6.3
fairly significant- Typical Repair Cost:
- $2,150
- Average Mileage:
- 92,400 miles
- Total Complaints:
- 7 complaints
Most common solutions:
- change erg/egr valve (2 reports)
- not sure (2 reports)
- replace dpfe sensor (2 reports)
- replaced coils and spark plugs (1 reports)
The check engine light came on and would not go off.
- Beth G., Mechanicsburg, PA, US
Check Engine light goes off and on in last 6 months on constantly.
- mrayfield, Granby, CO, US
changed erg sensor valve 2 times within 10,000 miles..costly and annoying
Update from Aug 11, 2016: Timing chain broke,$2500 to pull engine and replace,14 months later timing chain again, found out the 2008 mustang engine will fit right in its place, must change fuel injectors,valve covers,oil pan, runs great now! $4,000 in 14 months! 2002 ford explorer worst vehicle i ever owned!
- Ken W., Melvindale, MI, US
I replaced the ERG/EGR valve twice and there was never actually a problem with it my light wold come on for 1 to 2 day and then go off and i wouldn't see it again for 2 months.
- Alyssa S., Newark, OH, US
I was given an 02 ford explorer from my grandfather in january of 09 ive put 8,000 miles on it since then. i had to replace a battery twice in the same year, check enginge is repeatedly coming on after i pay to have it fixed, my gas pedal has stuck after taking it out of cruise control, brake lines r going. so basically i will never buy a ford peice of sh*t !!!! again.
- David F., Whitle Lk, MI, US
A sensor goes out for no apparent reason....Just make me a car that works consistently please.
- highwayman, Lemoore, CA, US
My 2002 Ford Explorer started running on seven cylinders on the way home one day. After O'Reilly auto part diagnosed it as a coil pack I purchased one and replaced it myself. The job was not that difficult but still a pain in the butt now that I know what all is wrong with my truck. Ford you should be reading my list of problems and offering me some kind of assistance getting this vehicle repaired. I have owned nine Fords in my lifetime, 5 of them new, but this one may be my last since you won't fess up to your poor engineering on this model truck.
- Terry P., Edwardsburg, MI, US