There is a crack (1/2" in length) that has developed on the outer sheetmetal of the drivers door on the lower left hand corner near the L shaped weatherstripping. This crack is growing weekly and structural integrity in an accident is my major concern as the crack can act as a "crumple" joint. Cosmetically it is also likely to begin to rust if not corrected as the paint is beginning to peel around the crack.

- Los Angeles, CA, USA

Door sheet metal cracking around window. Unknown affect to integrity of door.

- Jamestown, CA, USA

As stated, the door is cracking at the rear of the driver's side window approximately 1/4 of the way up from the bottom of the window. I have personally seen numerous F150 vehicles with the same type of crack. I believe this to be a safety issue because of the compromise of the structural integrity of the vehicle at normal speed as well as during a crash.

- San Diego, CA, USA

Cracks appearing in door

- Tacoma, WA, USA

This is my second truck (frist one was 1997 w/two cracked doors which dealer bought back) with this problem. The sheet metal on doors crack at the at the window trim do to stress created when raising and lowering window. Ford won't admit problem

- Auburn Hills, MI, USA

Driver's side door and passager's side doors have cracks within the frame and panel. Both door's are rusting at the bottom when driving at 25 mph on wet pavement. Also, when applying brakes rear brake's will lock up.

- Eccles, WV, USA

When driving 50 to 60mph the vehicle makes excessive wind noise around the door and cab area. Dealer says it's normal.

- San Jose, CA, USA

Doors do not shut properly consumer must slam doors.

- King, NC, USA

Steering pulls.

- Ladson, SC, USA

Car would shake at 45 mph, causing tires to go out of round.

- Ladson, SC, USA

Steering shaft failure. Also, power door locks failed/ABS brakes malfunctioned, causing brakes to vibrate upon braking.

- Ladson, SC, USA