10.0
really awful- Crashes / Fires:
- 2 / 0
- Injuries / Deaths:
- 5 / 0
- Average Mileage:
- 117,263 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
The universal joint on the intermediate steering shaft corrodes and seizes causing a potential problem steering. It is a serious safety issue in my opinion. It is an on-going issue.
- North Berwick, ME, USA
This vehicle is covered in the Toyota rusty frame lawsuit. As such, it has been inspected by 2 different dealers and deemed not to need a frame replacement both times. It was treated with crc. Its last inspection was in November of 2018. On Sunday, May 17th, 2020, the frame broke at the front cross-member causing the left front lower control arm to separate and steering the vehicle/controlling the vehicle became near impossible. Fortunately for me, this happened in a parking lot backing out of a parking space and turning left (in reverse at low speed) after a full 2 weeks of driving in the mountains of West Virginia. I question all inspections of frames being performed within the Toyota dealer network and hope that nobody has this failure while they are driving at speed as the results will be catastrophic.
- Morgantown, WV, USA
Steering became very stiff while driving in town yesterday. Upon making a right turn at a familiar intersection, it became difficult to make the turn due to very stiff steering. The front end of my truck came very close to a vehicle coming into the intersection from the street I was turning into, and then the usual return of my wheels to straight ahead did not occur as expected, and I had to quickly force the steering wheel back before I ran up over the curb on my right. Luckily the car coming into the intersection had been far enough back from the intersection that we did not collide, and if I had not forced the steering wheel back at the end of the turn I may have hit pedestrians on the sidewalk. Upon investigating this problem with a mechanic immediately after the incident (yesterday afternoon) and at online forums, the most likely cause seemed to be the U-joint on the lower intermediate shaft of the steering column down just before the steering gear, just inside the left front wheel. Per some online forum advice, I used penetrating oil on that U-joint to loosen it, with good results (stiffness is now gone). But this seems most likely to be a temporary fix. I doubt that loosening the U-joint today will keep it from a repeat performance at some unknown and unpredictable time. Clearly this could cause accidents, and per online forums, it has apparently been a known issue for a while. There are no grease fittings on the U-joint, so there is no way to put a more permanent lubricant (grease) into the bearings of the U-joint. Also, the U-joint in question is not protected by a rubber boot, and is completely exposed to all the water, dirt, and salt that splashes up while driving. Others have noted that spraying with penetrating oil or the like is only a temporary fix, and the stiff steering problem returns after a time, making an accident much more likely.
- Kempton, PA, USA
Stiff steering while stationary. Difficult turning while moving after not using the vehicle for a time. This occurred after leaving the vehicle for 6 months or so at the dealer for a recall in 2012 or so. When I got the vehicle back it was ok but I don't know what they did to it. This problem just reoccurred last week after I did not use the vehicle for a while.
- Averill Park, NY, USA
The steering wheel get really tight and make it difficult to turn. It feels like it's going to lock up on me. Call Toyota and the dealer about it. They don't seem to care. Truck has 86,000 original miles on it.
- Middleville, MI, USA
Rusted front end passenger side component broke of the frame due to corrosion. Toyota warranty for repair expired 31 January 2019 and vehicle was taken to Toyota 2 months later and Toyota will not honor repair. Very disappointing on Toyota end. The rusted frame takes longer than 2 months to corrode. Toyota care not willing to work with me and fix there faulty and very unsafe product!
- Vineyard Haven, MA, USA
My 2006 Tacoma is very stiif steering wheel everytime I use the vehicle. Im afraid of accident waiting to happen.
- Belleville, NJ, USA
The steering on my Tacoma sometime stiffens and does not return back to center or sometimes you can barely turn the wheel left or right due to the lower intermediate shaft rusting in order to drive safely you have to temporarily put white lithium grease all over it because the design is wide open to road spray and salt I'm almost got into 5 head-on collisions.. and researching online this is a very common issue with these trucks and also very dangerous there should have been some kind of protection over the small U joint in the steering shaft spraying it with penetrating oil is only a temporary fix unfortunately this is a $500 repair and who knows how long it will last being unprotected once again
- Shelton, CT, USA
Truck has hard steering in any condition. Took to dealer deihl in butler pa. They told me it was the steering shaft. The dealer is great they replaced my frame rear springs all U joints and driveshafts.we were told this repair would cost $450 roughly. This is a known problem and should be covered too..
- Evans City, PA, USA
Steering locking up.took shaft off with U joint. Got ot to loosen upwith heat and lube.put back on till I can get new one.dtarting to lock up again. Had frame recall done.Toyota said no recall on joint at that time.
- Fort Ashby, WV, USA
Lower intermediate steering shaft U joint seized. It is small and exposed to the elements, and there is no protective covering. It is a dangerous piece to have fail. Many other Tacoma owners of the same model years experience this problem.
- Kapaa, HI, USA
Steering getting very stiff. Hard to steer and hard to return steering to straight after completing turn.
- East Pittsburgh, PA, USA
My steering wheel has become really stiff, because the #2 shaft steering was poorly desing, it's rusted and gets dirty because it doesn't have a boot or nothing covering it. Truck is stiff when turning, and almost gets stock when turning back to straight.
- Springfield, VA, USA
Steering has seized up. U joint constantly needs to be lubed.
- Abington, MA, USA
Lower intermediate steering shaft universal joint bearings rust resulting in the steering wheel being difficult the turn. Some of have reported the steering locking. The part number is: 45203-04020.
- North Berwick, ME, USA
The universal joint in the intermediate steering shaft has rusted, creating an unsafe condition. This joint in the steering column should have been protected from the elements by a boot, or some other means, to maintain lubrication and prevent this joint from rusting. Online research suggests this is a common, and very dangerous, problem. Due to the cost of this repair ($400- 500), many people may try to simply lubricate a damaged joint, possibly resulting in steering failure.
- Erie, PA, USA
The contact owns a 2006 Toyota Tacoma. While driving approximately 30 to 70 mph, the drive train vibrated uncontrollably, and the seat and steering wheel also vibrated. The manufacturer was notified. The dealer replaced the tires, but the failure recurred. The vehicle was not repaired. The VIN was unknown. The approximate failure mileage was 60,000.
- Kissimmee, FL, USA
Steering issue. When I turn the steering wheel I experience stiffness on/off on the turn. I noticed the U joint was rusted out. I sprayed it with silicone, worked fine for a while, now the stiffness is back. I believe Toyota needs to recall this U joint replacement. This is a huge safety issue
- Harmony, PA, USA
Steering issue. When I turn the steering wheel I experience stiffness on/off on the turn. I noticed the U joint was rusted out. I sprayed it with silicone, worked fine for a while, now the stiffness is back. I believe Toyota needs to recall this U joint replacement. This is a huge safety issue.
- Abington, MA, USA
- Margate, FL, USA