Drivers seat problem. Active headrest restraint faulty the plastic retention tabs holding the metal bar in place spontaneously broke, the metal teeth were still locked down on the bar showing it didn't deploy, just the plastic tabs broke. This caused the headrest to 'activate' and move forward. This is a safety issue. Vehicle was parked in driveway. No injuries as no one in the car.

- Wilbraham, MA, USA

The headrest active restraint system deployed while driving in town. The plastic piece that holds the pin broke.

- Orlando, FL, USA

The headrest active restraint system deployed while sitting in our driveway. The plastic piece that holds the pin broke.

- Port Orange, FL, USA

Noticed passanger headrest had deployed one day. Plastic ears that hold latch pin in place had broken. Vehicle was stationary, no injuries.

- Palm Bay, FL, USA

The headrest broked by itself, the plastic of the mechanism cracked causing the headrest to be hold in place just by the material. The vehicle was parked, not involved in accident or anything else.

- Haslet, TX, USA

My 8 year old son leaned with his hand on the back of the driver side head rest. The head rest released shooting forward. Upon trying to reset the headrest I noticed the plastic piece needed to hold the spring mount to lock it was broke thus not allowing me to reset the headrest. The car was parked and off while this happened.

- Spring City, PA, USA

The front drivers seat head rest exploded when I was getting into the car the car was parked

- Carteret, NJ, USA

On July 3, 2020 I was sitting at a red light at night when my driver side headrest deployed/exploded without any warning, my vehicle was not in motion at the time. No injuries but headrest is defective now. I would have been injured if I was resting on it at the time without a doubt.

- Garland, TX, USA

Drivers seat active head restraint deployed unexpectedly with no impact or known reason.

- Edinburgh, IN, USA

Our 2014 Chrysler Town and country driver's side head rest deployed. The car was stationary....parked in our driveway. No one was hurt. The plastic pieces are broken ut the metal pin is in place.

- Travelers Rest, SC, USA

Got in my car this morning and noticed my passenger head rest was sticking out. Did some research and come to find out the head test deployed for no reason. I looked at it more and plastic inside of it broke which cause it to deploy for no reason.

- Youngstown, OH, USA

Wife was driving the car as normal when both active head restraints deployed for no reason. There was no sudden stop, no impact. One blew all the way apart, the other blew half apart, and then blew completely when she touched it to try to assess what the problem was. The cause is simple to determine. The head restraint is a metal pin retained by cheap plastic, and the plastic broke. I have the plastic chips to prove it.

- Annandale, VA, USA

I was sitting in a parking lot and my passenger side headrest deployed. I'm scared my driver's side will be next. Chrysler wanted to charge me $800 to replace it when it was clearly a defective part.

- Southaven, MS, USA

While the car was parked the active headrest deployed hitting the driver in the back of the head after they got in the car and were getting ready to drive off. The metal rod remained in the engaged position in the bracket but the plastic edges that hold the metal rod to the headrest broke which caused it to deploy.

- Scarborough, ME, USA

Both driver side and passenger side headrests have spontaneously deployed within a 6 month period. This is due to a flawed design by Chrysler engineering (used plastic clips to constrain strong spring loaded actuators in the headrest). The driver side deployed while I was driving, hitting me in the back of the head and distracting me in traffic!

- Martinez, GA, USA

I filed with the manufacturer...and once again the run round. Sent me to you... so below is my complaint. Hello " my name is [xxx]. I purchased this 2014 Chrysler Town and country believing it would be a safe vehicle for my family so the event today was the van just decided to shut off as I am driving 50mph down the road! I couldn't turn, I couldn't put it in neutral nor could I brake! I have a 5yr and a 3yr in my car!!! really?! all these sensors and [xxx] in this car makes it fatal! there was a semi behind me that proceeded to flip me off and blow the horn at me instead of seeing if we were ok. We could have been killed! I have an appointment tomorrow to bring the car in however this is a serious situation. No warning! no nothing! no check engine light. Let me just tell you a little more about this pos? I bought it with 30K miles on it. I only had it for about 6 months and had to have the entire transmission rebuilt which still to this day shifts hard and feels like its going to literally fall out of the car. After that is was a tire sensor, then both seats in the second row wont work and they want $1200 to fix a cable! I folded them into the floor maybe 4 times as we use them when going on vacation! the sliding doors act up like they are having a seizure! the pieces all around the car are broken. The running boards the piece in the back where the trunk is and the pieces on the front where it says Chrysler. The air conditioner went out! which took 3 times for the repair man to figure it out because there was no code for the problem! then when they had to tear the whole dash apart to fix the problem now the clock doesn"T work and the speedometer ticks like the is a bomb in my dash! information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Clearwater, FL, USA

The driver side headrest's airbag deployed without any particular reason. The van was parked in the driveway, and my wife was taking out her bag from the passenger section when suddenly the headrest deployed.

- Hialeah, FL, USA

The passenger side active headrest exploded (luckily just after we got out of the car). There was not a accident that triggered it. The car was parked in our driveway. The engine was turned off. Upon researching I see many complaints of this same issue. This needs to be recalled!

- West Des Moines, IA, USA

Passenger side head rest ejected and will not reset. There were no accidents involve, the vehicle was stationary when the headrest activated. Need to zip tied the head rest back in place. The

- Gaithersburg, MD, USA

I was driving on the highway (going at least 65 mph) and the headrests on the front passenger seat exploded. The air bag light on the dash had been going on and off for the past 2 weeks, I notified Chrysler via telephone with no response. About 1.5 weeks later the airbag light returned on (intermittently) and then I heard another loud "pop" in the drivers seat but nothing exploded open.

- Loveland, OH, USA