Both of the front window panels/trim on the outside flew off on the highway. Two different incidents. As if they are not properly installed because why are they so loose and flying off. Ford needs to fix this with a recall this is ridiculous

- Oak Harbor, WA, USA

I was driving on Interstate 75 Sunday April 30, when the Windshield A-Pillar molding trim, passenger side blew off and flew into the traffic behind me.

- Naples, FL, USA

The trim around my windshield on my driver's side blew off of the car. It is totally missing. Upon research, this appears to be a pretty common problem and it is very dangerous. Parts coming loose while driving could injure other drivers. No warning that the piece was loose. I am not sure who to report the problem to, I am going to call the dealership tomorrow and my warranty company. My concern is that the replacement piece may not stay on the car.

- Hulmeville, PA, USA

The Sync infotainment screen is inoperable and black. My backup camera is no longer operational. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 98,000.

- Hiram, ME, USA

While traveling at highway speed, the driver's side windshield pillar trim detached itself from the vehicle and flew into the roadway resulting in the following vehicle needing to take evasive maneuvers to avoid collision. In June of 2021 the passenger side piece also detached at highway speed and collided with the following vehicle. Ford does not offer a more robust replacement part, so there is no way for drivers to remedy this hazard.

- Maricopa, AZ, USA

While driving down the interstate a trim piece fllew off of my vehicle.. It was on the driver's side windshield support.

- Wisconsin Rapids , WI, USA

The windshield trim will not stay on-I will have to take in for replacement. I have already read this was an ongoing issue and was being investigated so I wanted to get my report in as well. This should be a recall issue.

- Royse City, TX, USA

Water pump leaking

- Tyler, TX, USA

No incident has occurred yet but I heard about the issue with the windshield parts coming loose. I have experienced the sound of air coming through the edges of the windshield when traveling on the highway. The sounds has gotten louder over time and I am always concerned that damage could occur during these travels.

- Huntington Beach, CA, USA

Roof rack rails have detached from my vehicle several times since purchasing my vehicle. The Ford dealership knows of the problem, attempted a brandade approach to solve the problem but has not fixed the problem. They used glue to try an fix a potential but that could result in the rail becoming detached on the freeway, flying off and striking another car and causing an accident. The right rail on my explorer came off on the freeway and luckily did not strike another vehicle. Despite knowing the problem and not accepting blame, my dealership asked me to pay for replacement rails. Ford should be instructed to recall all Ford Explorers with these rails and come up with a permanent fix before a major accident result in the death of someone.

- Fairfield, CA, USA

I bought a new Fire explorer in 2018 from Napleton Ford in Libertyville, IL. It has almost 22k miles in 2011. Early July, 2022, while driving, the Sync system of my car started failing. While reversing the car a few times, the screen went black, leaving me with a few seconds very distracted that could have led to a bad accident. It was an intermittent issue for a few days until the system completely stopped working when I was driving on a highway and suddenly lost all connectivity to my car Bluetooth and left with no USB power in the car or a way to start the back AC because it was Sync locked, eventually leading to a very unsafe drive on the highway. I took it to the dealership and they investigated to find the APIM module of the car had failed and it is a very common issue with Ford. It fails almost as soon as the warranty on the car expires. I feel cheated by Ford.

- Buffalo Grove, IL, USA

on May 25th I started my car and the dashboard indicated my engine is at critical stating its overheating. I immediately turned the car off and waited 10 minutes to restart the vechle assuming it was a malfunction because the vechle hasn't been driven since the day before. As I restarted the car no warning indicators lit and the vechle was normal as usual. I drove around the corner and noticed the vechle stalling with a slight jurk. I immediately drove into an auto shop to check what's going on. I told the rep what's happening with the car. they checked the oil and stated the coolant is mixing with the oil and that I need service right away. I asked if I get an oil change will it get me home around the corner. the rep stated it shouldn't be a problem. As I left it was fine, until I reached my driveway and the vechle just shut off. I then asked for help to push the vechle into the driveway by my neighbor and was able to put the car in neutral and moved into my driveway. I searched around to see recalls on fordpass app, it only stated that it was a new CSP on my vin to upgrade the high speed cooling fan relay and it's components stating it is known to either cause overheating or fire and that the relay will be replaced for vechles with millage at or below 150000 miles. I was in the clear and covered because I was at 126,600 miles. I remembered as I turned my vechle on it stated a critical indication of my engine overheating following me turning off the vechle and waiting 10 minutes and restarting with no warning indicators on. I contacted ford for service by requesting a tow to Brandon ford. The vechle was towed and the following day a service rep named Scott called stating he received the vechle and that it's gonna take a couple of days to get to, I said no problem. the next day I was contacted by Scott and was told my engine is seized and that no service is gonna be performed and to come pick my vechle up. I found recalls for 2019 and 2020 ford vechles but not 2018

- Seffner, FL, USA

Driving on freeway the driver side windshield A-Pillar trim came almost all of the way off and was flapping. We pulled it off by the one remaining attachment and drove home. Also noticed the passenger side A-Pillar trim was loose. Took to dealer. There was not a recall so we payed to have them replaced. The total cost was $655.96. These could have flown off of the vehicle and caused an accident.

- Colorado Springs, CO, USA

i SEEN WHERE THERE WAS A RECALL ON THE ROOF RACK COVERS ON EXPLORERS. MINE ON MY PASSENGER SIDE BLEW OFF IN THE WIND. SHOULD MY VEHICLE HAVE BEEN IN THIS RECALL. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

- North Adams, MI, USA

I was informed via mail several months ago there was a safety recall related to my 2018 Ford Explorer regarding the roof rail cover. My wife contacted our original dealership (Fairway Ford in Placentia) who stated that the repairs were unnecessary and refused to service the vehicle. In the past week I then received a safety recall reminder from Ford via mail and when I contacted their service representative (Bell; Today around 8:40 AM) she confirmed that the repairs were indeed necessary and she directed me to another dealership (Villa Ford in Orange) due to being informed of the refusal of Fairway Ford to perform the repairs.

- Placentia, CA, USA

Roof rack cover blew off while driving and snapped 3/4 of the cover off. Part was not recovered. Research shows this was an issue on the vehicle and there was a recall. When entering the vin # it shows no recalls?

- Newark, OH, USA

All of the components actually failed that were connected to in said computers Dean or data I am noticing that since we have connected our phones to this system and system and the Ford app we have seen constant problems with vehicle with vehicle has actually shut off while driving driving and lights are acting really weird would like to make sure that our identity theft data breach and hacking That has been done to us has not breached our vehicle's security systems within all said computer component Which can cause death dismemberment tdismemberment disharm or more please contact.

- Squaw Valley , CA, USA

2018 Ford Explorer Limited with rotten egg like smell/fumes emitted into the cab when increasing in speed. The smell became extremely strong to the point of having to roll down the windows. This has happened on multiple occasions.

- Grand Saline , TX, USA

Currently on 3rd day of owning vehicle. On second day, the presence of strong exhaust odor persisted throughout the day driving close to 90 miles. Heat was on around 72 with both head & floor pulling in fresh air. Had to open sunroof because of how strong odor became when sitting idle while stopping. There are no warning lights or anything that would be causing exhaust to enter car abnormally.

- Marlton , NJ, USA

The contact owns a 2018 Ford Explorer. The contact stated while driving 50 MPH in the rain, the vehicle stalled, and the windshield wipers seized. The contact stated that the message -€œtransmission not in the park-€ was displayed. The contact restarted the vehicle and drove to his residence. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer was not informed of the failure. The failure mileage was approximately 31,000.

- Windermere, FL, USA