The EGR valve failed, causing the loss of propulsion message on July 11 2022. This was fixed, however the message was received again in December 2022.

- Perrysburg, OH, USA

I was driving on the freeway and the engine turned off. I was able to continue driving as the hybrid system still had some charge to continue powering the car. I had to get the EGR valve replaced. No warning lights prior to this occuring but had check engine light after. Car would not shift into drive nor would it accept a charge for the main drive battery. Had to be towed to a shop and resulted in getting the Battery Energy Control Module (BECM) replaced.

- Huntington Beach, CA, USA

The car started stating "put in park" every time I would try to put the car in drive. I would shift back and forth from park to drive over and over and I could get it to clear. One time it lost all power and had zero control. Sat on the side of the road for an hour. Shifting back and forth until it stopped and let me engage the drive. The last time it happened in a parking lot and it would just say"shift to park" I couldn't get it out of park. Had to have the car towed. Tow driver had to drag the car on the flat bed with a wench because it was stuck in park. Had the vehicle repaired. Replaced an electronic control module that had previous service bulletins on but GM would not cover the repairs. I was lucky I was not injured our involved in a wreck when I experienced these issues. I was not aware I could file a report about this until I read there was an open investigation on the same issue I had.

- Crestline, OH, USA

1. 2 BECM failures: The original BECM failed and the replacement BECM failed as well. 2. Sudden loss of electric propulsion on the freeway while my wife (pregnant at the time), my son (1 year and a half) and I were driving. The car was still driving but was unstable when steering and with weak braking. The dealership identified the issue as BECM failure and the part was changed. 3. A couple of months later the car would not start at all leaving me stranded at work. The car was towed to the repair shop. The dealership diagnosed BECM failure again. 4. There was no warning indication or message prior to these issues. 5. The vehicle was only inspected by the dealership to the best of my knowledge.

- San Diego, CA, USA

Started acceleration on the freeway, car couldn't turn on engine, message came on dash "reduced propulsion mode" and check engine light came on, could only drive on battery, car was very sluggish, luckily had battery to exit after a few miles to get off the freeway. Had to restart car. If I had depleted the battery as I usually do that day, I would have had a dead car on the freeway with ton of traffic buzzing me and my family.

- Barnum, MN, USA

My Volt will suddenly lose propulsion. The air conditioner will stop working and the car will not properly accelerate. There has also been multiple occasion where the car will not power on. Additionally, there has been multiple occasions where the car won-??t charge. The failed component is most likely the battery engine control module. My safety and that of others is at risk because of the sudden loss of power and inability to maintain highway speeds. The issue was confirmed at the dealer. The check engine light goes on even after erasing codes, and there are 13 permanent codes related to this issue with no direct resolution. This is a recurring problem.

- Mount Dora, FL, USA

Sometimes when the vehicle powers on, it will not engage to drive in gas or electric mode when fully charged or with a full gas tank. Also sometimes while driving, it will say "gas mode not available propulsion limited". It frequently says "charging not available" as well. This is an on going, intermittent, problem.

- Saint Cloud , FL, USA

Car intermittantly lost propultion while driving. this started happening more and more frequently. One time driving on the freeway propulsion cut out and I barely made it to the side of the road. Put the car in park and it would start again. Drive for a few hundred feet then it would cut out again. Finally took it into the dealer when I was driving down the highway and propulsion cut out and I was stuck in the middle of traffic. As I was driving the instrument cluster power remained on but the engine just cut out. I was using the electric motor at the time but this is happened on the ice as well. As I rolled to a stop in the middle of traffic I put it in park so that I could restart the car as I had been able to previously but it would not start. It would not let me shift the car out of park into neutral so I could push it to the side of the road. After several attempts of disconnecting the battery and the high voltage battery I was able to get the car out of park into neutral. Even when I shifted the car into drive the propulsion system would not work, a officer stopped traffic to allow me to push the car to the side of the road. After getting to the dealer they were able to determine that a ground strap to the engine chassis was at fault. It interrupted the communication on the can bus which wouldn't allow the ECU to communicate with the drivetrain Which just shut down the propulsion system. This was extremely scary I have attached a snapshot of fault codes and snapshots of a video I took showing that the screen would just show that the car was initializing the entire time

- Ogden, UT, USA

On Nov5th 2023 the dash displayed "Shift to Park" and "Unable to Charge" and would not move. New 12v battery installed on the 7th, still had issue. OBD codes pointed to MAF and MAP sensors. Both replaced, but now "Reduced power" displayed on dash and erratic and limited to 30 mph driving function was experienced. PRND shifter replaced and car worked fine for 1 week. Then "shift to park" and difficulty to move car was happening again. Called dealer and under "reduced power" drove car to dealer on Nov 22nd. Car was erratic and I felt like it would stop moving at any time while in traffic.Now dealer has has car and they say they are not sure of solution and parts may take weeks to arrive. Saw article in Reuters about other Volt owners with same problem on Dec 1st, so I'm adding my car to the group. Thanks!

- Buffalo, NY, USA

The check engine light came on in my car with the message "service charging system." I took the car to the deal and they determined it was the battery control module that was failing. They told me the car would eventually stop turning on and I could either take it and drive it until it wouldn't turn on or I could leave it with them until they got a replacement part that is currently on backorder with no estimated time they can get it. I asked if the car was safe to drive and if it would stop working while I was driving, they assured me it would not stop while I was driving. I opted to take the car home and on my home, while driving, the car died on me. Luckily I was already in a turn lane and was able to get off in a neighborhood. The car gave me a message "propulsion system unavailable" while I was driving and would not power the car forward or backwards. This happened about six weeks ago and I am still waiting for the replacement part.

- Rochester, MN, USA

In the last couple months, have received multiple warnings regarding reduced propulsion that, as I understand is a potential failure related to the BECM. Besides the warning, I haven-??t noticed any major change in performance, but I am concerned there may be a defect. I haven-??t yet contacted dealer about this issue, but I noticed there was a formal report made about this and wanted to be sure my vehicle was included in the count.

- Lancaster, PA, USA

The EGR Valve has failed and they have not provided a replacement yet. Been 4 months. Decline to give an ETA.

- Longview, TX, USA

Cart fails to start nearly every time I try to start it. BECM failure seems to be the issue. Car instructs to shift to park then fails to start until eventually it clicks over and will start in gas mode. Sometimes will randomly flag into low propulsion mode while driving, which majorly affects acceleration speed. Car will no longer charge and must be used in gas mode due to known electrical defects. Sometimes have to wait 10+ minutes for the car to start.

- Pontiac, MI, USA

-- My 2017 Chevrolet Volt experienced a failure of the Battery Energy Control Module (BECM) in the powertrain system. This failure prevented my vehicle from being driven. The BECM and related battery pack components were replaced under warranty by a Chevrolet dealership. Those parts, to my knowledge, are not available for inspection. -- From a safety perspective, my vehicle was luckily parked when the failure occurred. Many Volt owners have reported -- via online Volt forums and on Reddit at r/volt -- that the failure has occurred while the vehicle is in motion, resulting in a safety issue when the vehicle loses power and stops in the middle of a street or highway. -- A Chevrolet dealership confirmed my vehicle's BECM failure through diagnosis and code reading (see attached documentation). In my case, the BECM initially failed and I lost the ability to drive my vehicle when it was stopped in a parking lot (while I was on vacation, 225 miles from my home). I left the dead vehicle in the parking lot overnight. The next day I was able to start the vehicle and drive it to the nearest EV-certified Chevrolet dealership, where the BECM permanently failed in the dealership's service entrance. I watched the dealership service staff push the dead vehicle into the service bay. It should be noted that I was lucky -- the replacement BECM part was available from GM to the dealership in two days. NHTSA will receive complaints from other Volt owners who waited weeks and MONTHS for a replacement part and repair, all the while their vehicle could not be driven. -- My vehicle's BECM was inspected, the failure diagnosed, and the part replaced by a Chevrolet technician at a Chevrolet dealership (see attached documentation). -- The BECM failure on my vehicle happened immediately with no warning. When I could not drive my vehicle, I saw cryptic "propulsion lost" and "shift transmission to park" error messages on the instrument panel.

- Bemidji, MN, USA

Car is having a few problems in relations to the BECM

- Niagara Falls, OH, USA

Any time the car switches from battery to gasoline the 12v battery comes on, I get the message to shift into park, and the car shuts off. This happens multiple times a day, making it difficult to drive long distance. It also makes it difficult to work more than a couple of hours at a time as an Uber driver. It has happened on the highway, very dangerous.

- Topeka, KS, USA

BECM failure, covered by warranty but required towing that I had to pay out of pocket. Have been waiting a week for the repair to be completed and the dealer is refusing to provide a loaner vehicle.

- York, PA, USA

I was driving home from a client meeting on the highway and received a check engline light with the message "Propulsion Power is Reduced." After a trip to the dealership, I learned that the car's Exhaust Gas Recirculation (EGR) valve malfunctioned and needs to be replaced. Some online research shows that this is a very common issue with Chevrolet Volts. What's worse, the part is back ordered indefinitely because they're not manufacturing enough of them. I know NHTSA is looking into the Battery Energy Control Module (BECM) issue as well. I'm very worried about when happens when/if this fails too and if it happens out of warranty. There should be recalls on both of these common failures and GM should make sure there they're a) all replaced and b) people don't have to wait months to get parts needed for their cars.

- West Hartford , CT, USA

During a drive the car began warning of loss of propulsion. The vehicle is at a dealer waiting for repair since Oct 16, 2023. There is no ETA on back ordered EGR valve that the technician anticipates a fix.

- Leander, TX, USA

As reported by the dealer the Battery Energy Control Module (BECM) has failed. Car initially did not start but then did start with a check engine light and a "Propulsion Power is Reduced" warning. Vehicle has approximately 56,500 miles. Car could have abruptly stopped or slowed considerably while driving. Chevrolet dealer is blaming the current UAW strike for complete lack of replacement parts. They also state there is no way to forecast a delivery date of the part. I am out a vehicle for an unknown amount of time with no promise that GM will reimburse me for out of pocket expenses for a rental vehicle.

- Oak Ridge, NC, USA