Had vehicle in for service for oil change and a loud clicking noise as well as misfire was the vehicle was fine to drive proceeded on my trip on my way back to my hometown the motor through a pushrod while on the highway

- Wichita, KS, USA

Truck died on busy road. Towed to certified Chevy dealer. They heard knocking noise did oil change drove it truck died again. Stated engine seized. Warranty dept denying claim saying truck driven 30 seconds to 1 minute after oil pressure light came on. But no lights came on for us and verified from diagnostic done at the Chevy dealer.

- Mays Landing, NJ, USA

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at approximately 35 MPH, the engine started to misfire. There was an unknown service warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that left side valve lifters needed to be replaced. The codes displayed were 0329 (Engine/Fuel Exhaust) and 6581 (Modular Component) registering incorrectly. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 15,253.

- Holly, MI, USA

The first time it happened my Truck started shaking a lot on the highway and it left me stranded on the side of the road. It had around 20,000 miles on it. When it got repaired I was told it had to do with the lifters on the left side of the engine. Took them 2 weeks to fix the issue. The second time it happened was on the ramp getting on to the highway, this time at 58,000 miles and now the right side lifters. Except this time they couldn-??t fix it and they are going to replace the whole engine and give me a new one. Only thing is that it's been in Chevrolet shop for over 2 months and they have an ETA of a new Engine arriving in about a month if even that. So currently don't have my truck.

- Bothell, WA, USA

Engine misfire, likely engine will need to be replaced

- Utica, NY, USA

Around [XXX] on [XXX] the vehicle shut down with no codes showing or any warning. The weather was approximately 13* f. After many failed attempts to restart, and the electrical systems would not power down as if the vehicle thought it was still running. The only way to get the system to shut down was to disconnect the battery. i had to physically push the vehicle to a safe location. The next morning I attempted to diagnose the issue with no success. I had the vehicle hauled to the dealership from which it was purchased in Idaho to have it inspected. Tuesday morning I received word from the dealership that the engine suffered major failure. This will be the 3rd engine in the vehicle. I am uneasy about the dependability of the vehicle as I have recently discovered that this particular engine is having massive failures all over the country. So much so that the NHTSA has opened an investigation for the purposes of safety. I purchased the vehicle for the main purpose of pulling a snowmobile trailer with snowmobile to the mountains and also to tow my boat and trailer. Both of these activities require a vehicle in which I can depend on. While I am waiting for a back order engine the dealership and manufacturer refuse to lend a like vehicle, leaving destitute. I am hoping that this agency can offer some assistance, and I believe it's important that you are made aware of the hazard that this particular engine possesses. As I previously mentioned this the 3rd engine and As far as I can see this will occur again putting myself and others potentially in harms way because of a known issue. This does not make me feel confident of the safety of the vehicle. Be aware where i live there grades in every direction and extreme weather conditions from season to season. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Spokane, WA, USA

2021 Silverado LT Trail Boss 6.2 (production date: 01/2021) was taken to the GM/Chevy dealer (Ed Morse Chevrolet) on 01/29/2024. It was confirmed by the GM mechanic that the engine had failed (75k miles) due to a shattered camshaft and metal in the engine and a complete engine replacement is needed. Had prior complaint at around 6k miles for engine noise along with hard shifts and a check engine light that had appeared then went away on its own (documented). I was told by a GM certified dealership, it was normal in the new trucks and no action was taken. Unsatisfied, I made another appointment for a second opinion and only regular maintenance service was suggested and performed several days after, at a GM certified dealership. All oil changes have been performed in a timely manner. No forewarning prior to engine failure to include check engine light or any system messages, although trucks performance from the initial complaint did not subside. To my knowledge, this vehicles engine is weighing heavy on consumers safety with engine failure and is a well documented issue, leaving many stranded. Thank you!

- Cooper City, FL, USA

The truck jerks when first driving and will jerk and lundge at various times and speeds. There is a almost grinding nosie. It often says "Reduced Engine Power" and the engine light comes one, the "Service ESC" notice comes on with the vehicle light, when this happens the truck will barely accelerate even if flooring the gas, continues to make a grinding noise. This happens frequently, but then lights go away, then come back on. Dealership pulled multiple codes (image attached). This is a huge safety risk due to failure of acceleration, and the jerking that causes the truck to jerk while in motion and slow.

- Mansfield, OH, USA

With absolutely no warning, the 6.2 liter V-8 engine with 28,500 miles on it seized up solid and would not run. I was stranded in heavy Christmas traffic and completely blocked one lane. It was an unsafe situation. I had to summon a wrecker to come and tow the vehicle, and I called 911 for police presence to alert and direct traffic. The vehicle was at the Chevy dealer for a month while they installed a new engine. The dealer never fully confirmed what the cause was - I don't believe they really know - and I only have 10 months of warranty left. I am concerned about another failure and thought I should at least get the warranty on the new engine re-set to 60,00 or more miles.

- Cedar Rapids, IA, USA

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 30 MPH following a school bus, there was an abnormal screeching sound coming from the vehicle. The contact stated that a message to pull over safely was displayed. The contact stated that the engine had seized. The vehicle was towed to the local dealer, where it was diagnosed that the crankshaft bearings and connecting rod bearings had failed. After further diagnostic tests, the contact was informed that the vehicle was not repairable. The vehicle was repaired with a remanufactured engine. The manufacturer was made aware of the failure. The failure mileage was approximately 16,000.

- Indianapolis, IN, USA

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed or while stopping the vehicle, the contact heard an abnormal sound coming from the top of the engine where the lifters were located. The contact stated that the spring in the engine had collapsed, causing the check engine message to be displayed. The contact stated that the dealer was contacted. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the lifters on the top of the engine were causing the DEF sensor to engage. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000.

- Douglasville, GA, USA

I brought in vehicle for check engine light is on for p0300 / p0308 had misfire tech removed engine valve cover and determine no movement in valve train components tech determine valve train failure lifters possible camshaft we would need to remove the cylinder head and replace valve train lifters.

- Orangevale, CA, USA

At 4K miles, the lifters of the engine went bad. It was determined a rod was bent and had to be replaced. At 26K miles, another cylinder went bad and had to be replaced. At 40Kmiles, serpentine belt had to be replaced. At 41K miles, another cylinder went bad and had to be replaced. Now, at 55K miles, I am getting the same issues with loss of power, engines stuttering and misfiring and will be taking the truck to the dealer on 1/28/25.

- Fullerton, CA, USA

Engine failure

- Listuguj, NY, USA

My 2021 Silverado with only 80,655 miles had to have the engine replaced. On 11/20/24, my vehicle indicated a P0303 code for miss-fire in cylinder 3. I took my vehicle to for repair to a local Chevy Dealership and was informed of the following: 1) Needed programming changes to the fuel injection based on service bulletin N242450631. This repair was completed by the dealer. 2) Needed a -??tear down-?? for further diagnostic. It was determined that the specific code could not be repaired and the entire engine needed to be replaced which was done at my cost. The details on service bulletin N242450631 are limited and do not describe issues that could be caused by the fuel injector problem. Relative to service bulletin N242450631 fuel injector issue, based on my experience with my vehicle, I believe this fuel injector programming bulletin issue caused the engine malfunction and subsequent need to replacement. Before the bulletin repair was completed, I know that my vehicle engine surged often. Looking back now, this constant surging had to be hard on the engine and likely caused the failure. Regardless, if it wasn-??t the service bulletin that caused the issue, a vehicle engine should last more than 80,000 miles. I believe GM needs to take responsibility for the engine failure which I believe was caused by faulty workmanship, design, computer engine programming, or some combination of these issues.

- Camden, TN, USA

Driving down the road and the vehicle shut off and said to restart. Wouldn't start back up. Check and found a 400 amp fuse was blown. Tested starter and was fine. Restarted the vehicle and it made a loud rattling noise and shut back off. Sent it to the dealer and they found that number 1 and 2 rods overheated and locked up the motor.

- Lockport, NY, USA

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 50-55 MPH, the vehicle went into LIMP Mode. The vehicle decelerated to 35-40 MPH. The contact stated that the vehicle was consuming an excessive amount of oil. The contact stated that the vehicle was consuming a quart of oil per month. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a failed lifter. The vehicle was repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 92,000.

- Irwin, PA, USA

At start up check engine light, service esc, service parking brake. Code reader shows code P0304 misfire cylinder number 4.

- Warrensburg, MO, USA

Lifter failure on number 2 cylinder.

- Green Bay, VA, USA

Lifter failure at 8629 miles. All warning lights went on at time of incident, truck would barely drive home and I had it towed into the dealership where they replaced the entire bank of lifters. This is on my repair order- "Checked and found dead mis on cylinder 4 and ticking noise from engine//performed compression test and found no compression on cylinder 4//removed passenger side cylinder head and found lifter bad causing push rod to bend//replaced all lifters on right bank and 1 pushrod//changed oil and filter//filled coolant and test drove and found all ok. I called Chevy at time of incident (1/21/22) and opened case# 9-7252876703 stating I wanted both banks of lifters replaced because I pull a 30' camper with my family and didn't want the other side to fail while I'm pulling 7000+ pounds. They declined to replace the other bank stating that since the vehicle had more than 5000 miles it did not qualify for both sides to be replaced and it was for only vehicles after 11/21 and mine was built 2/21. I still would like to get the other bank of lifters replaced under warranty.

- Roselle, IL, USA