Vehicle repeatedly shuts down due to wiring issue for fuel pump. Wire in rear fuse panel (in trunk) shows signs of overheating (discoloration). Vehicle shuts down without warning while driving. This causes an unsafe condition especially when travelling on busy roadways and highways. This seems to be a common problem with this model and year.

- Avella, PA, USA

To Whom It May Concern: My 2012 Chevrolet Malibu LS HASN'T been involved in an accident but I feel it necessary to report it! Due to issues involving my electrical system and other components of the vehicle that aren't working properly, the vehicle is inoperable! Beginning in April 2022, I have experienced issues with the vehicle starting (one day it will start and drive normally, another day it might not). Then it started stalling unexpectedly. Granted, I've had the car 10 years but I've never had these problems! It's been serviced and the problems still exist! These problems could easily cause an accident; I'm grateful I've been spared from tragedy! These issues need to be addressed and I'd greatly appreciate hearing from NHTSA!

- Hillsborough, NC, USA

The electric power steering and ESC systems. It is or was under recall for this type of vehicle. The steering becomes hard and vehicle shakes the tire rotation is being read wrong by computer. It doesn't want to stay 9n the road...the stability of vehicle is compromised.

- Montrose, MN, USA

Passenger as well as driver side headlight continuously pop on and off, not blowing the bulbs but assuming there is a wiring issue

- Florence , SC, USA

Each time I try to start my car it only starts up for 2 seconds and cut it off. I have changed fuel pump relay switch. It-??s still causing the same problem. If I knock on the fuse box in the trunk then start the car the car will eventually start up. My car will randomly cut off on me causing me to be stuck. My rpm stopped moving at times I feel like I-??m losing power. This car has serious electrical issues definitely a recall needs to be put in place. Let-??s not forget my headlights not working even though they-??ve been changed still only my driver side high beams work

- St. Louis, MO, USA

I'm a single parent and I can't afford to take my car to the dealership I love my car I have had my 2012 chevy malibu for over 6 years n I hate to just have it park at home knowing that, that's car was my everything. It started having problem with esc. When I would come to a stop then taking off it would break on its one I was told it could be my throttle body so I went n buy one n now the idle is too high now I can't get it to fix. Pls help me out I'm my car that I love so much.

- Hondo, TX, USA

The fuse box in the trunk (Body Control Module or BCM) has completely melted the rear defrost fuse into the block. A central piece of the fuse was removed once the issue was identified preventing the system from continuing to send electrical current through the fuse and possibly sparking or shorting out other essential systems (such as the fuel pump which seems to be a common problem). I have not taken this to be seen by a dealer, but intend to replace the BCM so as to prevent the fuses from completely melting. Overall, there was no indication of the issue until I realized that the rear defrost wasn't working when there was a light frost on the windows. This is when I checked the fuses and found the issue.

- Hampton, VA, USA

My electric steering motor and torque sensor is going out. I first noticed it starting to go out about 2 months ago in November. I was turning to pull into a parking spot at the grocery store and all of a sudden my wheel locked up and check ESC flashed across my dashboard. I almost side grazed the car on side of me on my way turning in. I had to turn the wheel really hard to straighten it up..so when I got into the parking spot and turned the car off and turned it back on it was working again and didn-??t do it for a while. So fast forward 2 months later in January it started back doing it again. I was backing out of my driveway and all of a sudden the steering got really hard and again service ESC flashed on the dashboard and I almost backed up into a car that-??s parked on the street behind my driveway. I had to turn really had and in the middle of the street I had to turn the car off and back on to reset itself. The next day was driving and and when I stopped at a stop sign my steering wheel started shaking left to right uncontrollably and ever since the the steering wheel just shakes even while sitting still so I made an appointment with the dealership that I got the car for checked it out and did a diagnostic test and the mechanic told me I needed a torque sensor and steering motor. I have the papers saying that-??s what-??s wrong with it and after doing research I found that that car model had a recall with the exact same thing my car is doing but when I put in my vin number it-??s not listed as a recall and my car isn-??t drivable and I think it should be recalled.As of now it has only been looked at by the dealership. And it-??s available for inspection upon request.

- Cahokia, IL, USA

ESC traction control /Power Sterering light turned on my wheel was hard to steer. Lost control. If I turn off it works for a few minutes but then goes back to hard.. unable to steer

- Baytown, TX, USA

Several electrical problems have occurred with my 2012 Chevy malibu. First the horn would not stop beeping which caused me to jump and almost run into a telephone pole. I parked the car and the horns kept beeping I got home and the horn cap beeping. My husband cleaned off the battery cables and that seemed to stop the problem for a while then they started beeping again. Then my door lock started unlocking and locking by itself causing me to lock my keys in my car. So I disconnected the horn I disconnected the locks. Now my trunk is popping open by itself. Even when the trunk is open the electrical supply keeps going to it and making a clicking sound trying to open it. I have had many electrical problems with this car.

- Dillsburg, PA, USA

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving, the brake light was illuminated. The contact stated that at the time she was not depressing the brake pedal. The contact stated that when she was switching gears from either drive or reverse the brake light only illuminates once in gear and does not turn off. The contact also stated that the traction control warning light also illuminates while driving, however the vehicle does not drive any differently. The vehicle was taken to an independent mechanic who advised her that there was a recall on the same year, make and model vehicle as her vehicle NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). The contact said she was advised that her vehicle had to be taken to the dealer to have her vehicle reprogrammed. The contact stated that she has not yet contacted the dealer or the manufacturer at this time. The failure milage was 60,000.

- Kent, NY, USA

I bought the car a year ago from a used car lot. Replaced the cam shaft positioning sensor as per diagnostic reading for check engine light. Since then, svc air bag light has stayed on. Traction control light stays on and is disengaged. When braking ESC warning goes on and off and sliding occurs. The low beam headlights go on and off intermittently and no way of knowing when it will happen. When turning cruise control on or off, the car will accelerate on its own and will increase speed until brake is applied. Regardless of whether cruise control was turned on or off. I have had it looked at at my local Mr.Tire and they cannot figure out what is happening.

- Blue River, KY, USA

I been having the same problem for a year now.. constantly putting it in and out the shop and no one can find out what-??s wrong with it.. the engine will loss it control and stop working in the middle of traffic which almost caused me a wreck several times. The Chevrolet dealership hasn-??t done anything to help but charge me to look at it and they didn-??t fix the problem. I have three kids and it has been a safety issue which is our only way to work and school. The car will skip constantly in the middle of traffic and several times someone almost ran into the back of my car. It will say engine power reduced, service traction and service sec I have spent ton of money trying to fix the issue and I have read several people have had the same problem.

- Tuscaloosa, AL, USA

The bcm and fuel pump relay over heats burns the wire causing stalls at traffic lights and normal driving then won-??t start back up. If you-??re lucky you can hit the bcm or take the fuel relay out and reinstall and it may start back

- Sweetwater , TN, USA

I have a 2012 Chevy Malibu i bought it in 2014. I have had the Esc light come on in 2016 but no problem with it untill now of this year in 2022. Not knowing the problem i have already put ALOT into it. I took it to a machanic they told me it was the rack and pinion. So got that done. Apparently it wasn't it took it to another machanic they told me it was struts got that done too n still nothing so i looked it up online got CV joint, inner, tie rod, wheel alignment. All those done n still nothing fix it. I didn't know what else to do until i made more scratch on my vehicle and i found that it could be a recall.

- Hondo, TX, USA

This car will not start!!!! It starts when it feels like it. I-??ve been stranded after work so many times for unknown reasons. Multiple mechanics have inspected car and cannot find the issue. Go on YouTube and search for this year car and you-??ll find so many people in the same situation as me. The car has battery but the engine will not start. GM cars have this issue in common and it-??s ridiculous GM cannot stand behind their brand. Please HELP US!!!

- Falls Church , VA, USA

The contact owned a 2012 Chevrolet Malibu. The contact stated that while his wife was driving at 10 mph, other drivers alerted her that there was a fire underneath the vehicle. The contact's wife was able to safely exit the vehicle. There was no injury and no medical attention was necessary. The fire department was able to extinguish the fire. The contact's wife was informed that there might have been an electrical short that caused the fire. A fire department report was filed. The vehicle was towed to the residence. The contact left a voicemail for the dealer notifying them of the failure and was awaiting a callback from the dealer. The manufacturer was not made aware of the failure. The failure mileage was 112,000.

- Fort Worth, TX, USA

GM Tech Bulletins say there is a Ghost Problem with Elect. Stability Controller. GM mentions there is no recall or known cure for this..Components/contacts were cleaned at service shop but " Serv. ESC-ESC OFF" keeps appearing in "driver display" when hitting bumps -turning car.. i will mail service sheets. This option was available on 08-09-10 models of Malibu but Std. on my 2012 car. It is worthless when there is thick snow.. I will send, by mail, serv. records on this unsolvable problem... It continues to happen, at slow speed - not just one time...I believe YOU can read the G.M.-TSBs, as it was shown to me.... Consumer stated it showed a bad steering column multi switch & Yaw sensor unit, part still available.. Unit fires off bad code when barely moving and turning to right... Unit gets damp and works for a while. Turns out: Plastic Yaw coil in steering column broke up against the shaft, and the multi reed switch is probably bad, in there. The consumer stated after a new multi switch was installed, the bracket of the plastic broke again.

- Payson, AZ, USA

While parked or driving this vehicle shuts down on its own, sometimes on the freeway going 65 mph. The fuse located in the trunk has a faulty connection and a wire that isn-??t efficient for heat from fuel pump so it shuts down while driving and sometimes won-??t start. This is gonna kill someone when it shuts off on the freeway in traffic. I-??ve read up on this being a regular problem with the Malibu

- Bakersfield , CA, USA

My vehicle fail to restart vehicle, but vehicle was running good before. Once I turn off the vehicle for couple of minutes when I returned back to my vehicle and tried to turn vehicle on it would not allow me to turn on lights on vehicle would stay on when taking key out of ignition. I kept trying couple of time until I open the hood to check battery move battery cables tried again until vehicle turn on. Once vehicle had turn on and put vehicle in reverse dashboard lights started turning on check engine a service warning message display and speed meter would go up and down. When going forward the steering wheel became hard to control while vehicle would go toward slowly then stop go fast and slowly again until I got home turn vehicle off. Didn't drive it anymore until two days later. The second time I was on the freeway when my vehicles speed started to significantly reduce speed very quickly. I became concern with my safety until I was able to pull over on the side of freeway car turned off. When trying to restart vehicle would fail to turn back on had to tow vehicle back home. I tried turning vehicle back on failed at first on the last try vehicle turned on but when putting on reverse or drive vehicle became undriveable thier was no movement on vehicle and speed meter would not move. I just purchased this vehicle only had 8 months with it I payed $5000 plus $600 on plates. I do make my vehicle available for inspection it is very dangerous going through this specially on highway. I checked my onstart vehicle report but it does not show that anything is wrong on the report. My insurance provider Geico car details only show it needs and oil change. I also notice that in the vehicle history shows it has an oil leak. I can not afford to pay for a mechanic at this moment my vehicle is just park at home now.

- Paramount, CA, USA