I took my vehicle in to have the flash system updated to pass the emissions test for Louisiana. Ford charged me over $200 for a failure on that system from purchase, and no dealership would get back to me until I took my vehicle across town to have the system reset. Hollingsworth Ford told me that this wouldn't be covered under their system because I took this in out of warranty, but this is a problem since vehicle purchase.

- Sunshine, LA, USA

A few weeks ago, my Ford Bronco Sport (Big Bend) starting jolting when I made slow turns to the right. It has since increased the jolting/seizing with a grinding noise since it began. My car has been looked at for this issue in which Chastang Ford replaced both frontal control arms stating this was causing the jolting. However, my car continued to jolt/seize on slow right turns. I took it back to Chastang Ford, and they said the RDU fluid needs replaced along with the hose. Their labor costs were high, so I got a second opinion at FireStone. The mechanic at FireStone told me the RDU needs to be assessed and gave me information about a recall for this issue. This recall is not assigned to my vehicle, but it is believed that is the problem. Reference#: 21V011000, Ford Recall#: 21S02 It was determined by the service assistance that my car didn't come from the plant this recall was initiated for, but it's still the problem. I called Legacy Ford (who I bought the car from), and they stated they would have to replace the hose and fluid. However, this wouldn't have happened if there was enough lubricant to begin with which is what this recall is addressing. I would like this issue to be addressed by NHTSA on other Ford Bronco Sports dealing with this issue as well as Ford as it is also not covered under my extended warranty.

- Houston, TX, USA

Attempted to start car, screen behind steering wheel went black. Tried again, car went through several error messages but would not start. Gear shift and other lights flashed. Hazards did not work. No warnings prior to failure. Only after. This is the third time this has happened. The first two in busy intersections where the car stalled then went through multiple error messages. This time, thankfully, the problem occurred in my driveway. We will be towing back to matt bowers ford in the morning. Again. The previous times they ran checks, drove it and said they could not replicate the issue. Last time they put dielectric grease on the connectors. When I contacted ford I was given a case number and told I would be contacted in one business day. I was not. When I contacted ford again I was informed my case was closed and if I was concerned about the dealer-??s work I should go elsewhere. Problem is the other dealer will charge me if my dealer messed up. They are also unable to look at my car for at least three weeks. The battery has been replaced once sine I bought the car in August 2021. The rear axle has also been replaced. I have brought it in for all recalls ( multiple) and kept up with recommended maintenance.

- New Orleans , LA, USA

Previous NHTSA ID Number. 11596944. Recall fix was run earlier this month. Car died at stoplight two days ago. Fix run again at dealership. Car died at red light again today. Was able to put car in park. Tried to restart. Multiple flashing warnings. Was able to get hazards on this time. Had car towed back to dealer. They are calling Ford. Second time this happened at busy intersection. This time at interstate on ramp. Bus driver attempting to turn got out of bud and offered to push the car but we could not get it in neutral. Tow driver had towed in a bronco sport right before us with the same issue. Someone is going to be seriously injured. Service guy showed me record of previous error messages. There were about twenty. I have a video of the screens flashing today.

- New Orleans , LA, USA

First, the car was brought in 6/2/24 to take care of the open recall. I am still receiving notices but the dealership assured me the recall dealing with the battery was addressed. I came to a stop at a red light and the car shut down (all screens black). I attempted to restart. Car would not start but the radio, wipers, and screens flashing warnings intermittently came on. Could not turn on hazard lights. I had to climb out of the passenger side to avoid traffic and then attempted to direct traffic around the car. (Red light is in a curve making it difficult to see stopped vehicle.). Waited about 30 minutes for my husband. He was able to start the car and pull out of the road. We were not comfortable driving it so had it towed to dealer. Prior to the shutdown there were no warnings. The car was running well prior to this incident. It is still at the dealer. They told me battery drain, communication issues, and that they could see the error messages that flashed after the shutdown. The car was purchased in August 2021. It has 15,479 miles on it and most recently is driven 5 miles per or less during the week. I can-??t find the date but the battery has been changed once already. Had this happened on some of the other rides I drive, I would have been part of a terrible crash.

- New Orleans , LA, USA

GPS does not work reliably. Will often show the car in a completely different area than where you actually are. Often parking the car, turning the car off and letting it rest for a few minutes prior to restarting with reset the GPS. Is a hazard if you are trying to follow directions when the GPS suddenly stops working.

- Kittery, ME, USA

It has been over a month and there is no fix for the recall, this is extremely scary and dangerous as the car can lose power at any time.

- Ramona, CA, USA

While driving the vpickle, shut off on its own and came to a complete stop. No lights, working, no horns know nothing would work on this vehicle. This happened while the vehicle was in motion we are lucky we didn't die.

- Mountain Home , ID, USA

I am currently on my Third battery. Prior to getting this third car battery, there was numerous electrical issues randomly occurring. I read that there is a current investigation going on with Bronco Sports just stopping, could it be batteries failing and not being g detected?? Just wanted you to know. The first time I had dealership replace battery, they said it tested "fine" I had to insist something be done, which led them to try replacing the original battery. Since it's happened before the dealership just replaces the batteries and then stuff works normally. Can't recall dates off hand, but at home I have paperwork with dates.

- Bayport, MN, USA

[XXX] Vehicle would not start(not even crank) while parked in the garage. Could not jump start, had to be dragged out of garage(could not put in neutral) and hauled on rollback to Blaise Alexander Ford Lewisburg, Pa. Dealership kept for 4 days and charged battery and could not replicate the problem. [XXX] Vehicle while driving message of Vehicle Connection Error came up on screen and then all gauges blacked out, turned off of road and died, could not restart, could not jump start and would not crank. Again had to be drug onto rollback (could not put in neutral) and towed to Blaise Alexander Ford Lewisburg, pa, kept for 6 days and tested battery, could not charge it and replaced it at our cost. Vehicle was at 35,098miles. They could not replicate the problem. Do not feel safe driving this vehicle if it shuts down randomly at times. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Milton, PA, USA

Car stopped while driving. Couldn-??t get the car into neutral to move it out of the road. Would not crank. Leaking oil.

- Hahira, GA, USA

My 2021 Bronco failed our family on Friday. The Bronco failed to start upon pressing the start and brake pedal. The main console panel started flashing then cycling through all kinds of failure alerts. There was a series loud noises from the engine, the headlights flashed off and on for over 3 minutes and then the engine started smoking. The doors would not open and we were stuck inside while the engine was smoking. That smoke came through the air vents as well. Finally, I was able to get my door open though couldn-??t open my son-??s rear passenger side door from the outside. He was stuck inside for what seemed like forever. He was able to open it finally and I carried him inside. My son-??s legs are paralyzed and he does not walk. My main concern was getting him to a safe place as I was scared to death that the engine was going to explode in that moment. The engine smoke started to ease up however the electrical burning smell was overwhelming. This all took place in my garage. The trunk would not unlock and my key fob would not engage with the vehicle at all during this time. The trunk hatch lock finally disengaged and I was finally able to get his wheelchair out. Everything failed. I could not get the Bronco into neutral at any point. The Bronco is currently at my local Ford dealer where I was told I have to wait a week before it can even be looked at. I was told "it's just the battery...." There is NO way my experience was "just the battery." As of 10/10/2023 no one from corporate or the dealer has reached out to me. Once I got to the dealer (Jarret Gordon Ford Davenport), they were so dismissive of me. The service advisor never even asked if my son or myself were OK.

- Davenport, FL, USA

When reversing there is the absolute worst extremely loud embarrassing metallic screeching sound, considerable to a ships horn. Once you press brake fully and come to a complete stop the sounds ceases, let go of the brake it come right back. You can put it in drive and then back to reversing, same thing. Dealership was informed in 2022, said they fixed it. Spring/Summer of 2023 after complaining again was told part was ordered, could not be told what part. September 2023 was told no part was ordered, issue was fixed. October 2023 had a male take my bronco in for repairs and answers, parts are now reordered, parts are back ordered since this is a recall, no time frame on repair. When you check my vin for recalls, all recalls are closed. I am under the impression that my Dealership never has done recall work and only clearing them off as completed.

- Middleburg, FL, USA

Since dec 2021, buying vehicle, I've not had real heat, you can turn heat to 86 and above and have heat, nothing in between. Was told they needed to speak to engineer to fix problem. I took it back in needing heat again, and was told if I only use automatic and set temperature, I could have a temporary solution for zero heat and they would find a more permanent solution. My vehicle is almost 2 years old and i still have not had an engineer diagnose and fix my heat. I've been told by dealership that temporary fix should be sufficient or to sell my bronco.

- Middleburg, FL, USA

When trying to start the vehicle, it would not crank. Instead, all dash indicator lights, interior lights, and exterior lights began flashing. Numerous random error messages began flashing on the dashboard screen. Then a large plume of smoke began coming out from under the hood and there was an acrid burning smell. No flames were visible so the fire department would not respond when called and advised to have it towed. After much difficulty loading onto a tow truck (the parking brake would not disengage--dash indicated a parking brake fault as one of the many errors--so it had to be dragged onto the flatbed tow truck) the vehicle was towed to the local dealership in Dothan, AL. Per the dealership, there was an underhood fire involving the starter and battery. We are unable to inspect the damaged components. They stated they are unable to remedy the smoke smell that has permeated the vehicle despite the disabling lung conditions of one of our family members. We have tried numerous times over the last 9 months to get the dealership to perform service required by NHTSA Recall # 22V859, but they keep stating the parts are unavailable. They will not say whether this underhood fire is directly related to the recall already in effect.

- Webb, AL, USA

Vehicle shut down completely with no power, while driving. No alerts on dash that there was a problem with the vehicle. The 911 safety feature did not work. The hazards would not work. This was a dangerous, unsafe situation to be in. We received a health alert from the Ford app that evening regarding a CSP for high-pressure fuel injectors.

- North Myrtle Beach , SC, USA

Beginning at approximately 25,000 miles the vehicle started exhibiting stuttering at low speeds (<10 mph) while turning. this happened in both forward and reverse and turning either direction. I originally reported it as possible CV joint issue. Dealer informed me it was a known issue and drained and replaced the RDU fluid. Issue went away but resurfaced around the 50,000 mile mark. same results that the issue went away. Issue came once again at ~ 75,000 miles at which point I was informed that it was no longer covered by warranty. I paid to have same "fix" done, however the issue did not go away. Ford has stated that they will not cover cost of repair even though this is an existing issue identified under warranty and not corrected. Issue currently has a NHTSA communication (10187981)

- North Windham, CT, USA

My husband was driving down a mountain highway when suddenly he heard a loud noise. He pulled over and found the moonroof glass had shattered. There were no cars around and no signs that something had hit it-?"we think it was glass failure due to a pressure change. Ford has had issues with moonroof glass spontaneously shattering on other vehicles and there are a few reports online about it happening to other Bronco Sports. Ford will not take responsibility and says we need to file an insurance claim. This is a major safety issue-?"my husband could have been seriously injured if the moonroof cover had been open and glass had fell on him.

- Parker, CO, USA

Second complaint regarding the vehicle - the vehicle is making similar "knocking" sounds reported in the previous complaint which I fear may result in engine failure (again). Submitted report 06/24/2023 regarding previous issues with the engine making knocking sounds and seizing at high RPMs (specifically going uphill at highway speed).

- Richland, WA, USA

While traveling up a steep highway grade my car engine started to make violent knocking sounds before seizing and coming to a stop. I was lucky I was able to "man-handle" the vehicle off to the side of the road before anyone could hit me from behind.

- Richland, WA, USA