My car was involved in the ignition recall...took it in had it all fixed. Now that same switch has gone faulty again. The car will not turn over. Acts just like the starter is going out, it slow to start and gets worse and worse till it will no longer start. I have had the battery replaced and starter(due to that seemed to be the issue. After digging deeper into the diagnostic code I have discovered that switch keeps coming up as an issue.

- Las Vegas, NV, USA

After abiding by the recall to change the ignition switch, the car starts freaking out randomly. The dash lights start going on and off. Loose power steering, power brakes and the car just stops. You can be going 70 miles an hour down the highway and the car just gives out. The dealership refuses to fix it unless I am willing to pay all the fees. I had a second dealership replace some fuses but after 2 days it started doing it again. After the first episodes, I called and opened a ticket with Chevrolet, but because the dealership I used didn't want to mess with the car any more they were not very helpful. Now I am driving a death trap because I can't afford a new car and I won't let my children drive or be in the car.

- Ballwin, MO, USA

Turn ignition switch off while car out of gear causing it to roll freely.

- West Columbia, SC, USA

There was a recall for the ignition on the HHR, I had the ignition changed but on the way home the locks unlocked and locked several times, then the cruse kicked off, the radio stopped working, the lights on the instrument cluster went off and on, and the motor stopped. I have contacted GM several times but they say the ignition change had nothing to do with it. This has happened several times since and also had to remove the fuse for the radio, because it would run the battery down. This has happened several times when we have driven it over the last couple of years. I former mechanic that worked for a GM dealer said that there is a electrical unit that the ignition controlled and that with the problem with the ignition caused the problem with the electrical unit. We do not drive the vehicle much because it doesn't feel safe driving it, nor would we sell it, because of the problems.

- Onawa, IA, USA

I was driving to my family's home on christmas, when my car suddenly began to smell like burnt rubber inside of the car. It was raining on that day. Suddenly the cars ac, or H vac did not work anymore. Upon googling things of what it could be, I found out that the resistor and blower motor had been burnt do to be allowing water to enter the blower motor panel from the outside of the car. Upon looking at my blower motor and resistor I found evident burn marks on them. GM should investigate how rainwater can enter the cars blower motor causing a burning smell in a inhalation of fumes of burning plastic. Not to mention my ability not to see out of the window due to the defrost not working. This is a safety concern!!

- Alcoa, TN, USA

The contact owns a 2006 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA campaign number: 14V171000 (electrical system). While driving approximately 40 mph the vehicle stalled after the engine power greatly reduced and engine disabled warning indicators illuminated. The vehicle did restart; however, the failure recurred every 20 minutes on several occasions. The vehicle would restart after approximately 10 minutes. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure and informed the contact that the recall repair was guaranteed for one year. The approximate failure mileage was 148,000.

- Taunton, MA, USA

The contact owns a 2006 Chevrolet HHR. The contact stated that the engine was turned off and a chime sounded. The contact then turned on and powered off the vehicle again when the chime suddenly deactivated. The failure recurred whenever the engine was turned off. The vehicle was taken to the dealer, who informed that the ignition switch needed to be replaced. In 2014, the vehicle was serviced under NHTSA campaign number: 14V047000 (air bags, electrical system). The manufacturer was not notified of the failure. The failure mileage was unavailable.

- Belle Glade, FL, USA

The contact owns a 2006 Chevrolet HHR. While driving approximately 30 mph, the steering wheel seized and excessive force was required to maneuver the vehicle. The power steering assist warning light illuminated. The failure recurred intermittently. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000. MA 10/26/2015

- Kaukauna, WI, USA

The contact owns a 2006 Chevrolet HHR. The contact stated that NHTSA campaign number: 14V171000 (electrical system) was performed; however, the repair did not correct the failure. The vehicle stalled several times. In addition, when the gear was shifted into park, the ignition switch failed to turn to the off position and the key did not release from the ignition switch. The battery was disconnected to be able to shut the engine off. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 160,000.

- Morrow, GA, USA

The contact owns a 2006 Chevrolet HHR. The contact received a recall notification for NHTSA campaign number: 14V047000 (air bags, electrical system) and stated that the part needed for the repair was unavailable. The manufacturer was not notified of the issue. The contact had not experienced a failure.

- San Juan, PR, USA

The contact owns a 2006 Chevrolet HHR. The vehicle jerked whenever the contact shifted gears. The failure occurred whether the vehicle were in drive, neutral, or reverse. The contact received a notification for NHTSA campaign number: 14V171000 (electrical system). The contact adhered to the recall; however, the failure recurred. The vehicle was taken to an independent mechanic, who diagnosed that the ignition switch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 181,732.

- Asheville, NC, USA

The contact owns a 2006 Chevrolet HHR. The contact received notification of NHTSA campaign number: 14E021000 ( electrical system); however, the part needed to perform the recall repair was unavailable. The contact stated that the manufacturer exceed a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure.

- Leigh High, FL, USA

Was going down the road app 35 mph car suddenly dies stop restarted car and it drove normally, a few days later while using the turn signal switch the dash lights and gauges stop working now we are getting the sound of a electrical popping or snapping in the dash and the dash lights will still intermittently stop working or flashing. All of this after the recall work was done.

- Fayette , AL, USA

The contact owns a 2006 Chevrolet HHR. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA campaign number: 14V047000 (air bags, electrical system). However, the dealer failed to replace the ignition switch as stated on the recall notification. The contact mentioned that only the keys were replaced. The manufacturer was made aware of the issue. The contact had not experienced a failure.

- Sebring, FL, USA

The contact owns a 2006 Chevrolet HHR. After the vehicle was serviced under NHTSA campaign numbers: 14V047000 (air bags, electrical system) and 14V171000 (electrical system), the steering wheel seized and the vehicle stalled. The vehicle was able to restart. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was not available.

- Columbus, GA, USA

The contact owns a 2006 Chevrolet HHR. The contact stated that the instrument panel shorted intermittently and caused electrical failures within the vehicle. The contact mentioned that the steering wheel was extremely tight and intermittently locked without warning. Upon using the cigarette lighter, smoke emitted inside the vehicle indicating that there was an electrical fire with the wires. The fire extinguished without having to contact the fire department. The vehicle was not inspected and diagnosed. The vehicle was included in NHTSA campaign numbers: 14V171000 (electrical system) and 14V047000 (air bags, electrical system) but was unable to determine when the recall repair would be performed. The manufacturer was not notified of the failure. The approximate failure mileage was 80,000.

- Chicago, IL, USA

Received letter from Chevrolet dated 1-2015 stating that "some 2006 HHR's" may have a defect which causes power steering (ps) to fail at any time. Called local dealer to have it repaired but my car (VIN) is not on the recall list. The exact sequence of ps failure described in letter has occurred with my car multiple times but they, Chevrolet dealer, does not guarantee that this will be fixed without my paying the bill as it (VIN) is not on their list. My car should be entered into the recall list as this is a manufacturers mechanical defect and needs to be recalled and repaired at GM's cost. This is the 3rd letter (recall) on this car; ignition cylinder, transmission lock and now power steering!

- Poolesville, MD, USA

While driving in trailer park, power steering failed struggled to park. Next day problem seemed to right itself. Scary.

- Apache Junction, AZ, USA

I have had numerous problems first off my dash lights will flicker while driving sometimes the radio and dash won't work at all, backs of my driver and passenger seats have fallen off, both driver and passenger door handles are broke the drivers handle is completely broke off, also when it rains my passenger floor board fills up with water, my seats are so dirty looking cause something keeps bleeding through upholstery, ignition and shift lever had to be replaced today cause car wouldn't go into park and key wouldn't come out!! also the car used to slide when on a corner or rough road!! this is ridiculous!! the door handles is a safety hazard god for bid if I'm in a wreck or my car starts on fire I won't be able to get out of my car and I can't afford to have them fixed right now because I recently lost my job!!

- Duncan, AZ, USA

Contact reported that door locks would not operate with key fob nor when activating the door lock switches on the door. Took vehicle to two different dealers trying to get the ignition recall fixed which took a total of four visits. While car was in for recall, addressed an unrelated electrical solenoid problem and asked the dealer to look at the door lock issue. Dealer notified owner that passenger door and rear seat left and right door lock actuators had failed (3 of 4 total). Asked dealer if they had seen this unusual condition on any other HHR's and they said no. Showed them the 30+ issues logged on this site and they only commented that the HHR was not the best GM product ever built but there was no dealer fix for this issue. Contact was advised that it would be $340 per door to fix and service was declined (after $80 diagnostic charge to verify that door locks did not work).

- Fayetteville, GA, USA