Engine starting banging loudly and misfiring. There was a loss of power and engine codes. Brought to the dealer and they said cylinder #4 was misfiring due to a stuck lifter, bent push rod and destoyed cam. Total cost of repair was $9200. Vehicle is less than 4 years old an has 75,000 miles on it.

- Lexington, MA, USA

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while his wife was attempting to start the vehicle, the engine failed to turn over as intended. No warning light was illuminated. Upon further inspection, the contact stated that there was an abnormal sound coming from the vehicle. The contact used an OBD-2 diagnostic scanner and retrieved DTC: P129F and U18A2. The vehicle was towed to a local dealer, where it remained for further investigation. The contact related the failure to an unknown recall; however, the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 82,000.

- Ridgeville, SC, USA

I am submitting this complaint regarding my 2021 Chevrolet Tahoe (VIN: [XXX] ) which has developed a severe transmission shudder at both low and highway speeds. The issue has been confirmed by my Chevrolet dealer, who provided an estimate of $5,492.18 for torque converter and valve body replacement. This failure is identical to the torque converter shudder problem documented in GM service bulletins and special coverage adjustments for other GM vehicles of the same make, model, and model year. However, my VIN is not currently included in those programs, leaving me without coverage despite experiencing the exact same defect. I believe this condition poses a serious safety risk, as the shudder occurs while driving at highway speeds, causing vibration, hesitation, and potential loss of control. These symptoms could lead to accidents if the vehicle fails to respond properly during acceleration or lane changes. Given that this appears to be a widespread defect affecting multiple GM vehicles, I respectfully request that NHTSA investigate and consider expanding any related recall or special coverage programs to include affected VINs such as mine. Please let me know if further documentation, service records, or dealer estimates are needed to support my complaint. Thank you for your time and for working to ensure vehicle safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Tomball, TX, USA

Car stopped while in motion, engine shutdown and could not be put into neutral to move vehicle out of traffic. Car had to be towed away. Only 37 k miles. This is the Second time this has happened in traffic posing a major safety hazard. Fuel control module was what shut down the car while driving the first time. Now it has failed again

- Ormond Beach , FL, USA

We are apart of the safety recall with the potential brake and engine issues, we have contacted the dealership and they have NO remedy at the current time for our defective vehicle. We contacted GM to request a buy-back due to the safety issues with the vehicle, told we did not qualify BUT they have no remedy for our defective truck. We do not fell safe in the vehicle, the brakes are sticking and the engine is making weird noises. We are currently seeking legal representation because we are being forced to drive around our family of 5 in an unsafe vehicle with NO remedy or option to trade it in.

- Fort Mill, SC, USA

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at approximately 40 MPH and accelerating to merge onto a highway, the check engine warning light started flashing. Additionally, the contact stated that there was an abnormal clunking sound coming from underneath the floorboard and coming from the engine compartment. The contact pulled over and stopped the vehicle. The vehicle was towed to the dealer, where it was diagnosed and determined that lifter #6 had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that it was a known failure, and the contact was offered monetary assistance. The contact was also referred to the NHTSA Hotline for assistance. The failure mileage was approximately 61,000.

- Hastings, MN, USA

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving on two occasions at various speeds, the vehicle stalled. There were no warning lights illuminated. The vehicle was not able to restart. The vehicle was towed a dealer where it was diagnosed that he fuel control module needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately 10 months later. The manufacturer was not notified of the failure. The failure mileage was approximately 67,438.

- New Roads, LA, USA

My 2021 Tahoe High Country began to make unrecognizable sounds and the orange engine light started blinking. I immediately pulled over and turned the vehicle off. I was made aware that numerous 2021-2024 V8 6.2L engines are affected. I am waiting for my VIN to be selected in some sort of lottery format to qualify for a fix. I was told by a Chevy Service Technician that it can take 2 weeks or 2 years for GM to find a -??remedy-??. Unacceptable and very expensive to rent a vehicle for work until GM decides to -??remedy-?? my situation. I truly hope they provide me with a solution soon.

- Zelienople, PA, USA

Lifter failure and camshaft failure. Found metal in engine oil that has caused bearing failure and engine damage. While driving the Tahoe on [XXX] I experience a jolt on the front right side. Then warning messages regarding the Traction Control and to Service the ESC appeared. As I cleared those messages my engine light was blinking and several other dash lights were lit up. There was a knocking sound. I contacted the dealership (Coyle Chevrolet in Clarksville, IN) and they sent a tow truck to bring it in. They assumed it would be in the recall but it is not. I am without a vehicle and the engine is backordered. It's not right that GM is picking which engines they are going to include in the recall when they know there is a manufacturing issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Pekin, IN, USA

I was driving down I-635 (Dallas) at 70mph on Friday 7/25 when my Tahoe started shaking, knocking and had complete engine failure. I managed to regain control and slow to the service road. Thankfully the car next to me was paying attention & swerved to avoid me, but honked at me the entire time. The vehicle was towed and we are being told we need to replace the engine for $14,500. As I-??ve researched, the 6.2L is recalled for this exact issue. The 5.3L has no current recall but I-??m clearly experiencing the same engine failure and being told I-??m responsible for it. I had no prior warnings & have regularly maintained this vehicle. Any chance others have complained about the 5.3L as well & our Tahoe-??s should be included in this recall?

- Heath, TX, USA

I-??m reporting a transmission failure that occurred unexpectedly on my 2021 Chevy Tahoe/the diesel version has been recalled so I don-??t know why all the other 2021 Tahoe have not been recalled for this issue. The vehicle began shifting roughly and slipping between gears, followed by a warning message and eventual inability to shift properly. I had it inspected by a family friend who owns a body shop, and I was told the transmission needs to be replaced at a cost of nearly $7,000. I am no longer under powertrain warranty, but this failure feels premature and unsafe for such a new vehicle. I-??ve seen many other 2021 Tahoe owners report similar issues online including transmission failure, harsh shifting, valve body problems, and complete breakdowns. This seems like a pattern, and I believe it may warrant investigation. I-??m asking NHTSA to investigate whether this is part of a broader transmission defect that poses a safety or reliability concern. Sudden shifting issues and inability to accelerate or reverse are dangerous for drivers and passengers. Thank you for your time and attention to this matter.

- Tomball, TX, USA

On 01/03/24, the vehicle stalled and smoked on the Suncoast Parkway. All dashboard warning lights and messages illuminated, and the vehicle entered emergency park mode. OnStar was contacted and the vehicle was towed to Jenkins Chevrolet in Homosassa, FL. The failure was linked to a broken pulley and belt system that damaged the ECM and wiring harness. No DTCs were pulled, and mileage in/out was 80042/80043-?"no test drive performed. On 08/06/24, the vehicle returned to Jenkins for a roaring noise. A pulley bearing was replaced, possibly related to the earlier failure. Again, no drivability evaluation or codes recorded. On 03/09/25, the same full system warning lights/messages appeared again. The vehicle experienced harsh shifting and delayed acceleration. It was taken to AutoNation Chevrolet South Clearwater on 03/10/25. DTCs (P0700, P0717, P2714, P2716, P0706, and U-codes) were found but dismissed. Only the battery was replaced. Mileage in/out was 99494-?"no test drive performed despite claims one occurred. On 07/08/25, the vehicle again showed full dashboard warnings. Brought back to AutoNation on 07/09/25. On 07/14/25, customer received a $9,177.85 estimate including full transmission replacement. Safety was at risk due to repeated stalling, loss of acceleration, and emergency parking mode while driving or merging. These failures could have led to accidents or left the vehicle disabled in traffic. Driver and children were present during each incident. The vehicle is enrolled in OnStar and the MyChevy app, which provide monthly health reports. Despite these incidents, no faults or warnings were ever shown in the reports. Vehicle remains available for inspection. A case is open with GM. Across 4 service visits, GM-certified dealerships failed to follow proper protocols, including code checks, drivability assessments, and test drives-?"contributing to delayed diagnosis of transmission failure.

- Odessa, FL, USA

Automatic fuel management/ Displacement on demand caused lifter failure which caused cylinder failures.

- Casper, WY, USA

I was driving home from a long trip and heard a large pop. Several warning signs and messages began popping up and the vehicle was shaking and struggling to maintain speed. I was able to get home and get my family out of the vehicle and get it to a dealer down the road. They stated the Fuel injector and harness had failed.

- Hartland, MI, USA

[XXX] # [XXX] VIN = [XXX] MAKE ; Chevrolet Tahoe 2021 RE : I received a recall affects certain 2021-2024 models equipped with the 6.2L V8 L87 engine. The defect involves the connecting rod and/or crankshaft engine components, potentially leading to engine damage or failure. On March 2025, My Tohoe completely stopped while I was driving. My SUV was towed to Bomnin Chevrolet in Manassas Virginia. They diagnois was crank shaft damage leading to engine failure. My SUV was in the dealership for 2 weeks while the engine was replaced. I spent a total of $ $15,027.20 to fix my car for that problem. I called GM recall about this problem. I was informed that the recall was for only certain vehicles. Not my SUV. I am concerned that my SUV was affected by faulty crank chaft. I had to replace the engine. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Haymarket, VA, USA

several issues with certain popups regarding various indicators on dash and engine not getting enough psi

- Childress, TX, USA

Unknown - engine is driving hard and somethings wrong. No one will service my car because they say it-??s on a recall, but then when they look up the VIN number it-??s not on a recall however there are major issues going on.

- Fayetteville, NY, USA

On April 25th, 2025 while traveling on Interstate 20 at 70+mph speeds with my children in my vehicle and 30 weeks pregnant, with no indication of an issue my 2021 Chevrolet Tahoe suffered catastrophic engine failure. There was zero warning from the vehicle including noises/electronic display warnings that this was fixing to occur. In the middle of going 70+mph surrounded by traffic on a busy interstate the vehicle just shut off completely. I was able to use what momentum I had from my speed to get on to the shoulder. However, the failure prevented me from being able to turn on my signal to alert other drivers of my merging and prevented the use of my emergency flashers to signal once on the shoulder immobile. The vehicle would not start up again after that, and I had to call a tow truck to take my vehicle to the nearest certified Chevrolet service center. When the tow truck arrived the vehicle would not even shift into neutral allowing them to load it without potentially causing more damage. It had to be drug with the wench in park onto the tow truck bed. Once at the nearest service center I was told it would be up to 3 weeks + before they could do a diagnostics. I was 14 hours from home when this happened, and now had to pay to have my Tahoe towed 14 hours back to the service center near my home. On May 8th the failure was determined to be caused by this recall, specifically the crankshaft. The dealership has lied and said they've ordered a new motor and it came in, then called to tell me they ordered the wrong motor. They said they ordered the correct one and it would be in within 14 days, and that was 25 days ago. They called today June 16, 2025 to tell me there is still no update on when my engine will ship to complete this repair. The dealership has also refused to assist me with any loaner vehicle or rental assistance even though GM has told me I am entitled to it under this recall. GM has moved my case to Parts Delay team and I still have not been contacted.

- Meadville, MS, USA

While starting from a stop the engine stuttered and resulted in a major loss of power. Luckily this occurred pulling out of our driveway on to a quiet neighborhood street. Several warning lights and messages went off including the engine and transmission system warning, -??service ESC-??, -??Service Traction Control-??, and the emission system warning. After driving it to the dealership at 30mph since the shaking and banging noise was so bad, the dealer diagnosed it as a cylinder 6 caused by a failed lifter and lifter rod. Resulting repair involved lifters and rods in that same bank at a $3500 repair. The vehicle was just over 4 years old with 79,250 miles.Repair invoice available upon request.

- Clemmons, NC, USA

The contact owns a 2021 Chevrolet Tahoe. The contact stated that upon coming to a complete stop, the vehicle suddenly jolted forward independently. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the valve body. The vehicle was not repaired due to part availability. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 57,000.

- Dayton, TX, USA