2007 Mercury Mountaineer
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2007 Mountaineer are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #DOR-S3J9G-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Read More »
-
TSB #062414
LOWER STEERING COLUMN SHAFT POP/CLUNK NOISE. *KB Read More »
-
TSB #08-2-8
IMPROVED BRAKE PEDAL FEEL AND FIRMNESS. *NJ Read More »
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
-
TSB #SSM 47331
Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
-
TSB #061713
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. Read More »
-
TSB #07253
FUEL FILL--SLOW OR EARLY SHUT OFF--BUILT BEFORE 11/28/2007. *NJ Read More »
-
TSB #06167
MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
-
TSB #SI-20005
FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. Read More »
-
TSB #SSM 51909
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. Read More »
-
TSB #SI-20005
FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. Read More »
-
TSB #0728
OVERHEAT INDICATION AND SHIFT QUALITY IMPROVEMENTS - CALIBRATION UPDATE RELEASE - 4.6L 3V WITH 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY. *KB Read More »
-
TSB #061713
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE. *KB Read More »
-
TSB #TSB-08-18-2
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. Read More »
-
TSB #TSB-08-9-5
FORD/MERCURY: 4.0L/4.6L HARD START/ROUGH RUNNING; AFTER LONG HOT SOAK/DIP IN RPM WHEN COMING TO A STOP; BUILT ON OR BEFORE 4/2/08. MAY EXHIBIT A DIP IN RPM BELOW NORMAL IDLE LEVEL OF 600 RPM ON DECELERATION. Read More »
-
TSB #20144
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN. COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ Read More »
-
TSB #19865
MULTIPLE VEHICLE LINES - INTERMITTENT PCM, FUEL PUMP, IGN, COIL, A/C, ABS OR FOG LAMP OPERATION. *NJ Read More »
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
-
TSB #TSB-08-19-3
FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Read More »
-
TSB #ASI-44429
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. Read More »
-
TSB #061710
MIL ON WITH P0463 OR ERRATIC FUEL GAUGE OPERATION. *KB Read More »
-
TSB #0782
THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C. *KB Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Read More »
-
TSB #SSM 47331
Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. Read More »