2007 Chevrolet Cobalt
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2007 Cobalt are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #PIC-5441
GM: THERE ARE MULTIPLE WARNING LIGHTS ON. THERE IS HARSH SHIFTING, HARD STEERING, AND NO START. THERE MAY BE MULTIPLE TROUBLE CODES STORED. *RM Read More »
-
TSB #060232002
NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT UPDATED 3/30/11. *PE Read More »
-
TSB #070232007
DIAGNOSTIC TIPS FOR POWER STEERING INOPERATIVE/STEERING WHEEL HARD TO TURN, POWER STEERING MESSAGE DISPLAYED ON DIC, DTC'S C0176, C0176, C0475, C0476, C0550, U2105, U2107 SET. *NJ UPDATED 2/17/10. Read More »
-
TSB #050232005
EI05093 - CLUNK NOISE IN STEERING SYSTEM AT SLOW SPEEDS WHILE TURNING AND/OR DRIVING OVER BUMPS. *TT (REPLACE INTERMEDIATE SHAFT). UPDATED 10/05/07. *NJ UPDATED 11/02/07 *NJ Read More »
-
TSB #050235007
INFORMATION ON INADVERTENT TURNING OF KEY CYLINDER, LOSS OF ELECTRICAL SYSTEM AND NO DTC'S. *KB Read More »
-
TSB #070235004
STEERING COLUMN RATTLE OR KNOCKING NOISE AT LOW SPEEDS (DIAGNOSIS AND REPLACE STEERING COLUMN, IF NECESSARY) *NJ Read More »
-
TSB #060235008
STEERING COLUMN SHUDDER, NOISE, VIBRATION WHILE MAKING RIGHT HAND TURNS AT 5-15 MPH. *KB Read More »
-
TSB #4145
STEERING COLUMN POP/RATTLE CONCERNS. *KB Read More »
-
TSB #060232002
NORMAL OPERATING CHARACTERISTICS OF ELECTRIC POWER STEERING (EPS) SYSTEM DURING EXTENDED LOCK-TO-LOCK (MAXIMUM STEERING WHEEL ROTATION) USAGE. *TT UPDATED 3/30/11. *PE Read More »
-
TSB #PIP5029G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
-
TSB #PI1394A
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. Read More »
-
TSB #030603004R
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. Read More »
-
TSB #000601012F
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. Read More »
-
TSB #000601026I
THIS INFORMATIONAL BULLETINS PROVIDES INFORMATION ON THE INTAKE MANIFOLD INSPECTION/REPLACEMENT AFTER SERVERE INTERNAL ENGINE DAMAGE. Read More »
-
TSB #PIP4548F
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN WHAT TO INSPECT IF CODES P0016 AND/OR P0017 ARE SETTING ON A PROPERLY TIMED ENGINE OR A CONDITION OF THE VEHICLE CRANKS BUT WILL NOT START. Read More »
-
TSB #SB-07-06-01-016C
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION INTERNAL ENGINE NOISE OR DAMAGE AFTER OIL FILTER REPLACEMENT Read More »
-
TSB #PI0817
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PIP4786C
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE LOW OIL PRESSURE MESSAGE. TECHNICIAN MAY ALSO FIND A DIAGNOSTIC TROUBLE CODE P0521 IN THE ENGINE CONTROL MODULE. Read More »
-
TSB #PIC-5441
GM: THERE ARE MULTIPLE WARNING LIGHTS ON. THERE IS HARSH SHIFTING, HARD STEERING, AND NO START. THERE MAY BE MULTIPLE TROUBLE CODES STORED. *RM Read More »
-
TSB #PIP-4495C
GM: THERE MAY BE NOISE COMING FROM THE CYLINDER HEAD, BECAUSE OF LOW OIL PRESSURE WHICH IS CAUSED BY DEBRIS. *RM Read More »
-
TSB #PIP-4416
INTERMITTENTSTALL WHEN COMING TO A STOP OR ENGINE CHUGGLES PRIOR TO A STOP, HYBRID DTC P1A6F. VEHICLES EQUIPPED WITH 4T45E TRANSMISSION INCLUDING HYBRID. *PE UPDATED 11/15/10. *PE Read More »
-
TSB #4175
INTERMITTENT SES LIGHT DUE TO DTC'S P060E, P2135, AND/OR P2138. *KB UPDATED 2/27/08. *NJ Read More »
-
TSB #4110
LONG CRANK, ENGINE WILL NOT START. *KB UPDATED 1/30/08. *NJ Read More »
-
TSB #4283
DRIVEABILITY/TACHOMETER ISSUES WITH VARIOUS DTC'S. *KB Read More »
-
TSB #4252
BUCK WHILE DRIVING, STALL, SES LIGHT, FLASH DOOR LOCKS CYCLE, CD PLAYER SKIP, CLOCK RESET. *KB Read More »
-
TSB #3404
MACHINING DEBRIS ON THE OIL FILTER ELEMENT. *SC Read More »
-
TSB #3859
LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ Read More »
-
TSB #3875
INTERMITTENT POWER LOSS IN HIGH AMBIENT TEMPERATURES WITH POSSIBLE DTC'S P0171, P0300, AND/OR P1133. *KB Read More »
-
TSB #030604017I
THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. Read More »
-
TSB #SB-08020
SATURN\CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOME 2004-07 SATURN ION RED LINE AND 2005-07 CHEVROLET COBALT SS VEHICLES, EQUIPPED WITH 2. Read More »
-
TSB #060849018
INACCURATE FUEL GAUGE READINGS, FUEL GAUGE READS EMPTY WHEN THER IS FUEL IN THE TANK, LOW FUEL MESSAGE DISPLAYED IN DIC, DTC P0461. *KB Read More »
-
TSB #SC-14728
PONTIAC/SATURN/CHEVROLET: SOME VEHICLES, WITH AN INLET CONTROL VALVE, HAVE A CRACKED FUEL TANK AND IT WILL CAUSE FUEL VAPOR OR A FUEL LEAK. MODEL 2006-08 COBALT, PURSUIT, G4, G5, ION. *PE UPDATED 11/18/15. Read More »
-
TSB #14728
14728 - SPECIAL COVERAGE. CERTAIN 2006 CHEVROLET COBALT, PONTIAC PURSUIT, PONTIAC G4, AND SATURN ION VEHICLES AND CERTAIN 2007 CHEVROLET COBALT, PONTIAC G5, AND SATURN ION VEHICLES AND CERTAIN 2008 CHEVROLET COBALT AND PONTIAC G5 VEHICLES ... Read More »
-
TSB #3627
FUEL TANK IS SLOW TO FILL AND/OR DTC P0446 - INSPECT EVAP VENT PIPE. THE SES LAMP MAY BE ILLUMINATED DUE TO A P0466 DTC. *TT UPDATED 08-15-07. *KB Read More »
-
TSB #SB-09275
SATURN/PONTIAC/CHEVROLET: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT; FUEL ODOR OR SPOTTING ON GROUND; REPLACE FUEL PUMP MODULE. Read More »
-
TSB #SB-12191
CHEVROLET/PONTIAC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON FUEL PUMP MODULE, PLASTIC SUPPLY OR RETURN PORT MAY BE CRACK AND WILL DEVELOP A FUEL LEAKAGE WHEREBY FUEL ODOR IS NOTICED, WHEN DRIVEN OR PARKED. Read More »
-
TSB #SB-12191-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-12191-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #RB-12190
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PI-0817
CHEVROLET/PONTIAC/SATURN: ENGINE FAILS TO START AFTER ENGINE CRANKS DUE TO FUEL PUMP WIRE HARNESS CONNECTOR NEEDS REPLACING, WITHOUT REPLACING FUEL PUMP COVER ASSEMBLY (FUEL PUMP FLANGE). MODEL 2007-2010 COBALT, G5, ION. Read More »
-
TSB #060604047
SES LIGHT ILLUMINATED, DTC'S P0171, P0300, P1133 SET, REDUCED PERFORMANCE, HARD START, INTERMITTENT LACK OF POWER. *KB Read More »
-
TSB #12190A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PIC5671D
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #09275B
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #14728A
14728A - SPECIAL COVERAGE (REVISED PART INFORMATION). CERTAIN 2006 CHEVROLET COBALT, PONTIAC PURSUIT, PONTIAC G4, AND SATURN ION VEHICLES AND CERTAIN 2007 CHEVROLET COBALT, PONTIAC G5, AND SATURN ION VEHICLES AND CERTAIN 2008 CHEVROLET ... Read More »
-
TSB #PIC-5671-C
CHEVROLET/PONTIAC: FUEL TANK COVER ASSEMBLY (NU6 EMISSION PACKAGE) CAN NOT BE ORDERED THRU DEALERSHIP DUE TO PARTS (25815572 AND 25948766) BEING PLACED ON RETRICTION THRU PRODUCT QUALITY CENTER (PQC). Read More »
-
TSB #PIC5671C
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PIC-5671-C
CHEVROLET/PONTIAC: FUEL TANK COVER ASSEMBLY (NU6 EMISSION PACKAGE) CAN NOT BE ORDERED THRU DEALERSHIP DUE TO PARTS (25815572 AND 25948766) BEING PLACED ON RETRICTION THRU PRODUCT QUALITY CENTER (PQC). Read More »
-
TSB #3876
FUEL GAUGE EMPTY OR LOW FUEL INDICATOR LIGHT - POSSIBLE DTC P0461. *KB Read More »
-
TSB #09275C
09275C - SPECIAL COVERAGE (REVISED PARTS). SOME 2006 MODEL YEAR CHEVROLET COBALT, PONTIAC G4, AND SATURN ION VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, ... Read More »
-
TSB #12191B
12191B - SPECIAL COVERAGE (REVISED PARTS). SOME 2006 MODEL YEAR PONTIAC PURSUIT, 2006-2007 MODEL YEAR SATURN ION, 2006-2009 MODEL YEAR CHEVROLET COBALT, 2007-2009 MODEL YEAR CHEVROLET EQUINOX, PONTIAC G5, AND TORRENT, AND 2008-2009 MODEL ... Read More »
-
TSB #SB-09275
SATURN/PONTIAC/CHEVROLET: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT; FUEL ODOR OR SPOTTING ON GROUND; REPLACE FUEL PUMP MODULE. Read More »
-
TSB #SB-12191
CHEVROLET/PONTIAC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON FUEL PUMP MODULE, PLASTIC SUPPLY OR RETURN PORT MAY BE CRACK AND WILL DEVELOP A FUEL LEAKAGE WHEREBY FUEL ODOR IS NOTICED, WHEN DRIVEN OR PARKED. Read More »
-
TSB #SB-12191-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #RB-12190
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #3932
TRANSMISSION FLUID LEAK SLIPPING CLUTCH OR BROKEN AXLE SHAFT. *KB Read More »
-
TSB #SB-03-07-29-004K
THIS INFORMATIONAL BULLETIN PROVIDE INFORMATION ON THE OPERATING CHARACTERISTICS OF A MANUAL TRANSMISSION. Read More »
-
TSB #PIP-4674
CHEVROLET/PONTIAC/SATURN: BLOCKED SHIFT, GEAR HOP OUT 1ST, 3RD, 5TH GEAR OR DIFFICULTY SHIFTING. THE SHIFT LEVER ON THE MANUAL TRANSMISSIONS ROLL PIN CAN BACK OUT AND CONTACT THE SHIFT COVER DURING A SHIFT EVENT. Read More »
-
TSB #070729001
MG3, M86 TRANSAXLE GRINDING/WHINING NOISE IN 3RD OR 4TH GEAR, EXCESSIVE ENGAGEMENT OR DISENGAGEMENT EFFORT WHILE SHIFTING INTO 3RD OR 4TH GEAR, WILL NOT SHIFT INTO EITHER 3RD OR 4TH GEAR. (REPLACE COMPLETE OUTPUT SHAFT ASSEMBLY). Read More »
-
TSB #3932
TRANSMISSION FLUID LEAK SLIPPING CLUTCH OR BROKEN AXLE SHAFT. *KB Read More »
-
TSB #3980
HARD TO SHIFT AND OR SLIPPING CLUTCH. *KB Read More »
-
TSB #PIP-3869-C
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN TO ASSISTANCE DIAGNOSING AND REPAIRING VEHICLES THAT MAY HAVE AN INTERMITTENT CONCERN WITH ANY OF THE TRANSMISSION ELECTRICAL OR COMMUNICATION DIAGNOSTIC ... Read More »
-
TSB #PIP-3869-B
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN TO ASSISTANCE DIAGNOSING AND REPAIRING VEHICLES THAT MAY HAVE AN INTERMITTENT CONCERN WITH ANY OF THE TRANSMISSION ELECTRICAL OR COMMUNICATION DIAGNOSTIC ... Read More »
-
TSB #14632B
14632B - SPECIAL COVERAGE (REVISED PART INFORMATION). ON SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE VEHICLE?S TRANSMISSION SHIFTER MAY NOT PROPERLY TRANSMIT AN ELECTRICAL SIGNAL THAT ALLOWS THE IGNITION KEY TO BE TURNED ... Read More »
-
TSB #PIP-4651
SATURN/PONTIAC/CHEVROLET: SOFT SHIFTS, ERRATIC SHIFTS, DTC P1811. VEHICLES WITH A HYDRAMATIC 4T45 TRANSAXLE MAY HAVE SOFT SHIFTS OR SHIFTS ERRATICALLY. THESE CONDITIONS MAY APPEAR INTERMITTENTLY OR SET A DTC P1811. Read More »
-
TSB #4252
BUCK WHILE DRIVING, STALL, SES LIGHT, FLASH DOOR LOCKS CYCLE, CD PLAYER SKIP, CLOCK RESET. *KB Read More »
-
TSB #070730005
4T45 TRANSMISSION, MIL/SES ON, DTC P1818, POWER DOOR LOCKS, CRUISE CONTROL, SHIFT INTERLOCK OR RETRACTABLE HARDTOP INOPERATIVE, ENGINE SPEED REVS LIMITED, HYBRIDS-AUTOSTOP, REGEN OR BOOST INOPERATIVE. (REPROGRAM TCM). Read More »
-
TSB #07153
TRANSMISSION CONTROL MODULE CALIBRATION CONCERN - REPROGRAM TRANSMISSION CONTROL MODULE (TCM). *KB Read More »
-
TSB #0707129001
EI07280 - KEY CAN NOT BE REMOVED FROM IGNITION WITH TRANSAXLE SELECTOR IN PARK, SHIFTER CAN NOT BE MOVED FROM PARK POSITION (DIAGNOSE USING SI). *NJ Read More »
-
TSB #3932
TRANSMISSION FLUID LEAK SLIPPING CLUTCH OR BROKEN AXLE SHAFT. *KB Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #16NA241
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO CHECK THE CYLINDERS FOR DAMAGED PISTONS AND DETERMINE IF THE USE OF AFTERMARKET CALIBRATIONS OR PERFORMANCE PARTS MAY BE THE CAUSE. Read More »
-
TSB #PIT5074J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT THE USE OF J-35616-64B TERMINAL TEST PROBE, REPLACEMENT TERMINALS, AND TERMINATED LEADS. Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5050-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIC4935E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #PIT5074F
GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR ... Read More »
-
TSB #PIC-5073B
CHEVROLET/PONTIAC: VARIOUS ELECTRICAL CONCERNS. SIR LIGHT, IP LIGHTS FLICKER/INOPERATIVE, PARKING LAMPS FLICKER/INOPERATIVE, TAIL LAMP DIM/INOPERATIVE, TRUNK OPEN LIGHT, RADIO INOPERATIVE DOOR LOCK INOPERATIVE, NO START, NO CRANK. Read More »
-
TSB #4110
LONG CRANK, ENGINE WILL NOT START. *KB UPDATED 1/30/08. *NJ Read More »
-
TSB #030603004R
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. Read More »
-
TSB #SB-15-06-03-001B
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION THAT MAY BE USEFUL ON DIAGNOSING BATTERIES THAT HAVE SET FOR A LONG PERIOD OF TIME AND/OR SET IN COLD WEATHER CLIMATES AND TESTING THOSE BATTERIES. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #SB-03-06-03-004Q
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDE POLICY INFORMATION ON USING THE EL-50313 MIDTRONICS GR8 BATTERY TESTER/CHARGER FOR DIAGNOSING BATTERY REPLACEMENTS AND MAINTAINING BATTERIES ON NEW VEHICLES IN DEALER INVENTORY. Read More »
-
TSB #PIP-3869-C
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN TO ASSISTANCE DIAGNOSING AND REPAIRING VEHICLES THAT MAY HAVE AN INTERMITTENT CONCERN WITH ANY OF THE TRANSMISSION ELECTRICAL OR COMMUNICATION DIAGNOSTIC ... Read More »
-
TSB #PIP-3869-B
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN TO ASSISTANCE DIAGNOSING AND REPAIRING VEHICLES THAT MAY HAVE AN INTERMITTENT CONCERN WITH ANY OF THE TRANSMISSION ELECTRICAL OR COMMUNICATION DIAGNOSTIC ... Read More »
-
TSB #PI-0817
CHEVROLET/PONTIAC/SATURN: ENGINE FAILS TO START AFTER ENGINE CRANKS DUE TO FUEL PUMP WIRE HARNESS CONNECTOR NEEDS REPLACING, WITHOUT REPLACING FUEL PUMP COVER ASSEMBLY (FUEL PUMP FLANGE). MODEL 2007-2010 COBALT, G5, ION. Read More »
-
TSB #PIC-4578
EPS/STR WHEEL CONTROL FUSE (#19) OPEN. *KB UPDATED 10/04/07. *NJ UPDATED 8/7/09. *PE UPDATED 8/1/11. *PE Read More »
-
TSB #PIC3385
REPEATED PARK LPS FUSE OPEN. *KB (ADDITIONAL INFORMATION) UPDATED 4/1/08. *NJ Read More »
-
TSB #14632B
GENERAL MOTORS: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. 2003-2010 CHEVROLET COBALT, HHR , PONTIAC SOLSTICE, PONTIAC G5, PONTIAC G4 , SATURN SKY, SATURN ION. Read More »
-
TSB #14632B
THIS TSB CONTAINS OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. GENERAL MOTORS 2003-2011 VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, UNABLE TO REMOVE IGNITION KEY. *LJ Read More »
-
TSB #14632
GENERAL MOTORS 2005-2011 CHEVROLET COBALT, HHR 2006-2010 PONTIAC SOLSTICE, G5,G4,2007-2010 SATURN SKY , 2003-2007 SATURN ION: SEE DOCUMENT SEARCH BUTTON FOR OWNERS LETTER. Read More »
-
TSB #G-206561
14632 - SPECIAL COVERAGE. ON SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE VEHICLE?S TRANSMISSION SHIFTER MAY NOT PROPERLY TRANSMIT AN ELECTRICAL SIGNAL THAT ALLOWS THE IGNITION KEY TO BE TURNED COUNTER CLOCKWISE PAST THE ... Read More »
-
TSB #SB-0000193040-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000191604-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000190649-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000189719-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-12089
CHEVROLET/PONTIAC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A BINDING CONDITION HAS OCCUR BETWEEN THE HOUSING AND IGNITION LOCK CYLINDER WHICH MAKES THE IGNITION KEY DIFFICULT TO TURN OR REMOVE FROM IGNITION. Read More »
-
TSB #13454C
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000193040-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #13454B
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000190527-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-00000189718-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000189716-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #13454
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #13454A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000188486-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000187754-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000187705-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000186726-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000185373-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-12089
CHEVROLET/PONTIAC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A BINDING CONDITION HAS OCCUR BETWEEN THE HOUSING AND IGNITION LOCK CYLINDER WHICH MAKES THE IGNITION KEY DIFFICULT TO TURN OR REMOVE FROM IGNITION. Read More »
-
TSB #PIT4720D
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS ... Read More »
-
TSB #PIC-5408
GM: THE FOG LAMP INDICATOR IS INOPERATIVE. *RM Read More »
-
TSB #SB-09-09-41-004
DAEWOO/SATURN/OPEL/PONTIAC/CHEVROLET: INSTRUMENT PANEL CLUSTER (IPC) AIR BAG INDICATOR ILLUMINATED (INSTALL PROTECTIVE MATERIAL). Read More »
-
TSB #3799
SIR LIGHT ON/SERVICE AIRBAG WARNING MESSAGE WITH DTC B0081. *TT UPDATED 03-01-07. *KB UPDATED 04-06-07. *KB Read More »
-
TSB #15-08-44-001H
THIS INFORMATIONAL BULLETIN PROVODES INFORMATION ON THE GM OF CANADA ONSTAR CELLULAR COMMUNICATION UPGRADE. Read More »
-
TSB #SB-06-08-47-001L
THIS INFORMATIONAL BULLETIN PROVIDES WARRANTY INFORMATION ON USING THE SERVICE PROGRAMMING SYSTEM (SPS) FOR PROGRAMMING CONTROL MODULES Read More »
-
TSB #3347
BRAKE LIGHTS INOPERATIVE WITH KEY IN THE OFF POSITION. *TT Read More »
-
TSB #PIC5260A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PI-0754-B
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON A NORMAL CONDITION ON TEMPERED GLASS OF SPOTS SHOWING ON THE REAR AND SIDE WINDOWS WHEN THE VEHICLE IS IN THE SUNLIGHT. Read More »
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
-
TSB #SB-08-09-41-002C
GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. Read More »
-
TSB #SB-09-09-40-003
CHEVROLET/PONTIAC: SIR/AIRBAG LIGHT ILLUMINATED, DTC B0081 AND PASSENGER PRESENCE SYSTEM (PPS) CODE 23 STORED (REPLACE PASSENGER SEAT BELT RETRACTOR AND RE-ROUTE WIRE HARNESS). *PE UPDATED 3/4/11. Read More »
-
TSB #SB-09-09-41-003
CHEVROLET/PONTIAC: THE SIR/AIRBAG LIGHT IS ILLUMINATED. UPON INVESTIGATION, THE TECHNICIAN MAY FIND DTC B0081 SET. *PE Read More »
-
TSB #TB-080941006B
GENERAL MOTORS: THE SIR LIGHT IS ILLUMINATED. DTC B0081 PASSENGER PRESENCE SYSTEM (PPS) CODE STORED (INSPECT PPS SYSTEM CONNECTORS). *PE Read More »
-
TSB #TSB-09-09-41-002
GENERAL MOTORS: SIR/AIRBAG LIGHT ILLUMINATED, PASSENGER PRESENCE SYSTEM (PPS) DTCS 023, 024, 063, 064, 065 SET (INSPECT PPS SYSTEM WIRING AND/OR CONNECTORS). *PE Read More »
-
TSB #4011
AIR BAG INDICATOR LIGHT IS ON. *KB UPDATED ON 12/13/07. *NJ Read More »
-
TSB #08-09-41-006
SIR/AIR BAG LIGHT ILLUMINATED, DTC B0081 (PASSENGER PRESENCE SYSTEM (PPS) CODE) STORED (INSPECT PPS SYSTEM CONNECTORS). *PE UPDATED 5/22/09. *PE UPDATED 4/22/13. *PE Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
-
TSB #05-09-40-002E
GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
-
TSB #PIT-3749D
GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB Read More »
-
TSB #PIC-5260-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #4252
BUCK WHILE DRIVING, STALL, SES LIGHT, FLASH DOOR LOCKS CYCLE, CD PLAYER SKIP, CLOCK RESET. *KB Read More »
-
TSB #PI-0011A
GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. Read More »
-
TSB #PIC-4336B
GMC: POWER DOOR LOCKS CYCLING OR INOPERATIVE FROM THE SWITCHES WHEN DRIVING. *PE Read More »
-
TSB #00-03-10-006M
THIS INFORMATIONAL BULLETIN PROVIDES GUIDANCE TO GM DEALERS WHEN USING GM APPROVED TIRE FORCE VARIATION MEASUREMENT EQUIPMENT. Read More »
-
TSB #050310011
18 INCH ACCESSORY WHEELS AVAILABLE THROUGH GMSPO. *TT Read More »
-
TSB #SB-09-09-40-003
CHEVROLET/PONTIAC: SIR/AIRBAG LIGHT ILLUMINATED, DTC B0081 AND PASSENGER PRESENCE SYSTEM (PPS) CODE 23 STORED (REPLACE PASSENGER SEAT BELT RETRACTOR AND RE-ROUTE WIRE HARNESS). *PE UPDATED 3/4/11. Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #00-03-10-006M
THIS INFORMATIONAL BULLETIN PROVIDES GUIDANCE TO GM DEALERS WHEN USING GM APPROVED TIRE FORCE VARIATION MEASUREMENT EQUIPMENT. Read More »
-
TSB #PIC5260A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
-
TSB #PIT4720D
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS ... Read More »
-
TSB #14728
14728 - SPECIAL COVERAGE. CERTAIN 2006 CHEVROLET COBALT, PONTIAC PURSUIT, PONTIAC G4, AND SATURN ION VEHICLES AND CERTAIN 2007 CHEVROLET COBALT, PONTIAC G5, AND SATURN ION VEHICLES AND CERTAIN 2008 CHEVROLET COBALT AND PONTIAC G5 VEHICLES ... Read More »
-
TSB #PIT3271G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT CHANGING THE TIRE AND WHEEL SIZE ON VEHICLES. Read More »
-
TSB #SB-0000191604-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #SB-0000191608-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PI0373A
THIS PRELIMINARY INFORMATIONAL BULLETIN PROVIDES A PROCEDURE FOR RELEARNING THE POWER FOLDING MIRRIORS AND ROAD TESTIN TO VERIFY THEY CORRECT A CONDTION OF THE POWER FOLDING MIRRIORS GLASS SHAKES, FLUTTERS AT NORMAL DRIVING CONDITIONS. Read More »
-
TSB #PIC4707E
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN TO DIAGNOSE THE CONCERN AND THE STEPS TO REPAIR THE CONCERN. THE VEHICLE'S XM TRAVEL LINK MAY BE INOPERTIVE. Read More »
-
TSB #PIC5050A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #PIC5088F
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS. Read More »
-
TSB #4252
BUCK WHILE DRIVING, STALL, SES LIGHT, FLASH DOOR LOCKS CYCLE, CD PLAYER SKIP, CLOCK RESET. *KB Read More »
-
TSB #PIC-5374-D
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN OF RECEIVING FREQUENT "OFF ROUTE" MESSAGES WHILE FOLLOWING TURN BY TURN (TBT) ROUTE NAVIGATION. Read More »
-
TSB #PIC5374D
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN OF RECEIVING FREQUENT "OFF ROUTE" MESSAGES WHILE FOLLOWING TURN BY TURN (TBT) ROUTE NAVIGATION. Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIT5389A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #04-00-89-015M
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDES POLICY INFORMATION ON USING GM SERVICE POLICIES AND PROCEDURE MANUAL THAT REPRESENT KEY GM REQUIREMENTS FOR SERVICE OPERATIONS. Read More »
-
TSB #SB-03-06-03-004Q
THIS WARRANTY ADMINISTRATION BULLETIN PROVIDE POLICY INFORMATION ON USING THE EL-50313 MIDTRONICS GR8 BATTERY TESTER/CHARGER FOR DIAGNOSING BATTERY REPLACEMENTS AND MAINTAINING BATTERIES ON NEW VEHICLES IN DEALER INVENTORY. Read More »
-
TSB #G-206857
14632 - SPECIAL COVERAGE (Q&A). ON DECEMBER 11, 2014, GENERAL MOTORS RELEASED SPECIAL COVERAGE ADJUSTMENT 14632. THE TOTAL NUMBER OF U.S. VEHICLES INVOLVED IS APPROXIMATELY 1.9 MILLION. Read More »
-
TSB #SB-0000189716-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #10-00-89-017C
GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM Read More »
-
TSB #4014
PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB Read More »