hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
48,067 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 Chevrolet Silverado 2500:

Unsubscribe any time. We don't sell/share your email.

problem #2

Nov 022005

Silverado 2500 4WD 6-cyl

  • Automatic transmission
  • 59,134 miles
The contact stated the exhaust manifold warped and caused the studs to snap off. This could cause the exhaust to leak on a cold start. The vehicle was taken to the dealership, but has not yet been repaired. The contact's son-in-law discovered this problem after inspecting the vehicle because he had the same problem with his vehicle. He stated the original studs were too small, and the new studs were bigger. Left and right exhaust manifold bolts broke and were replaced.

- Cottage Grove, WI, USA

problem #1

Jan 062005

Silverado 2500

  • Automatic transmission
  • 37,000 miles
While driving under normal driving condition, no bump or obstacle on the road exhaust system separated and dropped, but stayed attached to its structure. The muffler dangled. The cause of the failure was unknown because the vehicle wasn't been inspected by a dealership nor mechanic.

- Baldwin, MI, USA