6.5
fairly significant- Typical Repair Cost:
- $450
- Average Mileage:
- 79,300 miles
- Total Complaints:
- 622 complaints
Most common solutions:
- Ford should pay for it (396 reports)
- not sure (86 reports)
- paid to have rear panel replaced (48 reports)
- file complaint with NHTSA to get a recall issued (26 reports)
- start a class action suit and get damages reimbursed (17 reports)
- dealership replaced the entire panel (10 reports)
This problem may be covered under warranty. Ask your Ford dealer.
« Read the previous 20 complaints
Plastic piece below the window broke when the rear window fell due to the struts not holding. Approx. (2) weeks later I received a recall notice (#04V442000) from Ford that stated (Due to the risk of injury from the rear window falling Ford has issued a recall to have the rear window struts replace ASAP.) Upon arrival at the dealership to leave my vehicle, I showed the service writer the broken plastic piece and explained what had happened. He told me that it was not covered under the recall and that I should contact ford and if enough people complained that maybe ford would issue a recall on the plastic part. Didn't work!!!!! Contact ford again and filed a complaint and they had me get a written estimate and then call them back. Did that and when I called them back they told me that there was absolutely nothing that Ford could do about it, that I should just bite the bullet and pay to have it fixed. With that answer I guess that their customer service is one part of the problem with FORDS FINANCIAL PROBLEMS!!!!!!
And this horse ain't dead yet...... I'm not satisfied with their answer.
- flyboy75, Charlotte, NC, US
Rear body panel below window cracked spontainiously. Because of the age of the vehicle I would be happy if Ford would share the repair cost, but this appears to be a common (defect) problem. Awaiting decision from Ford Canada, seem receptive, will see.
- Glen W., Toronto, ON, Canada
I live in Arizona and thought that maybe the heat had something to do with the crack. However, my parents have the same make and model explorer as we do and theirs cracked also. We know of at least 5 other people with 02 explorers and they all have the same cracking. It seems to me that this is a ford issue and not just the hot weather hear as I had thought. I'm not sure what it takes to get a recall but this should definately be recalled.
- tjpip70, Surprise, AZ, US
in September 2007 A 2" crack formed on the Right side of the painted rear hatch panel on the back of our 2002 Explorer. In December the crack spread all the way down the panel and now there is a 5" crack in the back panel. I have not even been to the dealership, but plan to give it a go soon. We also had to replace the 3rd gear band at 30,000 miles conveniently after the warranty was up.
- Todd S., Edmond, OK, US
Same problem as stated in the other blogs. How much ranting should be done before Ford will take the blame for the defect? Does anyone know of any good shops to fix the problem in the Tennessee area?
- rt, Memphis, TN, US
I can't believe that this is still not a recall item. American auto builders complain about American consumer support but allows this to go on for years without follow up. I travel a lot and I have seen so many Explorers with the same defect.
- Ernest J., Danville, Va, US
We bought it used in great condition. It was a leases vehicle and had 26000 miles on it. We came out one morning and there it was ... a big crack. We took it to a friend of ours who owns a body shop who told us that it looked like a factory defect and that we should take to the dealer. We asked it how much to fix and we were told that to do it right he would have to replace the entire panel. We haven't taken it to the dealer yet. But I will today after finding out we aren't the only ones.
- Ellen W., Indianapolis, IN, US
Please add me to the list of complainants. For a couple of years now, my 2002 Explorer XLT has had two 5" cracks in the panel approximately under each window hinge. Today I noticed a new one directly above the Ford emblem. I happened to be driving by a Ford dealership and pulled in to see what they had to say. No surprise that they told me trim is not covered under warranty even though I bought the extended 6 yr/60,000 mile warranty. I told them I would take it up with the factory and he bid me farewell. This is my third Explorer in 10 years and has been by far the worst. It looks like it's finally time to move on.
- Mike R., Lubbock, TX, US
Crack is very noticable and will diminish the resale value. I possibly have an attorney in Texas that is willing to take on Ford in a class action to get the panels replaced. If anyone is interested in joining, contact me at glmoseley@hotmail.com and be sure to put "Ford Explorer problem" in the subject line so I can distinguish it from other mail.
- Gail M., Ben Wheeler, TX, US
This is a problem that is inbred with the manufacturing of the car. There is nothing behind this panel, of which when the car is frozen and you open the half window; upon closing the have window/door, this panel will crack and will continue to crack with the changing of the weather from heat to cold weather. I believe Ford is shirking their responsibility and liability. I've been a Ford owner for over 25 years. Not anymore, I'm buying a Lexus or BMW SUV in a couple of months. I'm finished with Ford and their irresponsibility when it comes to customer service. From the articles I'm reading in the Wall Street Journal, I'm not the only one fed up with Ford.
- Larry M., Raytown, MO, US
I noticed two small cracks a few days ago and just now i noticed about a 7 inch crack appeared! I's plastic and i was wondering I can get the part replaced but I can't seem to find it online. I am worried about the rear window falling out as well! Not sure what to do..........:-(
- Elizabeth G., Freeport, Grand Bahama, Bahamas
Mine cracked in December. Very mild winter here in CT. This should be a recall due to the number of complaints.
- Dan F., Shelton, CT, US
Bought vehicle in 2002, panel cracked in 2003 and was replaced under warranty. In 2006 clear coat on panel was flaking so panel was removed and repainted, under warranty. Last weekend panel cracked "again" right by emblem. Weather was colder than normal overnight but dealer said that would not cause it. Dealer said since it was out of warranty it was not covered. Dealer said cost was between $300 and $400 dollars and if I would pay $75.00 they would pay some and have Ford pay some. Not the best solution but better than nothing.
- earlsflyin, Daytona Beach, FL, US
I took the truck in to a Ford dealer so it can be repaired. They knew about it happening, the manager even showed me another explorer that was on their lot with the same problem. It is costing me 300.00 but I want it fixed. I hope Ford reimburses me after they start recalling it when they fess up to the problem. The part actually cost 90.00, the other cost are for labor, paint, etc.
- Landis J., Houston, Yexas, US
I noticed the crack while up in Lake Tahoe so figure it may be caused by the cold weather. I have seen two other Ford Explorers in the last week with the same crack and spoke to one of the owners. He said his also happened in the very cold weather and he never reported it as he figured it would not be covered due to the age of the car. My car is with Ford right now for evaluation, I'm hoping they will pay for it but I don't know yet. I know of one person who has had it paid for but it was right after she bought it used from the dealership.
- sunbum, Livermore, CA, US
This cracked panel thing just happened to my Explorer February 17, 2007. I was not sure how it happened but assumed it just snapped down the middle. With so many complaints on the matter Ford should replace it with a more durable material(sheet metal maybe)because this is going to keep happening to our vehicles. I did notice that the 2006/2007 models were redesigned in that area(a sign that they know this is a problem). I really love this vehicle but this cheap part is sending me running to Chevy for the Tahoe or Dodge for the Durango, some on Ford make me love you again by taking care of this immediately. I'm going to the dealers tomorrow to see what they'll tell me, the results will be posted soon after the visit.
- Landis J., Houston, Yexas, US
I'm a long time Ford owner but have to rethink after the run around I got. Rear window panel cracked for no apparent reason. Called the dealer and they said there was nothing they could do. They said if it had been cracked before the last recall(window supports) they could have sneaked it in. Ford must have really tightened the screws on the dealers for warranty work as I purchase all vehicles for our fleet of autos.(85% Fords) If my dealer would have been able to make an exception, I would have got it. To everyone else reporting, this is a very common problem. There are three 2002 Explorers in our parking lot of 90 employees and all 3 have the same crack in the rear panel.
- Chuck A., Wausau, WI, US
I just moved to Murphy, NC from Palm Harbor, FL and the infamous Ford "Butt Crack" appeared the other day (Feb 14, 2007). I attribute the butt crack to freezing weather, which I didn't experience in FL. It's probably caused by constant contraction and expansion but I'm just guessing. Along with compiling a list of VIN numbers we should compile a list of geographic areas.
I bought my Explorer new and it's been a pretty good SUV. I've always liked the Explorer and this is my 2nd. Saying I wouldn't buy another Explorer because of the butt crack is probably not true. I am baffled as to why Ford won't belly up to the bar and pay for this. It would be the honorable thing to do.
Based on the number of posts at this web site, projecting this number out, I would suspect there are 1000's of Explorers perhaps 10's of 1000's with this butt crack. I'm waiting for someone to come up with a decal of a butt crack. :-)
I did have transmission problems right after the original warranty expired BUT I had an extended warranty and the transmission work was covered ($5000!!). The transmission problem was also a common problem. I understand the Sport Trac transmission is Ok. So, why not use that transmission in the Explorer?? I suppose I'm too logical.
For now I'll have to seal my butt crack with epoxy to keep the water out. Won't that look lovely!?
- carnegieron, Murphy, NC, US
Do you know I thought someone hit me in the grocery store parking lot? There was no other damage so it didn't make sense. This really does suck. What if water gets in this crack and causes electrical problems? Has anyone thought of that? The rear window is electric. I am not paying for something that is not a result of something I have done. Clearly, this is a problem and Ford needs to recall it. I have never had a problem with any of my other Fords. I have been a die-hard Ford driver since I was 17. I think if Ford wants to be like this.. my next car will be a Honda. Thanks a lot Ford Family.
- Meridth D., Fruitland, MD, US
I closed the rear window and started the car. The door ajar light was on so I got out to check the rear window at which time I found it had cracked in half. The temperatures had been very cold for a week - under 15 degrees.
I had an estimate at a body shop and was told it was a known problem that Ford should take care of.
I called the dealer who said it was a known problem with Ford and they gave me an 800 number.
I called the 800 number and was on hold for 45 minutes. The operator was rude and kept asking what I expected Ford to do about it. I told her I wanted Ford to fix it at no cost.
I was surprised to do a search this morning and see so many people with the same problem. There was another Explorer in front of me in traffic yesterday with the same problem.
On a side note, the front passenger door lock no longer works.
- R G., Griffith, IN, US