The contact owns a 2014 Ford F-150. The contact stated while driving 65 mph, the vehicle loss motive power without warning. The vehicle was towed to an independent mechanic where it was diagnosed with needing the fuse box to be relocated. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 69,000. The VIN was not available.

- Coward, SC, USA

There's a known problem with fuse #27 overheating and causing the fuel pump to stop working. Do a google search. It affects many years prior to 2014. This is serious as it can leave people stranded. It has not thrown a computer code from 2014 F15. Simply replacing the fuse did allow starting but it will happen again. There's a fuse relocation kit (el3Z-14293A) available but Ford should be responsible for performing this repair. The fuse does'nt blow out but the fuse socket overheats for some reason.

- Hibbing, MN, USA

Ford has obviously machined manifolds for the F-150 that are less than reliable and lack in quality. The exhaust manifolds are not hardened to endure engine heat and end up warping. This causes exhaust bolts to break, exhaust gaskets to be destroyed and in turn causes loud noises and potential damage to the motor on their F-150 trucks. Ford obviously knows that they have a problem on their hands as they are currently dealing with 1,700+ vehicles that are sitting in service shops across the country for this very reason. I called Ford to find out what was causing the issue and they explained that the materials just aren't holding up to driving conditions. Ford is working redesigning the manifolds and releasing them for purchase. However, it you have an issue this large and have admitted that it is due to your own failure to produce a product/part that will endure normal driving conditions, this should be recalled and fixed by Ford. Personally, I don't drive this truck very often. It is stored inside and taken care of to the extreme. The vehicle had been parked in a garage for a few days to a week (approximately) and when I started the truck I heard a loud "clicking" noise. I took it out for a drive to see if I could locate the noise. At first is was just a fast clicking noise on acceleration. This became a loud clicking mixed with a whistling noise. Thinking it was a bearing in one of the turbos, I took it in for inspection and they found the broken exhaust stud and damaged exhaust gasket. While working on fixing the issues, they found that all of this resulted from the deformed manifold.

- Fort Collins, CO, USA

The contact owns a 2014 Ford F-150. The contact stated that the vehicle was leaking an unknown fluid. The vehicle was taken to North central Ford (1819 N central expy, richardson, tx 75080, (972) 584-1338) and was diagnosed that the vehicle was leaking coolant from the lower degas hose and the connector. The vehicle was not repaired. The contact called an independent mechanic who stated that the failure was a common issue. The manufacturer was contacted but no further assistance was provided. The failure mileage was 32,000.

- Wyllie, TX, USA

Traveling down a two-lane road about 50 mph when the truck's engine suddenly lost all power and an error message popped up on the screen. Had to stop in the middle of the road blocking traffic due to no shoulder. Had to put truck in park, turn off motor and only then was able to get motor running again. Managed to get 1/4 mile back home. Found out from my obd diagnostics that the throttle body was stuck. Only option was to replace the throttle body to ensure it didn't occur in the middle of the road or worse, a major intersection. No problems since replacement.

- Tallahassee, FL, USA

The contact owns a 2014 Ford F-150. The contact stated that while driving at low speeds and entering traffic with the accelerator pedal depressed, the vehicle stalled. The vehicle was restarted. The contact stated that the steering wheel locked up and was difficult to turn. The contact coasted to the side of the roadway. The service engine warning light was illuminated. The vehcile was taken to mac haik Ford (4506 N. navarro St, victoria, tx 77904 (888) 253-4662) and was diagnosed. The low voltage message was displayed. The 20 amp fuse box was melted. A fuse relay kit was needed. The vehicle was repaired. The contact's husband attempted to replace the 20 amp fuse however, the fuse failed to fit correctly. The manufacturer was made aware of the failure. The failure mileage was 106,305. The consumer stated repairs were made by mac haik and paid for most of the repairs and Ford paid for a portion.

- Vanderbilt, TX, USA

The contact owns a 2014 Ford F-150. The contact stated that her husband was driving 70 mph, when the vehicle loss motive power and stalled without warning. The driver coasted the vehicle to shoulder and waited for approximately 10 minutes for the vehicle to resume normal operation. The vehicle was taken to an independent mechanic who diagnosed the vehicle but was unable to duplicate the failure. The vehicle was not repaired. The failure recurred several times. An independent mechanic diagnosed the vehicle 3 times but was unable to retrieve any fault codes. A dealer was not contacted. The manufacturer was made aware of the failure however, informed the contact that the VIN was not subjected to a recall. The failure mileage was approximately 150,000.

- Newygo, MI, USA

I recently financed a truck and the seller did not disclose that it was a flood damage vehicle. I did auto check and found out there was also recalls on the truck when he sold it to me. That he didn't fix recalls are for the seatbelts N the bolts for the seabelts. The truck also is leaking oil. He also tempered with the engine lights because it's leaking oil but no lights turned on. I want a full refund of every dollar I have given him. He also lied on the odometer.

- Little Elm, TX, USA

While driving on a country road, the truck lost all power and service wrench came on. I pulled to side of a 2 lane rd and coasted to a stop. Turned the cr off and on again and code was gone. I drove for about 4 minutes and the truck lost power again. This repeated about 4 times as I was in a mountain area with no cell service. I had to to keep trying to coast as far as I could to find service. Finally after about an hour of stalling on the side of the road, I was able to get cell service and contact help. At 1am we got a tow to the dealer that just repaired the vehicle. They said the problem was unrelated to the service just performed and we had a bad throttle body. The item was replaced.

- Amsterdam, NY, USA

When trying to accelerate in my truck on the highway, I had a jerking motion with reduction in speed. The check engine light came on so I took it into a Ford dealership. They said the code P0016 represents a tsb out on ecoboost engines for timing chain stretched. The cost for me to fix is $4100. Thi

- White Pigeon, MI, USA

Vehicle would lose all ability to accelerate or use any type of throttle control while driving on highway. Had to continually drift to a shoulder on the highway to turn off vehicle because the throttle body went bad. Extremely dangerous, vehicle became inoperable and unsafe to be on any roadway.

- Ellicott City, MD, USA

While driving at highway speed 65 to 75 the truck just shuts down, stops running this is the 4th time in 5 years this has happened to us almost had a major rear end mishap as a semi was on us going up a bridge in heavy traffic, a wrench showed up on dash display truck started but died 3 more times at road speed in 20 miles.

- Brownsville, TX, USA

Motor has begun to make a load clanking sound when starting. I have been informed it is the timing chain

- League City, TX, USA

As I was accelerating the truck stopped accelerating and idles rough. Wrench light on the dash came on. Fortunately was able to get the side of the road with out causing an accident. Came to a stop, put it in park, truck still idleing but roughly. Pressed down on accelerator and nothing happened. Engine didnt rev up at all. Turned the engine off. Restarted and then everything was fine. Wrench light on the dash even went out.

- Alpena, MI, USA

The contact owns a 2014 Ford F-150. The contact stated that while driving at 55 mph, the vehicle stalled and loss motive power with several warning lights illuminated. The contact was able to maneuver the vehicle to the shoulder of the roadway. After inspecting the vehicle, the contact became aware of a puddle of oil on the ground underneath the vehicle. The contact was unable to restart the vehicle. The vehicle was towed to the residence and then to an independent mechanic to be diagnosed. The contact was informed that the engine and transmission needed to be replaced. The repair was still pending. A dealer was not contacted or informed of the failure. The manufacturer was contacted and informed of the failure. The approximate failure mileage was 126,000.

- Fulton, NY, USA

I drove my F-150 eccoboost truck to the snow, same area I have been hundreds of times and suddenly smoke burst from the engine, then flames shot out around the hood, popped the hood and fought the fire for half an hour, it kept restating. It stranded myself and children, and we had a harrowing experience that was pretty dicey. Ford had just put in a new engine, at my cost, +14,000.00, after the timing chain failed. They would not repair it at their cost, even though I have copies of the fault codes from before the failure of the timing chain that destroyed the old engine. The new one had under 10,000 miles on the new engine, probably about 5,000 miles on it. We had driven on the relatively flat grade mainline road, and drove up about 0.8 miles, climbing maybe 400 ft elevation over that distance. I was in the process of turning the vehicle around when the engine burst into flames. It was on a gravel road. We had traveled from home, 35.2 miles.

- Molalla, OR, USA

Out of warranty, timing chain problems, phasers not operating correctly, Ford issued tsb: Some 2011-2014 F-150 vehicles equipped with a 3.5L gasoline turbocharged direct injection (gtdi) engine and built on or before 10/10/2014 may exhibit a malfunction indicator lamp (mil) illuminated with diagnostic trouble code (dtc) P0016. Other dtcs and driveability concerns may also be present. This concern may be due to a worn primary timing chain. Loss of power, exhaust smoking, loud rattle in engine during cold starts.

- Glendale, CA, USA

The contact owns a 2014 Ford F-150. While driving various speeds, the engine suddenly shut off. After restarting the engine, the vehicle operated normally; however, the check engine indicator remained illuminated. The vehicle was taken to an independent mechanic who diagnosed that the throttle actuator control system was faulty. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The dealer was not contacted. The failure mileage was 216,000.

- Kentwood, MI, USA

The contact owns a 2014 Ford F-150. While driving various speeds, the engine suddenly shut off. After restarting the engine, the vehicle operated normally; however, the check engine indicator remained illuminated. The vehicle was taken to an independent mechanic who diagnosed that the throttle actuator control system was faulty. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 216,000.

- Kentwood, MI, USA

While traveling on the highway we saw looked out the rearview mirror and saw white/gray smoke coming up from between the truck bed and the cab of the truck. We exited the freeway. While exiting the white/gray smoke turned to black then flames shot up. We pulled over and got out as the flames continued to grow. We attempted to put out the fire but it grew very fast. The back glass exploded and the entire cab and front of the vehicle was engulfed. 911 was called. Firefighters arrived and put out the fire. The vehicle and contents were a total loss. The fire department reports states that the fire was caused by a mechanical failure in the engine compartment or under the passenger compartment causing flames to show from the back of the vehicle and causing heavy damage to the front of the vehicle and passenger compartment.

- Spring, TX, USA