10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
92,001 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2005 Ford F-150:

Unsubscribe any time. We don't sell/share your email.

« Read the previous 20 complaints

problem #5

Apr 272013

F-150 8-cyl

  • 161,000 miles
While driving at posted speed limit the engine quit running, as if the key had been turned off. This stopped all control of the power steering and hydraulic brake control. Traffic behind me was forced to stop quickly and avoid me. While trying to pull over I almost went into the ditch because of lack of steering control. When I took the vehicle to the Ford dealer the service mgr said this was a common problem where the fuel pump driver module corrodes and causes problems but that there was no recall on it. If I had not been an experienced driver this could have caused a horrible accident.

- Bryan, OH, USA

Add Complaint
problem #4

Feb 162013

F-150

  • 69,950 miles
The contact owns a 2005 Ford F-150. The contact stated while driving approximately 10 mph, the vehicle stalled and the check engine warning light illuminated. The contact inspected the vehicle and noticed the fuel pump driver module was corroded. The contact replaced the fuel pump driver module. The vehicle was not taken to the dealer for diagnostic testing. The manufacturer was made aware of the failure. The vehicle was repaired. The approximate failure and current mileage was 69,950.

- Tarentum, PA, USA

Add Complaint
problem #3

Jan 022006

F-150

  • 20,000 miles
The coil packs and plugs have been changed on different times and the vehicle still has the same problems. Ford has to find a better solution to fix these ongoing issues so the customer does not have to keep paying all this money for the same problems over and over again. Engine lost power on several occasions and shakes when idling. Paint on front of vehicle started peeling off. All service work has been conducted a T a Ford dealership since the vehicle was purchased except for today with (2) more coil packs had to be installed at a local garage. This is apparently a big problem and something has to be done about it or Ford will find good customers going to other vehicle brands.

- Saxe, VA, USA

Add Complaint
problem #2

Jan 032013

F-150 6-cyl

  • 95,000 miles
Would not start broke down had to tow rusted fuel pump module.

- New Middletown , OH, USA

Add Complaint
problem #1

Nov 132012

F-150

  • 62,000 miles
My fuel control module shorted out which caused my PCM to be erased. It seems to be a common problem after researching it, but no recall has been issued. My pregnant wife was driving my truck and lost all power. This resulted in a near accident due to having no power steering and less brake control. If this is such a common problem with the placement of the control module why has this not been recalled. $1000 later I hope this doesn't happen again.

- North Chili, NY, USA

Add Complaint