10.0

really awful
Crashes / Fires:
9 / 7
Injuries / Deaths:
3 / 0
Average Mileage:
11,401 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2018 Chrysler Pacifica:

Unsubscribe any time. We don't sell/share your email.

« Read the previous 20 complaints

problem #234

Feb 032025

Pacifica

  • miles
After safety recall 73B was performed on my 2018 Chrysler Pacifica Hybrid on 02/03/2025, the vehicle's check engine light illuminated and it began experiencing charging failures. The component that has failed is the high-voltage (HV) battery pack and its control system. Diagnostic scans performed by a Chrysler dealer on [Date of diagnosis] confirmed trouble codes, including U0412, which indicate a critical fault within the battery system. The HV battery is available for inspection upon request. My safety and the safety of others are at risk because the recall was issued to prevent a battery fire. The symptoms my vehicle is exhibiting are precisely the kinds of faults the recall's software update is supposed to detect. By refusing to provide the full remedy, the manufacturer has left an unresolved fire hazard. The problem was confirmed by dealer diagnostic reports. However, both the dealer and Chrysler have refused to replace the defective battery under the recall. Their denial is based on [indicate reason for denial]. The first warning signs, including the check engine light, appeared within days of the recall service. This strongly indicates the recall procedure, specifically the mandatory battery integrity test, was not completed correctly by the dealership. This is a widespread issue, with numerous owners reporting the same post-recall failures online and to Chrysler Cares customer service.

- Columbus, OH, USA

problem #233

Jul 092025

Pacifica

  • miles
Component/system failed: Electric Power Steering (EPS). The system intermittently fails during normal driving, showing a "Service Power Steering" warning. Diagnostic codes include U113E (lost comm w/ EPS), C2217 (SAS not calibrated), C2210 (EPS internal fault), P058C (low voltage), and P1009 (hybrid module MIL request). The issue began immediately after a Chrysler recall service where the main charging unit was replaced. Vehicle is available for inspection. Safety risk: Loss of steering assist creates a serious hazard, especially during turns or at low speeds. The steering becomes extremely heavy without warning, increasing the risk of collision or inability to maneuver safely in traffic or parking situations. Dealer confirmation: Yes. A Chrysler dealer confirmed the EPS fault and quoted $5,500 to replace the entire steering rack. No electrical diagnostics were completed, despite the issue starting after recent electrical recall work. Inspections by others: The dealer has inspected the vehicle. Chrysler corporate has been contacted but has not yet resolved the issue. No inspections by police or insurance. Warning signs: The issue started right after the dealership performed recall work. -??Service Power Steering-?? message appears, and diagnostic trouble codes are present. The error is intermittent and can clear after restarting, only to return later.

- Sarasota, FL, USA

problem #232

Jul 032025

Pacifica

  • miles
On Thursday, July 3, we were on our way out of town and had just gotten on a highway when I smelled something burning, saw smoke (we thought was steam at the time) coming from the hood and heard the engine making a grinding, or rattling noise so we pulled over immediately. My husband got out of the car to start to take a look when another vehicle who had just passed us backed up and motioned frantically saying -??Your car is on fire!-?? So we got out and looked under the front of the car and sure enough, there was liquid spilling onto the ground and fire coming from underneath. So we quickly got away from the car and called 911. Another gentleman who had been going West also stopped to make sure everyone was okay and was also calling 911. Within 10-14 minutes the front of the car was totally engulfed in flames.

- Round Hill, VA, USA

problem #231

Jul 162025

Pacifica

  • miles
The hybrid battery system is malfunctioning. I am not at risk. I am repeatedly getting U0412 error code, indicating a problem with voltage in the hybrid battery system. It only happens intermittedly. I have taken it into the dealer when the check engine light is not on (unfortunately), and they did not find any issue. One time while driving at highway speed, I did get an immediate red message saying "check hybrid system". It went away with the check engine light remaining on for about an hour. This has occurred after (and I think because of) the 73B recall.

- Saint Louis Park, MN, USA

problem #230

Jan 182024

Pacifica

  • miles
I am writing to formally report ongoing and unresolved electrical issues with my 2018 Chrysler Pacifica. Despite replacing both the main and auxiliary batteries, several components continue to fail, including: -??The third-row power seats, which do not function at all or operate intermittently, rendering them impossible to stow or adjust. There is no manual override, which is a serious design flaw for families. -??The rear liftgate, which starts to open and then immediately closes without completing its cycle. -??The passenger-side rear entertainment screen, which is completely non-functional while the driver-??s side screen works normally. These issues have severely impacted the usability and reliability of the vehicle. The third-row seat and tailgate problems, in particular, compromise safety and convenience-?"especially for families with children. The third-row power seat design lacks a manual fallback, which could leave passengers stuck in emergency situations. The liftgate-??s failure to open fully and the battery system-??s unreliability and constant need for replacement (around every 1.5/2 years) has left my stranded countless times. These electrical issues need recalls and solutions.

- Cranberry Township, PA, USA

problem #229

Jan 152025

Pacifica

  • miles
After the 73B recall was performed on my 2018 Chrysler Pacifica Hybrid, the vehicle began experiencing persistent check engine lights and charging issues, especially during charging. Diagnostic scans revealed codes U0412 (invalid data from battery energy control module) and P0BBE (hybrid battery pack voltage variation), both directly related to the high-voltage battery system. These issues began within days of the recall and escalated, with the battery fault becoming permanent by late May 2025. The recall was issued due to a risk of fire from the high-voltage battery, caused by defects that can develop over time. The recall remedy included a software update to monitor for dangerous battery conditions and disable charging if a risk is detected, as well as inspection and replacement of the battery if necessary. My vehicle-??s post-recall symptoms-?"persistent warning lights and charging faults-?"are exactly the type of problems the recall is meant to detect. The problem was confirmed by diagnostic data and scan reports, which were sent from the dealer to Chrysler-??s technical support (STAR), but the vehicle itself was not physically inspected by the dealer or STAR. Both refused to authorize battery replacement, citing the contradicting STAR report, despite clear evidence of battery failure and the recall-??s stated purpose. The battery and related components are available for inspection upon request. My safety and my family-??s safety are put at risk, as the recall specifically warns owners not to charge or park the vehicle near structures until the remedy is complete, due to fire risk. Multiple other owners have reported similar post-recall battery failures, indicating a broader unresolved safety issue. Chrysler has not provided a satisfactory resolution, and the vehicle continues to exhibit battery faults and charging issues after the recall remedy.

- Hickory Hills, IL, USA

problem #228

Jun 192025

Pacifica

  • miles
Vehicle engine shuts off while driving down the road. Will start up after a few minutes. Traction control light and auto start stop light will come on. Random right wheel noise will come and go. Have had multiple mechanic shops check vehicle with no findings. Vehicle loses all power when shuts down.

- Catlettsburg , KY, USA

problem #227

Feb 182025

Pacifica

  • miles
I had my Chrsyler Pacifica since Nov 2018. Recently I heard a noise and Dealer suggested change in Transmission. Ever since I have problem with Car stopping im middle of road, towed 5 times to dealer and dealer says he fixed it but still same problem with vehicle stalling happen. yesterday (05/20), delaer informed that vehicle stalled in road while they did test drive after they fixed the problem. I am scared to drive this car anymore. Dealser did not want to loan their car as well anymore, I am without car for more than 30 days during this all 5 incidents.

- Cerritos, CA, USA

problem #226

Apr 302025

Pacifica

  • miles
Hello: My 2018 Pacifica hybrid was just recalled, and serviced, yet the hybrid battery only last a few miles before needing to be recharged. Also, when in reverse the back up camera doesn-??t always come on and doesn-??t beep when approaching an obstacle. It will also stay on while driving forward.

- Apple Valley , CA, USA

problem #225

Oct 312024

Pacifica

  • 135,000 miles
The contact owns a 2018 Chrysler Pacifica. The contact stated while reversing, the back-over prevention camera screen failed to function as intended. The back-over prevention screen displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with computer and electrical system failure. The contact was informed that the back-over prevention assembly, instrument cluster, and electrical system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall; however, the VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 135,000.

- Atascosa, TX, USA

problem #224

Nov 212024

Pacifica

  • miles
The vehicle randomly stalls, goes dead and becomes unresponsive. This has happened numerous times at lights, stop signs and in the middle of the road.

- Seattle, WA, USA

problem #223

Dec 242024

Pacifica

  • 73,692 miles
The contact owns a 2018 Chrysler Pacifica. The contact stated while driving 30-35 MPH, the vehicle made an abnormal beeping sound. The message "Stop Safely - Vehicle will shut off soon" was displayed, and the vehicle stalled. Several unknown warning lights were illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart, and the contact continued driving. The contact stated that the failure had previously occurred while her husband was driving at an undisclosed speed. The contact's husband was able to pull to the side of the road, and the vehicle was able to restart after an extended period. The vehicle was taken to the dealer, where it was diagnosed as a low voltage failure. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE22008 (Power Train). The manufacturer was not notified of the failure. The failure mileage was approximately 73,692.

- Peachtree Corners, GA, USA

problem #222

Dec 272024

Pacifica

  • miles
While driving on the freeway, the van suddenly started to -??drag-?? and alarm that the start/stop system was unavailable. I was barely able to pull off the freeway before the van completely stopped moving and would not start up again.

- Green Bay, WI, USA

problem #221

Nov 012024

Pacifica

  • miles
The hybrid battery coolant heater (part 68443445AC) was confirmed a problem, however the dealership wont review ANY recalls on my vehicle until I pay $1700 to replace that part. However, there are MULTIPLE incidents online showing this is a problem with this vehicle and should be a recall as this is obviously defective within the first 150000 miles. My car has roughly 124K miles, making it just outside the warranty coverage. Shortly before this lamp warning (check engine) came on my steering wheel started "sticking" making it hard to steer in a curve, causing me to veer off the road. Within 7 days of this happening, is when my check engine light appeared, throwing code POE15. The heat now also takes much longer to warm up- like 30 minutes longer. The dealership said none of the issues are connected, however after online research I have determined that is not true.

- Jasper, GA, USA

problem #220

Mar 012019

Pacifica

  • 64,000 miles
The contact owns a 2018 Chrysler Pacifica. The contact stated that since 2019, the "Auto START/STOP feature unavailable" message was displayed on the instrument panel. Due to the failure, the vehicle intermittently failed to start, the vehicle was jerking and hesitating while depressing the accelerator pedal, and the vehicle also shut-off unintendedly while driving at various speeds. The vehicle had been towed to a dealer on several occasions and the auxiliary and the main batteries replaced; however, the failure returned approximately a year and a half later. To prevent the failure from recurring, the contact disabled the Auto START/STOP feature to prevent the vehicle from stalling. The contact stated that numerous repairs had been performed on the vehicle and that the only other solutions would be to replace the transmission, perform a software update or replace a possible unknown sensor. Additionally, the contact stated that while turning off the vehicle there was an abnormal knocking sound coming from the engine. The manufacturer was notified of the failure and the contact was given a case number. The vehicle was not repaired. The failure mileage was approximately 64,000.

- Norfolk, VA, USA

problem #219

Nov 072024

Pacifica

  • miles
There was a fire of unknown origin within the van. The fire was self extinguished and contained to the inside of the vehicle. No one was in the vehicle at the time of the fire, and it was found about 45 minutes after leaving the vehicle parked.

- Paulsboro, NJ, USA

problem #218

Sep 252024

Pacifica

  • miles
REPAIR ORDER DATE: 11/04/2024 MIKE PERRY CHRYLSER/NACOGDOCHES PROBLEMS: SHAKING WHILE IDLING/STOP-START NOT WORKING ACTIONS TAKEN: REPLACED SUPPORTS AND MOUNTS ENGINE SUPPORT -?" $105 TRANS MOUNT -?" $274 ENGINE MOUNT -?" $155 PARTS - $535 LABOR - $600 TOTAL - $1191 REPAIR ORDER DATE: 10/14/24 - MIKE PERRY CHRYSLER/NACOGDOCHES PROBLEMS: CHECK ENGINE LIGHT ON/ENGINE MISSING ACTIONS TAKEN: REPLACED GASGETS, GASGET FLANGE, CAMSHAFT, THERMOSTAT GASGET - $250 GASGET -?" $120 GASGET EXHAUST FLANGE - $43 CAMSHAFT INTAKE - $572 ANTIFREEZE COOLANT - $53 THERMOSTAT - $122 PARTS - $1014 LABOR - $3752 TOTAL - $5129 REPAIR ORDER DATE: 10/02/24/SOUTHERN CHRYSLER LUFKIN ISSUE: CAR WOULDN'T START ACTIONS TAKEN - REPLACED STARTER AND BATTERY FUSE FUSE BOX - $202 LABOR - $636 TOTAL - $855 REPAIR ORDER DATE: 9/25/24 /MIKE PERRY CHRYSLER /NACOGDOCHES ISSUE: CHECK ENGINE LIGHT ON ACTIONS TAKEN: REPLACED SPARK PLUGS AND COILS IRIDIUM IX - $15 IGNITION COIL SET - $274 LABOR - $300 TOTAL - $710 SERVICES FROM 9/25/2024 THROUGH 11/04/2024 *Approximately 6 weeks TOTAL EXPENSES $7,855

- Lufkin, TX, USA

problem #217

May 062024

Pacifica

  • miles
Vehicle just dies when you brake. This has now happened twice. Once in May 2024 and now Oct 2024. You have no steering and cannot be put into neutral or park. Must pull neutral cord to get pushed out of road. No codes pull up other than the neutral cord used. In May 2024 towed to dealer and they replaced starter but could not find anything else. In Oct 2024, took it to an independent car place and he could not find anything wrong, just re-boot computer. This is very dangerous; this is a handicap van modified for a wheelchair person to be put in through the back of the van. If I get hit in the back, I can't get my son out of the van. Extremely unsafe! I know the 2017 Chrysler Pacifica's were recalled for this and I believe the powertrain control module software was updated or the chip was replaced. This needs to be recalled for the 2018's also.

- Jackson Township, NJ, USA

problem #216

Sep 132024

Pacifica

  • 104,417 miles
The contact owns a 2018 Chrysler Pacifica. The contact stated while driving approximately 40 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the power steering and braking functionality were inoperable. The contact had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the batteries and the alternator needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V348000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was 104,417.

- Arlington, TN, USA

problem #215

Sep 242024

Pacifica

  • miles
The vehicle has stalled several times while driving and while at a stop light leaving the van completely disabled and it will not turn on or start again. My wife and 2 year old were put at risk when the vehicle stalled on them at a major intersection and my wife was unable to put the vehicle into parking or drive since there was no power after it stalled and dashboard lights flicked on and off multiple times.. Stall has also happened at drive thru almost causing collision with vehicle in front. The stall produces dashboard error messages reporting an internal transmission malfunction, auto start/stop error, and or a problem charging the battery. Certified ASE mechanics can-??t reproduce the issue or find anything to pin point the issue after multiple diagnostic tests ran and physical thorough inspection. Every time a stall happens loads of error codes (85+) pull up but none point to the root cause of stalling happening. Vehicle has most up to date software update done over a year ago.

- Grayson, GA, USA

Read the next 20 complaints »