Engine failure. Engine failed due to water ump allowing water to enter engine via oil pan. Sludge problems caused timing chain to be excessively tight thereby causing too much pressure on waterpump bearings. Waterpump bearings failed thereby letting water flow directly into engine. Oil has been changed in this car regularly. This is entirely a design flaw. I still owe a lot on the car and can't afford a new engine or even a used one.

- Gallman, MS, USA

The vehicle just started knocking to it to the shop and was told it need a new engine car has less the 70,000 miles on it and its only a 2002. The repair shop says it has sludge that caused it to spin a bearing. The good news I have a warranty the bad news is the wont cover the whole repair and is given me the run around about fixing the car. Also had to have the transmission replaced just 2 months ago.

- Hephzibah, GA, USA

On 12/18/2002, I purchased a "leftover" 2002 Dodge Intrepid SE. I recently refinanced my home and paid off the car loan less than 3 years later. As soon as I recieved my title for the vehicle, the engine failed! I brought the Intrepid to a local mechanic who stated that he saw sludge in the engine and that I should contact sansone route 66 in neptune, NJ to replace the engine. I contacted the dealer who stated that the vehicle was out of warrantee for two reasons; first, because the Intrepid has 47,000 miles on it (I bought it with 12,801 miles on it) and second, because the mechanic found sludge in the engine which I was told was my fault for not changing the oil! I have changed the oil regularly with mobile1 synthetic oil and used mobil 1 oil filters (confirmed by mechanic) as well as having other oil changes done. This is a complete failure of Dodge/Chrysler to honor its commitment to repairing faulty engines; I have done research and have observed many others with similar problems.

- Toms River, NJ, USA

I was driving to church on May 15, 2005 while I was approaching a stoplight the water temp. Gauge began to move to the dangerously high temp. Side and then the engine began making a ticking sound and white smoke came from the engine, then the engine shuts down completely. The thermostat & water pump failed which led to the oil getting hot inside the engine, which led to oil sludging because of narrow oil ports within the engine, which cause the timing chain to fail and the cylinder heads to become damaged. I called Chrysler about this engine defect and they placed the blame on me instead of fixing the defect. I will now have to replace the engine for $4,000 or let it be repossessed. I have a 2002 Dodge Intrepid SE with 2.7L engine.

- Fayetteville, NC, USA

Contact states the engine failed. When taken to a local service dealer they stated there was 1-2 pints of excess liquid in the motor oil.

- Albany, NY, USA

After getting a tune-up and coming back from a trip, without warning, the car started making clicking noises. The driver pulled over, and it had to be towed. Caller found out that the engine was a discontinued motor because it was a defective motor. Dealer said the motor was not worth replacing, and she had not called manufacturer yet. Caller had reason to believe there was consumer actions on this motor.

- Decater, GA, USA

Went to get a routine oil change; mechanics showed me the oil, stating that I needed to bring the car to the dealership due to a possible blown head gasket. In actuality, I need a new engine. The car only has 48000 miles on it. I have owned it for less than 1 year and still make payments.

- Sacramento, CA, USA

Consumer states the engine developed a sludge build up. As a result, the engine needs to be replaced.

- Liberty, MO, USA

While driving on the highway engine completely failed. Contacted the dealer, and was told that there was a problem with the 2.7 liter engines. Sludge buildup caused the engine to overheated suddenly.

- Palm Coast, FL, USA

Merging into traffic when engine blew. Had to have car towed and engine replaced. Had to tow car from first shop who wouldn't work on it to another shop. With out use of car from 12-23-04 to 01-31-05. But still making car payments. Had to travel 220 miles to get car when work was done than 220 miles back. Engine was replaced with another out of wrecked vehicle. Old engine was turned in for core charge to a salvage yard.

- Mission, KS, USA

While driving vehicle stalled. Consumer was unable to restart vehicle, and had it towed to dealer. Mechanic determined that engine needed to be replaced due to sludge build up.

- Toledo, OH, USA

I financed a 2002 Dodge Intrepid in February 2003. The payments are over $400 per month for 6 years.on December 21, 2004, the engine failed. I still had a warranty on the vehicle, so I called to have it towed to the dealer where I purchased it. After authorizing them to break the engine down and see exactly what the problem was, I was told it needed a new engine. After the warranty company came out to do their inspection, I was told it was my fault and I was responsible for all charges. They said the problem was sludge buildup and lack of oil change. My problem is that there was no warning at all. There was no engine knocking, the check engine light never came on, the car was running good. And then one day the engine is no good. I still have 4 years to pay for this vehicle and I have to buy a new engine, which costs $4,000 to $7,000. (the engine only had 59,000 miles on it) this doesnt make any sense to me. I also have to pay the dealer $360 for breaking the engine down to find the problem. Is there any help for me or is there anything I can do? in the past week I have heard hundreds of complaints about these engine problems in the Dodge Intrepid. Thank you for your time. Lori justice 12/30/04.

- Clementon, NJ, USA

While driving consumer heard a ticking noise. Consumer pulled off of the road, and had the vehicle towed. It was later discovered that engine was blown. Manufacturer stated the warranty expired after the vehicle 's oil was changed.

- Delphos, OH, USA

Cooling system failure cause the car to over heats and resulted in total damage of the engine; crysler refuses to supply the engine and my car is dismantled in the dealership for more than three weeks, and the dealership refuses to put back my car the way it was when was towed to the shop. I need desperatelly need help.

- Woodside, NY, USA

While driving 65 mph, the vehicle stalled without warning. The driver tried to restart the vehicle and was not able to do so. The vehicle was towed to the dealer for inspection. The mechanic informed the driver that the engine needed to be replaced.

- Baraboo, WI, USA

While driving 25 mph consumer heard a loud noise coming from the front of the vehicle. Suddenly the vehicle stalled. Consumer restarterd the vehicle, and it was taken to the dealer for inspection. Mechanic determined that the engine blew out, and needed to be replaced.

- Tucson, AZ, USA

While driving engine failed due to sludge inside the engine. Consumer pulled over, and had the vehicle towed. Dealership was notified, but did not resolve the problem.

- Concordia, KS, USA

While driving 45 mph the engine failed completely without warning. Please provide additional information.

- Belton, MO, USA

Vehicle commenced to rattle and make other noises while coming onto the freeway. Vehicle would not restart. Dealer was notified, and informed the consumer that engine need to be replaced.

- West Point, VA, USA

While driving vehicle stalled. Consumer was unable to restart vehicle, and towed it to dealer for inspection. Mechanic detrermined that the engine needed to be replaced.

- San Diego, CA, USA