hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
90,135 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Chrysler Pacifica:

Unsubscribe any time. We don't sell/share your email.

problem #4

Jan 142014


  • 91,000 miles
Engine cradle is rusting out from inside frame out, popping large holes in the frame. Had to replace.Chrysler won't help at all with parts or cost.

- Wheeling, WV, USA

problem #3

Jul 052007

Pacifica 6-cyl

  • 40,539 miles
07/05/07 customer reported blower motor noisy, Chrysler checked and found blower motor noisy and replaced the blower motor. Cost to customer $179. On 08/11/10 blower motor noisy on high speeds, Chrysler removed and replaced the blower motor. Cost to customer $256. On 07/05/12 customer experiencing same problem with noisy blower motor. Will need to take vehicle to dealer to have blower motor replaced again.

- Sharon Hill, PA, USA

problem #2

Apr 262012

Pacifica 6-cyl

  • 129,000 miles
A follow up to earlier safety complaint.just ordered a computer for the affected vehicle and while describing the problem to the tech was informed that it is a well known problem affecting not only my Pacifica but their town and country mini van as well.

- Knoxville, TN, USA

problem #1

Apr 242012

Pacifica 6-cyl

  • 100,000 miles
This vehicle has suffered through a wide variety of problems as outlined from online complaint boards. Today has started sudden acceleration while stopped at traffic lights almost taking me into traffic your investigation on these are closed but I never had satisfaction speaking to Chrysler officials and was informed by my dealer a couple of years ago that the vehicle was made by the ;old; company and the new company does not honor problems.what is disturbing is that a close inspection by me has revealed that the wiring harness going to the control computer was routed under the drivers side flexible motor mount and the harness has been damaged by the mount compressing this harness right on top of a bolt on the frame causing fraying of several control wires.the poor design has indeed created most of the problems with the vehicle and could cause wrecks and perhaps even deaths. Chrysler has informed me they do not accept suggestions from the public but for the safety of the citizens still driving these vehicles, I see a lot on the road, please contact them as to this problem which while not covered under their warranty should be as this flaw only shows up with mileage. The wiring harness has not been priced by me yet but if past experience is the guide Chrysler parts are significantly higher than competitors, even if the last 'genuine' part had product of South Korea right on the box. The problem is poor design.

- Knoxville , TN, USA