10.0
really awful- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 1 / 0
- Average Mileage:
- 70,195 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
« Read the previous 20 complaints
Upon filling the vehicle with fuel it will spit back a considerable amount of fuel after pumping has stopped full. Its amazing that a recall was issued for the 2005 Durango for this problem and not the 2006. A quick google search shows the scale of the continued fueling problem on Durangos. This problem has been occurring over the past 2 years at multiple gas stations.
- Omaha, NE, USA
Gasoline overflows from filler neck when filling fuel tank. A considerable amount of gasoline overflows after gasoline pump shuts off.
- Hutchinson, MN, USA
When refueling the vehicle and filling the tank to full or near full, when the fuel nozzle shuts off automatically, fuel will spray out of the filler neck all over the side of the vehicle and all over the ground and the driver. Approximately 1/3 to 1/2 gallon of fuel will be expelled from the tank. This started after I had about 75000 miles on the vehicle. It will happen every time I fill the car up. As a result I can only fill the tank about 3/4 full. The fuel has destroyed the paint on the side of the car. I have had to drive 20 miles home soaked in gasoline after this has happened. I'm glad no one flipped a cigarette in my direction!
- Glen Rock, PA, USA
The contact owns a 2006 Dodge Durango. The contact stated that when attempting to refuel the vehicle, the fuel was spewing out. The contact mentioned that he had to listen to when he thought the tank was going to be full to stop fueling. The failure recurred numerous times. The vehicle was taken to a dealer however the contact could not recall the diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 67,000.
- Three Rivers, MI, USA
Each time I fill up my gas tank when the pump kicks off gas spills out of the tank onto the ground. The car was parked and off
- Rosedale, MD, USA
Each time I fill up my gas tank when the pump kicks off gas spills out of the tank onto the ground. Dodge says they are aware of the problem but because my vehicle is listed as "restricted" in their data base they cant tell me exactly what restricted means only that it may have been classified as a total loss at some point. I purchased the vehicle used but had no issues registering it or insuring it in NJ. Dodge says there is a lifetime warranty on this problem but because it is not a recall they refuse to make the repair for me because of my vehicles "restricted" status so I guess if I am refueling and gas spills out and catches the place on fire Dodge wont care I would like to file a complaint this should be a recall and not just a warranty issue there is a significant chance of someone getting severely burned or killed if this spill happens near an ignition source. Please advise me of my next course of action.
- West Milford, NJ, USA
The contact owns a 2006 Dodge Durango. While refueling the vehicle, fuel ejected out of the tank. The failure recurred on numerous occasions. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 69,000.
- Phil Campbell, AL, USA
As I braked to park the Durango, the engine abruptly stalled. Not sure why it stalled, but I know there was a problem with the 2004-2005 Durangos where the engine would stall during sharp turns while braking.
- Camp Hill, PA, USA
When I fill the gas tank, the pump does not automatically shut off and gasoline spews all over the place. I just purchased this car less than a week ago and have had it happen every time I fill it up.
- California, KY, USA
When I took my vehicle in for a recall I was informed that the right manifold studs were broken and the repair was going to cost $765. I took the vehicle into my regular mechanic to determine if I was being informed correctly. He advised that the Chrysler dealer ship did not remove the heat shield to verify that this was actually the issue. The mechanic mentioned he could determine this by looking at the fasteners of the heat shield. The mechanic said that this happens a lot to Chrysler products. He said that is why they did not need to remove the heat shield. When the studs are broken it allow the exhaust system to leak. My question is if this is a regular problem with Chrysler why is there not a recall. I called Chrysler to see what they would do about paying for a repair for a constant issue. They said there has not been many problems of this nature. Can this be investigated by having Chrysler mail out S survey to actually determine if this is a material defect in their studs?
- Cumming, GA, USA
This Durango had spewed gas during fill up ever since purchased 11/2006, so I just tried to be careful when filling. April 2012, I had some rust fixed around the rear wheel area on the gas tank side. Did not really think too much about it at the time. 1/29/14 I had an inlet check valve replaced at the dealership due to notification from Chrysler and they said this could be a safety issue. Thought then that this defect is probably what caused my rust issue but I had had that fixed so did not think anything about it....until it started to rust again in the same area. This is a without a doubt caused by the faulty inlet check valve. I believe Chrysler intentionally did not notify their clients until the 100,000 mile rust warranty was up. They will not stand behind the resulting damage from the faulty inlet check valve.
- Dekalb, MO, USA
The contact owns a 2006 Dodge Durango. While operating the vehicle, the power train erroneously switched to the 4 wheel drive low position and the traction control and 4 wheel drive sensor lights illuminated. While stuck in the 4 wheel drive position, the vehicle became very difficult to steer and failed to accelerate normally. When refueling the vehicle, fuel would spew out of the filler neck. The cause of the failures was not diagnosed. The manufacturer was not notified of the failure. The failure mileage was 135,000.
- Allenstown, NH, USA
When I fill up my gas tank, the gas does not stop flowing when the tank is full. The indicator does not work, therefore gas spills out onto the ground every time I fill up the tank.
- New Orleans, LA, USA
I went to fuel up my car, when it reached full, fuel started spitting out of the tank. It has done this on numerous occasions.
- Boyd, TX, USA
The contact owns a 2006 Dodge Durango. The contact stated that the fuel tank was defective and fuel spilled onto the ground when the fuel tank was filled to capacity. The failure was experienced several times. The vehicle was not taken to the dealer for diagnostic testing. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 1,000.
- Camas , WA, USA
I am constantly having to watch as I fill my tank on this car, because their is no way of knowing when the gas will spill out onto my car. The constant overflow has effected the paint near the gas tank as well as run under the body of this car. This is an issue which no one wants to address but I hope soon it will be resolved. It is a hazard to the owner and those who are near us when we attempt to fill our car.
- Purcellville, VA, USA
This vehicle had a fuel overflow problem. Chrysler has a lifetime warranty on fixing this. The problem is that the gas that was continuously overflowing on fill-up has caused the vehicle to rust under the gas tank. Chrysler is saying this is not covered. Also on the lift gate under the silver piece above the handle there is rust forming from dripping on each side of this silver piece. I believe this is a manufacture defect, but Chrysler is saying none of this is covered.
- Blackwell , MO, USA
Everytime I fill up or come close to filling up the gas will come shooting out of the tank. It gets all over me, the vehicle and the ground. It can shoot as far as 4 or 5 feet away from the vehicle. I have stopped putting more than 1/2 a tank at a time in it but it is a huge inconvenience to have to stop for gas so much.
- Arlington, TX, USA
When gas tank gets full, gas spills out of the tank all ovdr car and person standing there. You have to fill tank very slowly. Car is rusting below gas cap from all the gas that has spilled there.
- Frisco, TX, USA
- Franklinville, NC, USA