1997 Chevrolet Malibu
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1997 Malibu are official communications between Chevrolet & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #060235019
REVISED TILT STEERING WHEEL AND COLUMN FASTENER TIGHTENING SPECIFICATIONS. *KB Read More »
-
TSB #01292004
POWER STEERING GEAR LOWER PINION BEARING, SAFETY RECALL 03062. *TT Read More »
-
TSB #030232049
RELEASE OF NEW OUTER TIE ROD ENDS FOR SERVICE. *TT Read More »
-
TSB #010308003A
SOME CUSTOMERS MAY COMMENT ON A SQUAWK NOISE FROM THE FRONT AND/OR REAR SUSPENSION WHILE DRIVING. *TT Read More »
-
TSB #010308003
INFORMATION REGARDING SQUAWK NOISE FROM FRONT AND/OR REAR SUSPENSION. *YH Read More »
-
TSB #050901
SOME CUSTOMERS MAY COMMENT OF A SQUAWK NOISE FROM THE FRONT OR REAR SUSPENSION AREA. *SLC Read More »
-
TSB #990308004
SUBJECT PERTAINING TO FRONT AND / OR REAR STABILIZER SHAFT SQUAWK / SQUEAK NOISE. *TT Read More »
-
TSB #98733210
LOW PITCH RATTLE, CLUNK AND/OR SQUEAK NOISE COMING FROM FRONT END OF VEHICLE DURING LOW SPEEDS. *YC Read More »
-
TSB #32
CUSTOMERS MAY COMPLAIN OF A CREAK OR POP NOISE FROM THE REAR OF THE VEHICLE, THIS MAY OCCUR ON TURNS, ON ACCELERATION OR DECELERATION, OR ON MANEUVERS THAT TWIST THE SUSPENSION. *SLC Read More »
-
TSB #000309003
SOME VEHICLES BUILT PRIOR TO VIN BREAKPOINT 1M531582 OR 16145701 MAY EXHIBIT A CREAK / POP NOISE COMING FROM THE REAR OF THE VEHICLE. *TT Read More »
-
TSB #050523001
REVISED BRAKE SYSTEM SPECIFICATIONS. *TT Read More »
-
TSB #000523002B
FRONT DISC BRAKE PULSATION. *TT Read More »
-
TSB #98835023
EXPERIENCING A SQUEAK /SQUAWK TYPE NOISE WHEN BRAKE PEDAL DEPRESSED. *YC Read More »
-
TSB #210602
INFORMATION REGARDING THE BRAKE ALIGN KIT. *TT Read More »
-
TSB #051502
ADDITIONAL INFORMATION ON REPEAT BRAKE PULSATION AFTER AN INITIAL BRAKE REPAIR. *TT Read More »
-
TSB #020522001
SERVICE MANUAL UPDATE REGARDING REVISED BRAKE SPECIFICATIONS. *TT Read More »
-
TSB #010522001
VEHICLES MAY EXPERIENCE CLUNK, RATTLE NOISE FROM THE UNDERBODY OR FRONT SUSPENSION. *JB Read More »
-
TSB #121200
SOME CUSTOMERS MAY COMMENT ON A BRAKE PEDAL RATTLE OR CLUNK. *TT Read More »
-
TSB #990523001A
SOME OWNERS MAY COMMENT ABOUT A SQUEALING TYPE NOISE COMING FROM THE FRONT BRAKES DURING A BRAKE APPLICATION. *TT Read More »
-
TSB #990523001
CUSTOMERS MAY COMPLAIN A SQUEALING NOISE COMING FROM THE FRONT BRAKES. *TT Read More »
-
TSB #735008
SQUEALING NOISE COMING FROM FRONT BRAKES (INSTALL NEW BRAKE PADS). *TW Read More »
-
TSB #022603
BRAKE PAD REPLACEMENT. *TT *JB Read More »
-
TSB #010523005
INFORMATION PERTAINING TO PROPER INSTALLATION OF FRONT BRAKE PADS WITH WEAR INDICATOR. *TT Read More »
-
TSB #970801735026
COMMENT THAT THE ABS LIGHT IS ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) 46 AND 86 SET AS CURRENT OR HISTORY. *YC Read More »
-
TSB #070201
INCORRECT OUTER BACKING PLATE. OUTER BACKING PLATE HAS SHORT CENTRE PROTUSION. OUTER BACKING PLATE SHOULD HAVE TALL CENTER PROTRUSION. *KB Read More »
-
TSB #4615
ABS PUMP RUNNING WHEN NOT NEEDED. *NJ Read More »
-
TSB #04152004
VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES. GM VOICEMAIL EXPRESS. *TT Read More »
-
TSB #00966B
ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT Read More »
-
TSB #00966
ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS. *TT Read More »
-
TSB #9702019774T
VARIOUS INFORMATION REGARDING OVERNIGHT COLD SOAK CONDITIONS. *YC Read More »
-
TSB #010601002A
REVISED PISTON PIN REMOVAL / INSTALLATION PROCEDURE. *TT Read More »
-
TSB #10172002
ENGINE STARTS AND IMMEDIATELY STALLS AND THEN CAN BE RESTARTED AND WILL RUN NORMALLY. *TT Read More »
-
TSB #970501776109
EXHIBITING DIAGNOSTIC TROUBLE CODES P0300, P0301, P0302, P0303, AND P0304 INDICATING ENGINE MISFIRE CONDITIONS. *YC Read More »
-
TSB #020601014
SUBJECT REGARDING REVISED LOWER INTAKE MANIFOLD INSTALLATION. *TT Read More »
-
TSB #010601010A
SUBJECT REGARDING POLYMER SERVICE PISTONS. *TT Read More »
-
TSB #990604005A
SOME OWNERS MAY COMMENT ON DRIVEABILITY SYMPTONS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT Read More »
-
TSB #130301
EXPERIENCING A NO CRANK NO START, CRANK NO START, NO START OR A START DOESN'T RUN THAT MAY BE ACCOMPANIED BY A THEFT SYSTEM LIGHT AND / OR A SERVICE ENGINE SOON LIGHT. *TT Read More »
-
TSB #000604005
SOME OWNERS MAY COMMENT ON A COLD ENGINE IDLE HUNT OR SURGE. *TT Read More »
-
TSB #990604005
SOME OWNERS MAY EXPERIENCE A DRIVEABILITY SYMPTOM OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE. *TT Read More »
-
TSB #876002A
SOME V6 ENGINES MAY, ON A VERY INFREQUENT BASIS, HAVE AN OIL ODOR CONDITION THAT IS GENERALLY ENCOUNTERED AFTER THE ENGINE'S OIL HAS BEEN CHANGED. Read More »
-
TSB #98576124A
COMMENTS ON A TICKING TYPE NOISE THAT BEGINS SHORTLY AFTER COLD ENGINE START-UP AND GRADUALLY DIMINISHES AS THE ENGINE WARMS UP. *YC Read More »
-
TSB #970701776517
EXPERIENCES WITH UNSTABLED ENGINE IDLE. *YC Read More »
-
TSB #010602012
SOME OWNERS MAY COMMENT ON LEAKAGE OF A FEW DROPS OF COOLANT AFTER PARKING THEIR VEHICLE. *TT Read More »
-
TSB #676204
COOLANT LOSS, VISIBLE COOLANT LEAKAGE, LOW COOLANT LAMP ON OR COOLANT ODOR CAUSED BY COOLANT LEAKAGE. *TW Read More »
-
TSB #971101776529
SUBJECT PERTAINING TO INSTRUMENT CLUSTER RESETS WHEN ON-BOARD HAM RADIO IS KEYED. *YC Read More »
-
TSB #971101776304
SUBJECT PERTAINING TO DRIVEABILITY SYMPTOMS DUE TO FUEL INJECTOR DEPOSITS. *YC Read More »
-
TSB #98776304A
SOME VEHICLES MAY EXPERIENCE A DRIVEABILITY SYMPTOM OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE. *YC Read More »
-
TSB #030849015
FUEL GAUGE NEEDLE RESET PROCEDURE AFTER BATTERY DISCONNECT/REPLACEMENT WITH KEY IN ON POSITION. *TT Read More »
-
TSB #030730021
NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT Read More »
-
TSB #020730050
ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR 4T45E TRANSAXLES AND SUBSEQUENT OVERHAUL PROCEDURES WHICH AFFECT 1995-2001 MODEL YEAR TRANSAXLES. Read More »
-
TSB #677160
DELAY ENGAGEMENT INTO DRIVE AFTER COLD SOAK (REPLACE WITH REVISED FORWARD CLUTCH HOUSING ASSEMBLY COMPLETE). *TW Read More »
-
TSB #070730025
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. Read More »
-
TSB #030730021A
NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P1810, DIAGNOSTIC TROUBLE CODE P1815 SET. *TT Read More »
-
TSB #971101738152
CONCERN WITH PARK LAMPS STAY ON WITH HEADLAMP SWITCH IN "OFF" POSITION. *YC Read More »
-
TSB #736016
VIBRATION AT IDLE AND INCREASED ENGINE NOISE ON ACCELERATION (REPLACE FRONT/REAR TORQUE REACTION MOUNTS). *TW Read More »
-
TSB #010303
INFORMATION USED WHEN SERVICING THE DRIVE AXLE NUT. *TT Read More »
-
TSB #990844003
SOME CUSTOMERS MAY COMPLAIN ABOUT WEAK FM RADIO RECEPTION AND / OR NO AM RADIO RECEPTION. *TT Read More »
-
TSB #98836416
CONDITIONS REGARDING WEAK OR DISCHARGED BATTERY, SLOW STARTING, GEN OR MIL LAMP ON, VARIOUS DRIVEABILITY SYMPTOMS. *YC Read More »
-
TSB #97IDPD18B
SUBJECT ON CLUSTERS FOR 1997-98 VEHICLES - CIRCUIT BOARD UPDATE. *TT Read More »
-
TSB #010849020
SUBJECT REGARDING REVISED IGNITION LOCK CYLINDER OR IGNITION SWITCH ASSEMBLY REPLACEMENT. *SLC Read More »
-
TSB #0208116001
SUBJECT REGARDING INTERMITTENT COMMUNICATION OR SERIAL DATA DIAGNOSTIC TROUBLE CODES STORED IN HISTORY. *SLC Read More »
-
TSB #200602
SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY OR THAT THE LAMP ASSEMBLY HAS WATER IN IT. *TT Read More »
-
TSB #000842007B
SOME CUSTOMERS MAY COMMENT THAT A STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY, OR THAT THE TAIL LAMP HAS WATER IN IT. TO INCLUDE CHEVROLET CLASSIC 2005. *TT Read More »
-
TSB #000842007
STOP TAIL LAMP INOPERATIVE OR INTERMITTENT AND OR WATER IN LAMP. *EH Read More »
-
TSB #000842007
STOP AND / OR TAIL LAMP MAY NOT WORK CORRECTLY, OR THAT THE TAIL LAMP HAS WATER IN IT. *TT Read More »
-
TSB #990849008
CUSTOMER MAY COMPLAIN THAT THE CHIME SOUNDS WHEN KEY IS REMOVED FROM IGNITION, INTERMITTENT OPERATION OF POWER DOOR LOCKS, KEYLESS ENTRY, STEERING COLUMN LOCK OR MEMORY SEATS. *TT Read More »
-
TSB #01014
ALL GMC DEALERS PLEASE DISREGARD ADMINISTRATIVE MESSAGE WIA20010111 TRANSMITTED 8/7/2001. *YD Read More »
-
TSB #98831115
CONCERNS REGARDING THE PASSENGER FRONT FLOOR CARPET BEING WET OR WATER LEAKING FROM THE BOTTOM OF THE INSTRUMENT PANEL AND/ OR HVAC MODULE. *YC Read More »
-
TSB #070941006
SDM REPROGRAM - CLASS ACTION SETTLEMENT (U.S. ONLY). *NJ Read More »
-
TSB #000940002
A CONDITION MAY EXIST WHERE THE FRONT SEAT SHOULDER BELT IS SLOW TO RETRACT WHEN NOT IN USE, OR NOT LONG ENOUGH. *TT Read More »
-
TSB #071101
SOME CUSTOMERS MAY COMMENT OF WATER LEAKING INTO THE CAR ON THE FRONT FLOOR. *TT Read More »
-
TSB #020866005
SOME OWNERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN. *TT Read More »
-
TSB #831704
CONCERNS OF DOOR HANDLES ON WHITE PAINTED VEHICLES TRUNING YELLOW. *YC Read More »
-
TSB #831703
ON SOME VEHICLES, THE PAINT MAY BE WEARING OFF THE FRONT DOOR ON THE INSIDE OF THE A PILLAR, WHERE A SEAL PATCH IS PLACED OVER A WELDED JOINT. *TT Read More »
-
TSB #240101
SOME CUSTOMER MAY COMMENT THAT THE REAR DOORS HAVE HIGH SWING EFFORT WHEN OPENING OR CLOSING. *TT Read More »
-
TSB #990864030
ADDRESSING CONCERNS OF COLD AIR ENTERING VEHICLE AROUND DOOR HANDLES. *TT Read More »
-
TSB #971101631041
COMMENTS ON INOPERATIVE POWER DOOR LOCKS (FRONT AND/OR REAR DOORS). Read More »
-
TSB #731047
HIGH EFFORT NEEDED FOR DOOR OPENING/CLOSING IN COLD WEATHER. *TW Read More »
-
TSB #020866005A
SOME ONWERS MAY COMMENT THAT THE MOLDING ALONG THE REAR (TRUNK) COMPARTMENT OPENING AT THE STRIKER IS LOOSE OR BROKEN. *TT Read More »
-
TSB #040699
SUBJECT REGARDING RESCISSION OF STOP SALE OF REAR COMPARTMENT LID INTERNAL RELEASE. *TT Read More »
-
TSB #060599
SUBJECT REGARDING A STOP SALE OF REAR COMPARTMENT LID INTERNAL RELEASE. *TT Read More »
-
TSB #010863003
SOME CUSTOMERS MAY COMMENT THAT WHEN THEY CLOSE THE HOOD, THE PRIMARY LATCH DOES NOT ENGAGE. *TT Read More »
-
TSB #150301
THIS MESSAGE CONCERNS HOOD CABLE FREEZING. SOME CUSTOMERS MAY COMMENT THAT THE HOOD RELEASE CABLE WILL NOT OPEN THE HOOD. *TT Read More »
-
TSB #970801676305
SOME VEHICLES EXPERIENCE DIFFICULTIES TO DEPRESS ACCELERATOR PEDAL AND/OR AN ACCELERATOR CABLE SEPARATION. *YC Read More »
-
TSB #676305
DIFFICULT TO DEPRESS ACCELERATOR PEDAL AND/OR ACCELERATOR CABLE SEPARATION (INSTALL ACCELERATOR CABLE AND CLIP). *TW Read More »
-
TSB #010850009
SOME OWNERS MAY COMMENT THAT THE PASSENGER RIGHT FRONT SEAT RATTLES WHEN UNOCCUPIED. *TT Read More »
-
TSB #990850006
CUSTOMERS MAY COMMENT THAT THERE APPEARS TO BE PREMATURE WEAR OF THE LEATHER MATERIAL ON FRONT AND REAR SEATS.*TT Read More »
-
TSB #990850006
SUBJECT REGARDING PREMATURE WEAR OF LEATHER MATERIAL ON BUCKET SEATBACK BOLSTER. *TT Read More »
-
TSB #98731616A
SEAT BELT LATCH SLIDES TO SEAT BELT ANCHOR SLEEVE. *YC Read More »
-
TSB #971101731616
COMMENTS THAT THE SEAT BELT LATCH SLIDES TO THE SEAT BELT ANCHOR SLEEVE. *YC Read More »
-
TSB #16NA260
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO ... Read More »
-
TSB #3121
HVAC WILL CHANGE FROM RECIRC MODE TO FRESH AIR MODE WHEN DRIVING. *SC Read More »
-
TSB #000089008E
SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. Read More »
-
TSB #000089008B
SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. Read More »
-
TSB #020603005
SOME CUSTOMERS MAY COMMENT THAT THE SERVICE ENGINE SOON LIGHT IS ON. WITH STORED CODES P0112, P0113, P1111 OR P1112. *TT Read More »
-
TSB #270202
SOME CUSTOMERS MAY COMMENT OF A MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH STORED DIAGNOSTIC TROUBLE CODES P0112, P0113, P1111 OR P1112. *TT Read More »
-
TSB #040202
SOME CUSTOMERS MAY COMMENT ABOUT AN INTERMITTENT SERVICE VEHICLE SOON LIGHT AND/OR AN ELECTRONIC TRACTION CONTROL LIGHT OFF WHICH MAY ILLUMINATE AFTER STARTING THE VEHICLE WITH THE ENGINE RUNNING. Read More »
-
TSB #01014
ALL GMC DEALERS PLEASE DISREGARD ADMINISTRATIVE MESSAGE WIA20010111 TRANSMITTED 8/7/2001. *YD Read More »
-
TSB #010849012
INFORMATION ON INSTRUMENT PANEL COMPARTMENT LOCK CYLINDER REPLACEMENT PROCEDURE *JG Read More »
-
TSB #000089008A
SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. Read More »
-
TSB #98776514A
SOME VEHICLES MAY EXPERIENCE A MIL (MALFUNCTION INDICATOR LAMP) LIGHT ILLUMINATED ON THE VEHICLE'S INSTRUMENT PANEL. *YC Read More »