5.2

fairly significant
Typical Repair Cost:
$970
Average Mileage:
63,950 miles
Total Complaints:
5 complaints

Most common solutions:

  1. replaced a/c compressor (3 reports)
  2. not sure (2 reports)
Get notified about new defects, investigations, recalls & lawsuits for the 2006 Ford Fusion:

Unsubscribe any time. We don't sell/share your email.

problem #5

May 282018

Fusion ES 3.0L V6

  • Automatic transmission
  • 84,506 miles

WHEN I JUMPED THE CONNECTION FOR RELAY, THE COMPRESSOR WORKED JUST FINE, COOL AIR AND EVERYTHING, BUT THE CLUTCHES ARE ALWAYS FULLY ENGAGED. NO FUSES KNOWN FOR THE CLUTCH, JUST A RELAY. NOT THE TEMPERATURE SENSOR UNDER THE DASHBOARD, LOOKING THE CURRENT JUST NOT GO TO THE RELAY TO PUT ON. THE CONTROL WORKED AND LITTLE LIGHT GOES ON. WEIRD PROBLEM AND ANNOYING.

THIS CAR SEEM TO HAVE A TENDENCY WITH ELECTRICAL PROBLEM. SMART JUNCTION BOX BLOWN A YEAR AGO AND WAS REPLACED. SUSPECTING THIS PROBLEM AGAIN.

AMERICAN CAR MADE BY MAZDA NOT EXACTLY HAPPY WITH IT. PROBABLY LAST FORD EVER.

- Alain C., Québec, Canada

problem #4

May 072015

Fusion SEL

  • Automatic transmission
  • 67,000 miles

Had A/C compressor fixed. Very expensive. Now another large outlay coming for another part for A/C. Very unhappy

- mhenn555, Rhinebeck, NY, US

problem #3

Jul 012008

Fusion

  • Automatic transmission
  • 69,000 miles

A/C died. Compressor problem. Was told it would be 7 hours of maintenance to repair because they would have to take the dash out and the part it needed cost about $50.

- amberp, Wilson, Nc, NC, US

problem #2

Jun 172010

Fusion SEL V6

  • Automatic transmission
  • 55,000 miles

I bought this POS brand new in 2006 and it has been in the shop 5 times. 1 time key stuck in the ignition. 2 times for the A/C. while they were fixing my A/C they( Ford) broke my radio and had to replace that. Then my moon roof stopped working. had to replace that. Now its leaking oil.I'm hoping whatever is wrong its covered by the extended warranty they were gracious enough to give me. WTF am I supposed to do. I love my car. But the hell with ford!!!

- deedee0118, Waldorf, MD, US

problem #1

Apr 172008

Fusion SE 3.0L V6

  • Automatic transmission
  • 44,000 miles

When I went to use the air conditioning in my Ford Fusion at the start of 2008, it did not blow cold air. I took the car to the dealer where they indicated the a/c compressor had failed and had to be replaced. After two trips (the first time they did not completely reseal everything and all the freon escaped) the problem was fixed but at a cost of almost $800!

- Shawn H., Cold Spring, KY, US