1994 Ford Econoline
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1994 Econoline are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #DOR-X8B9R-11
This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Read More »
-
TSB #99141
COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT Read More »
-
TSB #9997
SOME VEHICLES MAY EXHIBIT A "SQUEAKING" OR "MOANING" NOISE FROM THE STEERING COLUMN WHILE TURNING. *TT Read More »
-
TSB #00510
CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO CREATE AN OPTICAL ILLUSION OF DOGTRACKING, A CONDITION WHICH THE REAR AXLE IS NOT SQUARE TO THE CHASSIS. Read More »
-
TSB #6417
ADDRESSING TIRE BALANCE HINTS. *TT Read More »
-
TSB #985153
SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT Read More »
-
TSB #12070
VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS Read More »
-
TSB #12123
VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS Read More »
-
TSB #985102
SOME VEHICLES THAT ARE LOADED TO THE UPPER END OF GVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *TT Read More »
-
TSB #99141
SUBJECT REGARDING A HIGH NUMBER OF BALL JOINTS BEING REPLACED AS THE RESULT OF ROUTINE INSPECTIONS OR OF COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT Read More »
-
TSB #95206
UPPER BALL JOINTS MAY HAVE EARLY WEAR ON SOME VEHICLES. THIS MAY BE DUE TO ENTRY OF MOISTURE AND CONTAMINATION INTO THE BALL JOINTS. Read More »
-
TSB #942610
VEHICLES MAY EXHIBIT MORE BODY ROLL DUE TO REDUCTION IN THE AMOUNT OF LEAF SPRINGS IN THE ASSEMBLY. *TW Read More »
-
TSB #99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »
-
TSB #985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »
-
TSB #96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW Read More »
-
TSB #95315
NEW DIAGNOSTIC PROCEDURE FOR BRAKES PULLING OR DRIFTING. *TW Read More »
-
TSB #BC4074950103
BRAKE SHUDDER. *TW Read More »
-
TSB #985A13
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC Read More »
-
TSB #985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »
-
TSB #9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »
-
TSB #985A51
ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT Read More »
-
TSB #BC0106960102
ECONOLINE W/ 4WABS MAY BE EXPERIENCING FALSE ABS CODES WHICH WILL ACTIVATE THE ABS LIGHT. IF AN ECONOLINE HAS ALL OF THE CODES IN MEMORY: B1342, C1222, C1115, & C1226, DO NOT REPLACE THE MODULE, CLEAR CODES. Read More »
-
TSB #95212
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
-
TSB #96721
CONCERNS WITH THE ANTI-LOCK BRAKE SYSTEM (ABS) LAMP REMAINING ON AFTER THE VEHICLE IS STARTED AND SIX (6) ABS CODES ARE STORED IN MEMORY ON SOME VEHICLES. *TT Read More »
-
TSB #9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »
-
TSB #032124
A HARD START OR NO START CONDITION IN EXTREME COLD WEATHER. *TT Read More »
-
TSB #010198
SOME VEHICLES MAY DEVELOP "CAVITATION" EROSION IN THE CYLINDER WALL OF THE ENGINE. *TT Read More »
-
TSB #95522
ACCESSORY DRIVE BELTS - ALL 7.3 IDI DIESELS COME OFF ACCESSORY DRIVE PULLEYS - VEHICLES BUILT AFTER 2/15/92. *TW Read More »
-
TSB #BC3103950301
IMPROVED PARTS FOR SERVICE OF DRIVE BELT TRACKING. *TW Read More »
-
TSB #95522
SOME DIESEL POWERED VEHICLES ARE EXPERIENCING DRIVE BELT TRACKING CONCERNS DUE TO FRONT END ACCESSORY DRIVE PULLEYS (FEAD) MISALIGNMENT. *TW Read More »
-
TSB #9568
REVISED OIL PAN GASKET. *TW Read More »
-
TSB #95617
EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES. *TW Read More »
-
TSB #9568
UNKNOWN Read More »
-
TSB #95310
NEW TORQUE-TO-YIELD CYLINDER HEAD BOLT KIT. *TW Read More »
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #9588
KNOCKING NOISE ON INITIAL START-UP. *TW Read More »
-
TSB #95514
REVISED OIL FILL PROCEDURES. *TW Read More »
-
TSB #9568
UNKNOWN Read More »
-
TSB #BC0080950103
NO START AND OIL RESERVOIR EMPTY. *TW Read More »
-
TSB #95210
ENGINE HESITATION/SURGE DURING LIGHT ACCELERATION. *TW Read More »
-
TSB #BC0331941204
ROUGH IDLE AFTER HIGH SPEED OPERATION. *TW Read More »
-
TSB #95712
DURING HIGHWAY DECELERATION OR ENGINE START-UP, THERE MAY BE A HOOTING NOISE COMING FROM THE ENGINE COMPARTMENT. *TW Read More »
-
TSB #9748
ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD Read More »
-
TSB #16945
AN OIL LEAK AT THE TURBOCHARGER PEDESTAL AROUND THE EXHAUST BACKPRESSURE ACTUATOR. *TT Read More »
-
TSB #9777
HARD START- EXTREME COLD AMBIENT TEMPERATURE- VEHICLES WITH 7.3L DIESEL ENGINE. *JD Read More »
-
TSB #9568
UNKNOWN Read More »
-
TSB #9524
NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION. *TW Read More »
-
TSB #982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »
-
TSB #9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
-
TSB #BC0883961004
VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT Read More »
-
TSB #95316
LOW PERFORMANCE/LACK OF POWER. *TW Read More »
-
TSB #9568
UNKNOWN Read More »
-
TSB #96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »
-
TSB #17467
ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT Read More »
-
TSB #96728
SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT Read More »
-
TSB #99236
SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT Read More »
-
TSB #BC0678961025
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT Read More »
-
TSB #98167
TRANSMISSION-E40D-NO 2-3 UPSHIFT. SOME VEHICLES MAY EXHIBIT A NO 2-3 UPSHIFT CONDITION. *AK Read More »
-
TSB #98168
TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD Read More »
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #9996
EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #98123
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT Read More »
-
TSB #97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »
-
TSB #BC0820961010
REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. Read More »
-
TSB #951112
REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW Read More »
-
TSB #95619
NEW DESIGN TRANSMISSION RANGE SENSOR. *TW Read More »
-
TSB #9568
UNKNOWN Read More »
-
TSB #95313
POSSIBLE WATER INTRUSION IN THE MLP/TR SENSOR CAUSING SHIFT CONCERN. *TW Read More »
-
TSB #95212
VEHICLES MAY EXHIBIT A SHIFT CONCERN. *TW Read More »
-
TSB #94269
DELAYED OR NO FORWARD ENGAGEMENT OF TRANSMISSION. *TW Read More »
-
TSB #942318
TRANSMISSION OVERHEATING, CONVERTER COVER DISCOLORATION, CLUTCHES BURNED AND BURNT FLUID *TW Read More »
-
TSB #942415
UPGRADE KIT FOR THE E40D TRANSMISSION. *TW Read More »
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #002310
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Read More »
-
TSB #0038
VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. Read More »
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
-
TSB #16480
DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT Read More »
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
-
TSB #BC0531941201
ECONOLINE CONVERSIONS BY TIARA MAY EXPERIENCE A DISCHARGED BATTERY AFTER PROLONGED STORAGE. *TW Read More »
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
-
TSB #96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Read More »
-
TSB #99164
CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT Read More »
-
TSB #ONP/94B56
CORROSION BETWEEN THE TAMPER SENSOR AND THE IGNITION SWITCH CASTING MAY CAUSE FALSE ACTIVATION OF THE ANTI-THEFT ALARM SYSTEM. *TW Read More »
-
TSB #9859
A HARD TO TURN IGNITION KEY, AND/OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER MAY OCCUR ON SOME VEHICLES. *YC Read More »
-
TSB #962511
POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #BC0502941201
HARSH REVERSE ENGAGEMENT CONCERNS. *TW Read More »
-
TSB #99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »
-
TSB #96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW Read More »
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
-
TSB #970503527
CONCERNS WITH SERVICE MANUAL NOT HAVING AIR BAG SYSTEM DIAGNOSTICS. Read More »
-
TSB #9747
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD Read More »
-
TSB #00610
INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS Read More »
-
TSB #942611
HOOTING NOISE FROM THE ENGINE COMPARTMENT. *TW Read More »
-
TSB #12835
SUBJECT REGARDING TIRE BALANCE HINT. *TT Read More »
-
TSB #9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #96226
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW Read More »
-
TSB #5892
SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT Read More »
-
TSB #98419
SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »