1999 Dodge Caravan
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1999 Caravan are official communications between Dodge & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #1900303
POP/TICK SOUND IN STEERING WHEEL AREA. *TT Read More »
-
TSB #190999
A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION. *TT Read More »
-
TSB #190598
A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS. *YC Read More »
-
TSB #1900801
EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT Read More »
-
TSB #020300
EXPERIENCING A KNOCKING / CLUNKING SOUND COMING FROM THE FRONT SWAY BAR LINK HEARD INSIDE AND OUTSIDE THE VEHICLE WHEN DRIVING OVER ROUGH ROADS. *TT Read More »
-
TSB #021098
A SQUEAKING / CHIRPING NOISE IS HEARD ( INSIDE OR OUTSIDE THE VEHICLE ) FROM THE STRUT TOWER AREA( S ). *YC Read More »
-
TSB #0200401
EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT Read More »
-
TSB #0500305
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT Read More »
-
TSB #0500204
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT Read More »
-
TSB #0500102A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT Read More »
-
TSB #0500101
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. Read More »
-
TSB #051099
INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS. *TT Read More »
-
TSB #0500301
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. Read More »
-
TSB #0500106A
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB Read More »
-
TSB #050999
INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE. *TT Read More »
-
TSB #68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Read More »
-
TSB #R2118796A
Valve Body. These may cause over drive cycling. Read More »
-
TSB #0900801
SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT Read More »
-
TSB #180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT Read More »
-
TSB #180200
CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS. *TT Read More »
-
TSB #090798
SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK. *YC Read More »
-
TSB #090598
A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES. *YC Read More »
-
TSB #090198 REV B
VEHICLE EXPERIENCING A TICKING NOISE WHILE AT IDLE FROM ENGINE. *YC Read More »
-
TSB #070299
CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY. *TT Read More »
-
TSB #832
EMISSIONS CALL FOR AN INCORRECT VEHICLE EMISSION CONTROL INFORMATION (VECHI) LABEL WHICH WAS INADVERTENTLY INSTALLED. *TT Read More »
-
TSB #250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC Read More »
-
TSB #180300
SUBJECT REGARDING EGR MONITOR DIAGNOSTIC TEST DIFFICULT TO COMPLETE OR NOT READY AT HIGH ALTITUDES (ABOVE 4000 FEET). *TT Read More »
-
TSB #2601000
INFORMATION REGARDING UPDATES TO THE FUEL SYSTEM SERVICE PROCEDURES. *TT Read More »
-
TSB #210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT Read More »
-
TSB #210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT Read More »
-
TSB #210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT Read More »
-
TSB #181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT Read More »
-
TSB #9913
VEHICLES MAY EXPERIENCE FAULTS RELATED TO THE TRANSMISSION RANGE SENSOR (TRS). *TT Read More »
-
TSB #0700601
SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE. *TT Read More »
-
TSB #030698
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
-
TSB #030698
RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK Read More »
-
TSB #211599
SUBJECT ON TRANSAXLE SEEPAGE MIS-DIAGNOSIS- CASE POROSITY. *MJS Read More »
-
TSB #9920
INFORMATION ON FAST FEEDBACK FLEET - INSTALLATION OF 2000 MODEL YEAR 41TE TRANSAXLES. *TT Read More »
-
TSB #08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
-
TSB #0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT Read More »
-
TSB #0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB Read More »
-
TSB #081500
A CONDITION MAY EXIST WHERE THERE IS INTERMITTENT OPERATION / STATIC OCCURING IN THE FRONT INSTRUMENT PANEL SPEAKERS. *TT Read More »
-
TSB #083498
INFORMATION ON ELECTRICAL FEATURE CHANGES. *YC Read More »
-
TSB #084098
SUBJECT REGARDING BODY CONTROL MODULE AUTO HEADLAMP SENSOR/ SIGNAL CIRCUIT DIAGNOSTIC TROUBLE CODE (DTC). *YC Read More »
-
TSB #083498
INFORMATION ON ELECTRICAL FEATURE CHANGES. *YC Read More »
-
TSB #080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT Read More »
-
TSB #190699
INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE. *TT Read More »
-
TSB #9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
-
TSB #9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. Read More »
-
TSB #9919
SERVICE ACTION REGARDING HEADLAMP AIM PROCEDURE CHANGE. *TT Read More »
-
TSB #235998
WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR. *AK Read More »
-
TSB #2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT Read More »
-
TSB #2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC Read More »
-
TSB #2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT Read More »
-
TSB #0801102
CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY. *TT Read More »
-
TSB #082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT Read More »
-
TSB #083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT Read More »
-
TSB #081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC Read More »
-
TSB #31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
-
TSB #31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
-
TSB #3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
-
TSB #3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
-
TSB #3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
-
TSB #2304402
COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT Read More »
-
TSB #231100A
A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT Read More »
-
TSB #231100
THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE. *TT Read More »
-
TSB #233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS Read More »
-
TSB #230199A
EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT Read More »
-
TSB #230199
SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT Read More »
-
TSB #183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC Read More »
-
TSB #182598
SUBJECT REGARDING ERRONEOUS BODY CONTROL MODULE DIAGNOSTIC TROUBLE CODE. *YC Read More »
-
TSB #9827
INFORMATION ON BODY CONTROL MODULE (BCM) REPLACEMENT. *YC Read More »
-
TSB #2304200
EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED. *TT Read More »
-
TSB #233399
CONCERNS WITH THE RIGHT SIDE SLIDING DOOR TRIM PANEL CONTACTING THE QUARTER PANEL WHEN THE DOOR IS OPENED. *TT Read More »
-
TSB #230399
CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE. *TT Read More »
-
TSB #233498
THE FRONT DOOR BODY MOUNTED WEATERSTRIP FALLS OFF MOUNTING FLANGE, USUALLY ALONG THE TOP OF THE DOOR OPENING. *YC Read More »
-
TSB #082799
CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE. *TT Read More »
-
TSB #210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT Read More »
-
TSB #140399
EXPERIENCING VIBRATION / BUZZ IN THE ACCELERATOR PEDAL AT 2200 - 2500 RPM AND ABOVE 3500 RPM. *TT Read More »
-
TSB #220399
SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION. *TT Read More »
-
TSB #220299
CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE. *TT Read More »
-
TSB #220100
INFORMATION ON SPARE TIRE WINCHES. *TT Read More »
-
TSB #220198
INFORMATION ON VEHICLE ALUMINUM WHEELS HAVING A UNIQUE BALANCE WEIGHT RETENTION FLANGE. *YC Read More »
-
TSB #2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT Read More »
-
TSB #08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are ... Read More »
-
TSB #31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Read More »
-
TSB #31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Read More »
-
TSB #3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Read More »
-
TSB #23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
-
TSB #1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. Read More »
-
TSB #084599
VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION. *TT Read More »
-
TSB #082798
PERCEIVED LOSS OR CAHNGE OF RADIO STATION PRESETS. *AK Read More »
-
TSB #081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK Read More »
-
TSB #9911
SERVICE ACTION REGARDING VEHICLES EQUIPPED WITH LUGGAGE RACK CROSSBAR INSTALLATION INFORMATION. *TT Read More »
-
TSB #9915
SERVICE ACTION REGARDING AN INCORRECT VEHICLE EMISSIONS CONTROL INFORMATION (VECI) AND MONRONEY LABELS INSTALLED ON VEHICLES EQUIPPED WITH CALIFORNIA EMISSION. *TT Read More »
-
TSB #241099A
VEHICLES MAY EXHIBIT AN INTERMITTENT CONDITION WHERE THE A/C SYSTEM BLOWS WARM AIR AFTER THE A/C SYSTEM HAD BEEN WORKING PROPERLY. *TT Read More »
-
TSB #241099
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE AIR CONDITIONER SYSTEM BLOWS WARM AIR INTERMITTENTLY. *TT Read More »
-
TSB #240798
CONDITION WITH A/C COMPRESSOR LOCK-UP AT LOW MILEAGE. *YC Read More »
-
TSB #9843
EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION. *YC Read More »
-
TSB #241198
SUBJECT REGARDING A/C SUCTION AND / OR DISCHARGE LINE REQUIRES REPLACEMENT DUE TO CRACKING AT OR NEAR COMPRESSOR. *AK Read More »
-
TSB #23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Read More »
-
TSB #1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC Read More »
-
TSB #2601200
INFORMATION ON SERVICE PUBLICATION UPDATES. *JB Read More »
-
TSB #182299
SOME VEHICLES MAY EXHIBIT INTERMITTENT MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH HEX CODE $1B (P0123) THROTTLE POSITION SENSOR (TPS) VOLTAGE HIGH. *TT Read More »
-
TSB #081699A
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT Read More »
-
TSB #081699
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT Read More »
-
TSB #234598
APPROVAL OF USING OF IN- TRANSIT PROTECTIVE FILM. ON ALL VEHICLES AT ALL ASSEMBLY PLANTS. *AK Read More »