Our Chrysler 300C had begun to stall out while driving with more than 3/4 tank of gas. We began to limit the amount of gas to never fill more than 3/4 tank. This lasted for approximately 6 months. In Dec, 2013 the vehicle began to stall at other times. I had between 1/4 to 1/2 in the tank when we were driving at approx 45mph when the vehicle began to stall then restart at first. Then it stalled entirely several times that evening as we tried to make it home. I had my 2 daughters and 2 granddaughters with me at the time. The next morning I took the vehicle to local dlr, lee Chrysler, were I purchased the vehicle. The vehicle stalled on me 3 times while I was trying to make it the 3 miles. The dealer had the car until 12-16-2013 when they advised that the proportional valve/purge vale needed replaced and that all of the updates to the system needed to be made. The total of this attempt to repair was $379.45. The car immediately began to stall again so I returned it. They kept the car for approximately two weeks with their computer hooked up to it then advised that the PCM needed replaced this repair cost a total of $1,018.61. The car was on empty so he offered to stop for gas. He filled the tank up then pulled out to 5 lanes of traffic and stalled. The vehicle would not restart for several attempts. I called the dealer and they wrecker after the vehicle. They had the car for one night and called us to pick up and run the gas out to 1/4tank. We were told it would not stall again because they had disconnected the emissions system. While I was driving the car on a very busy 7 lane hwy with my daughter and 3 month old granddaughter the car came to a dead stop in 40mph traffic. I was terrified but was able to get the vehicle to the center lane. They have now called and advised another sensor must be replaced. Someone is going to get injured or killed in this car.

- Shalimar, FL, USA

Last month, I filled my 300C with mid grade gas, which is what I have always used since I bought it new in 2006, and then directly entered the turnpike. Travel speed was 70 mph. Approximately 1 hour later, exited into a turnpike plaza. There is a left hand turn into the parking area about 500 feet after you exit the highway. As I slowed then coasted around the turn, the engine stalled and the oil light came on. I coasted a short distance until I stopped. I was able to get the car started again, after several tries. This was the first time this had ever happened. I had bought gas and entered the turnpike at that same location many times in the past. I had no further problems getting home. However, last week, I filled up tank and exited my local gas station, which sits on the corner of a main road and a side street. As I turned to get on the side road, the street light turned red, as I slowed to stop, the engine died. I got the car restarted and when the light turned green I stated to go and it stalled again. I got it started drove the 2 miles home and as I pulled into my housing development it stalled a third time. I am not sure what is happening in the engine. This car has had all its maintenance performed at the dealer, including oil changes and has been a great car. I have never had any problems before these stallings started happening.

- Palm Beach Gardens, FL, USA

I've been having a problem with my car stalling after I fill up at the gas station for a few years now. I read that Chrysler was not recalling for this reason so I just read forums and tried not to fill up my gas tank but sometimes I forget and the problem continues.

- Katy, TX, USA

After I fill up (I do not overfill), within the first several miles I drive, the vehicle will stall when slowing down for a stop light. I have also had it that at 40-50 mph it will "hesitate/jerk" like there is a fuel mix issue. This has happened two times in the last week.

- Fennville, MI, USA

After re-fueling vehicle, car stalled at 5 intersections. Vehicle was difficult to restart. Vehicle would not always go back into gear after restarting until several attempts were made. After burning off a few gallons of fuel on the highway, the vehicle no longer stalled/misfired. Tank was not "topped-off" when filled, it was filled until the pump stopped automatically. Stalling occurs every time vehicle is filled to full.

- Mapleton, ND, USA

Vehicle stalls several times after filling up the gas tank, mostly while idling. And, it is difficult to re-start after stalling. Engine also runs "rougher" after fill-up. Problem has gotten worse over the past few months. Took 300C to local mechanic who says there is a problem with the gas tank overflow valve. Solution is to replace gas tank or never completely fill it up. It seems that with all of these similar safety complaints, Chrysler should find an alternative fix.

- Vienna, VA, USA

After filling up the gas tank the car stalled multiple times and was very difficult to start. This happened several times before it would run properly. This happens every time I fill the gas tank. The solution has been to not fill the tank. Chrysler knows this is a problem--the have been able to recreate it in their test.

- Arnold, MO, USA

After fueling my vehicle I drove about 300 feet away from the gas station, and my car completely stalled out without restarting for about 5 minutes. After getting the car to restart I drove for another 5 miles and the car stalled out again. After the second stall I let the car sit on the side of the road for about 10 minutes and turned it back on and drove away. This is not the first time I have experienced this issue, it has happened 2 other times before. I fear that if this keeps happening with no resolution from Chrysler people may have to report something worse than just the car stalling.

- Albuquerque, NM, USA

After refueling the vehicle it stalls. The vehicle looses steering power. This has happened numerous times. I have tried to not let the fuel get to low and have tried filling the tank at different levels with no luck.

- White Plains, MD, USA

After refueling the car it will begin to run, and idle, rough to the point that it stalls. This happens every time the car is refueled. Most of the time it dies while idling, but has died while driving several times. The issue is worse if the car is refueled from the point that the low fuel light is on. It will die several times when refueled from this low level in the tank. The car has died while leaving a red light and getting as far as the intersection and having to try to restart it while in the middle of the intersection.

- Poway, CA, USA

Engine stalled and stopped working as coming out of gas station after filling at gas station. Steering went hard and brakes did not work. Warning light (lub oil can) came up. Turned ignition off and on again, engine started but kept stalling for next 5 minutes. - multiple occurrences - all after filling tank. All subsequent occurrences reported to dealer. Dealer kept vehicle for a week trying to 'replicate' the error but reported no findings.

- Martinez, CA, USA

I filled up the car with gas and after driving about half a mile the engine stalled while in traffic. The car started and stalled repeatedly five or six times for about four blocks. At a certain point the problem stopped and the car was drivable. I took the car to a nearby auto shop and they found no error codes in the system. After leaving the auto shop the car continued to drive without stalling. Several weeks later I filled up with gas again and the problem repeated itself after driving about half a mile. The engine stalled about five times. It was more difficult to turn the engine over this time but it eventually started and drove fine.

- Encinitas, CA, USA

Within a minute or so of refueling, the engine stalled and, consequently, the power steering and power brakes failed. The car would re-start with little difficulty only to stall again very shortly thereafter. Eventually, after perhaps 10 minutes of starts/stalls, and re-starts, operation would return to normal. At the time of the first occurrence, I had no reason to believe that this problem was related to refueling. However, the problem has since recurred with every refueling (at least 4 refuelings so far), resulting in numerous engine stalls in traffic. Apart from these refueling-related incidents the car runs perfectly, and my local mechanic has said that "the car's computer" indicates all systems are normal. A google search on my problem, however, suggests that the problem is extremely common in Chrysler 300cs of a similar vintage.

- Washington, DC, USA

Vehicle stalled after refueling. Filling the gas tank to full without 'topping off' will cause the car's engine to stall without any prior warning. No dtcs/miles are set. Can be restarted with some difficulty. The stall will occur at any engine/vehicle speed and will happen within the first 5 minutes of driving the car after refueling. The problem can be avoided by not filling the tank past 3/4 full. Have tested this 'work-around' at the same gas station & pump.

- Burke, VA, USA

The first time this happened was over a year ago. I had just filled up gas tank and pulled out of lot still in a parking lot of a shopping area. Turned left into a fast food place and car shuts down and would not restart until attempted several times. I was able to pull into a parking spot and went inside. Came out started car was pulling out of lot into traffic and car shuts down again. This time not to the liking of other drivers or myself. Restarted after several attempts drove home and did not happen again till I went on a trip a few months later. Half way through the trip I had to refuel and bingo it happened again after pulling out of gas station lot and turning left into traffic. This is not good. I was able to restart after several minutes and continued my trip on interstate without further incident. Since then it has been ok until just two days ago the 28th of December 2013. It happened again, after filling up and turning left at slow speed car shut down while pulling into a lot. It finally restarted after several attempts. After reading on line I'm not the only one with this problem. When it happened the first time I took to dealer, that I will never take it to again. Short story is they wanted to replace my transmission at the tune of $4500. I left there and drove to a transmission shop who diagnosed and said that there was nothing wrong with transmission. Problem appears to be getting worst and afraid to fill up and pull out into traffic. From what I understand there seems to be a problem with the fuel tank and related components. Please Chrysler fix this problem, I love my 300C.

- Fort Wayne, IN, USA

After refueling, car stalls. This happens after driving approximately 2 to 3 minutes after leaving gas station. The stall has taken place at intersections, while at a complete stop and while driving no more than 5 -10mph after leaving the gas station.. car restarts after several attempts in neutral. When each incident occurs, the oil icon comes on, however the oil level is not low. On one occasion after having backed into a parking space with the car gear shift still in reverse and my foot on the brake, the car lurched. The tires could be heard spinning. That was very scary because my car could have rolled into a busy highway. Once the fuel level indicates approximately a half a tank, no stalling incidents take place. Car was taken to the dealership with this concerned. Service advisor was aware of chyrsler 300C stalls after refueling. Fuel injection system was serviced/cleaned. This has not resolved the problem. Car still stalling. Really afraid to drive the car, however I am taking it back to the dealership to let them know of the still ongoing problem.

- Lithonia, GA, USA

Engine intermittently stalls while either idling or driving. Stalls are increasingly more frequent. Unable to get a diagnosis of problem. Have replaced the PCM but no change in problem occurrence.

- Houston, TX, USA

Electrical problem has been happening since purchase in December 2005. Sometimes power windows will not go up or down, lights on temp gauges and dash have burned out and heated seats occasionally get super hot. Headlights have gone out while driving even after replacing the switch and all the trouble lights have come on while driving down the road. Have taken to many different dealers and none have found any problems they say.

- Locust Grove, VA, USA

I was turning right at a stop light, immediately following a gas tank fill, when the engine stalled and power steering and brakes failed. The engine continued to stall during deceleration or when stopped for the next 30 miles.

- Gilbert, AZ, USA

Stalls after I fill up and jerks violently when moving slowly 0 to 20 mph and hesitates when driving 30 and over if I don't drive around drive around in a parking lot for apx 10 min it will stop in traffic and possibly causing a rear end collision.

- Fort Pierce, FL, USA