10.0

really awful
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
0 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 Chevrolet Express:

Unsubscribe any time. We don't sell/share your email.

problem #1

Jun 282004

Express 8-cyl

  • miles
Problems while using cruise control on vehicle. When the cruise control was engaged and the brake pedal was pressed, the vehicle took a while before responding and reducing the speed of the vehicle. When the cruise control was set at 65 mph and going down grade, the van would pick up speed and never adjust back to 65 mph. If the speed went up to 70 mph the cruise control set itself at 70 mph. The consumer experienced other problems with the vehicle. The van would loose power when accelerating. The dealer replaced the PCM and reprogrammed it. While performing the engine diagnostic the technician found that the cap and rotor had moisture in them and were corroded. The vehicle's battery was also replaced because of a dead cell.

- Philadelphia, PA, USA

Add Complaint