Driving about 30mph when low brake fluid light came on dashboard. When I pulled over brake pedal went to the floor and I lost all my brakes had to have brake master cylinder and vacuum pump replaced also brake fluid got into the fuel system and contaminated that

- Fort Myers, FL, USA

After entering the highway and maintaining a speed of approximately 65 mph, the brake pedal suddenly lost function and was able to be pushed all the way back with no effectiveness. No alarms or safety chimes alerted the failure. This was frightening due to our whole family being present and the speed of which we were traveling at the point of failure. We were able to safely coast onto the shoulder and be towed to the nearest dealership. The mechanics could not recreate the failure and replaced the master cylinder in hopes that this will correct the problem. I am still unsure if the vehicle has had the issue corrected permanently.

- Richmond, TX, USA

I own a 2015 F150 with the 3.5L motor and 47,000 miles. This morning the " low brake fluid " light came on then within minutes I started experiencing low/spongy brake pedal. I pull over and check the master cylinder, the fluid level was very low. I add 2 containers ( 24 fl. Oz. ) of brake fluid to refill master cylinder and drove about 3 miles when the brake malfunction light return along with low/spongy brake pedal. I called Ford roadside for a tow. There was no visible fluid leak at the master cylinder area or at the 4 wheels. However I believe that this is a major leak because that fluid did not take long to leak out ( 3 miles and about 10 minutes )

- Brentwood, MD, USA

While driving I received a warning light that my brake fluid was low. Went to stop and the pedal went to the floor. I added brake fluid and the same thing happened again, plus it started to push white smoke out of the tail pipes from the brake fluid entering the engine through the vacuum system from the power booster. There is definitely something wrong with the master cylinders in these vehicles and hope you are able to conclude your investigation into this issue and get a recall in process so that I may be reimbursed for the repair.

- Jonesborough, TN, USA

Driving down the road, the low brake fluid light came on, the first time I had to stop, I had no brakes. Pedal went down to the floor. Just missed hitting the car in front of me. There was no warning from the time the light came on and having no brakes. It was the first depression of the pedal following the light. I was on thomasville road in tallahassee at 6:30 in the morning, light traffic, four lane road, 45mph. Firestone is telling me that repairs will cost $2,500+. truck has 60,000 miles, needs new master cylinder, booster, front calipers because the left was locking up, new front rotors, new rear rotors and read pads.

- Tallahassee, FL, USA

Driving home brake light low fluid alarm comes on. Worried I go to apply the brakes and the petal goes to the floor. I am traveling eastbound on a freeway (summerlin parkway) down a hill. I start to panic a little bit. Lucky for me traffic was light and through a combination of coasting and brake I manage to slow down and get to the side of the road. I check the brake fluid reservoir and it is low. I lump the truck to the next exit and stop at O'reilly auto parts. I by a quart of brake fluid and put it into the car. Brakes are back and light goes out. I start driving home and 4 miles dow. The road the low brake light fluid light comes back on. I stop off my exit to my house and buy more brake fluid from autozone. Light goes out again and I limp the truck home. Today I had it towed to team Ford dealership to have it looked at.

- Las Vegas, NV, USA

The contact owns a 2015 Ford F-150. The contact stated that the brake pedal traveled to the floorboard when it was depressed. The vehicle was unable to be safely driven due to the failure. Ford Lincoln of franklin (615-794-4585, 1129 murfreesboro rd, franklin, tn 37064) diagnosed that the brake booster, seals, and master cylinder needed to be replaced. The vehicle was not repaired because it exceeded the three year warranty. The manufacturer was notified of the failure. The VIN was not available. The approximate failure mileage was 34,250.

- Franklin, TN, USA

The contact owns a 2015 Ford F-150. While driving, the brake fluid warning indicator illuminated. The contact coasted the vehicle over to the side of the road and filled the brake fluid reservoir. While driving 60 mph, the brake fluid warning indicator illuminated again. The vehicle was taken to rusty wallace Ford (located at 134 sharon dr, dandridge, tn 37725, (423) 623-6138) where it was diagnosed that the master cylinder and brake booster needed to be replaced. The vehicle was in the process of being repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 42,000.

- Sevierville, TN, USA

While on a road trip from the sf bay area to las vegas and having been there just one day, the valet at ceasar's palace drove my truck to the front entrance of the hotel/casino where many people and vehicles were coming and going. When I got in my truck, the brake warning/failure lights were brightly lit and the brake pedal went mushy right to the floor. When I inspected the brake fluid reservoir, it was near empty (see attached photo). When I looked beneath the vehicle, there was no indication of a leak and no indication of a leak in the engine compartment. The truck mileage was around 62K and had the 60K service recently which included new front rotors and pads installed by a Ford dealer in the sf bay area. For the brake failure, I had the truck repaired at the Ford dealer in las vegas. They reported that brake fluid leaked from the hydraulic cylinder secondary seal into the brake booster. Both the hydraulic cylinder and brake booster required replacement at a cost of nearly $1400! fortunately, I wasn't driving when the brake failure occurred. There were no accidents or injuries. Thank god.

- Cupertino, CA, USA

Master cylinder leaking into brake booster. Only warning is low brake fluid light. Known issue on 13, 14 ecoboost models. Just driving down the interstate and low brake fluid level warning came on. Pulled over and put more fluid in master cylinder. By the time we got to the end of parking lot needed fluid again. Took to Ford dealer where they said needed new master cylinder and brake booster replaced. Parts and labor over $900. This should not be a normal failure for a truck that has less than 62000 miles on it. Thankfully we did not have a more catastrophic situation.

- Knoxville, TN, USA

While driving my kids to school I was stopped at a red light when the low brake fluid light came on. The traffic light turned green and as I was driving I went to apply the brakes and the pedal went completely to the floor. I had to shift the car into neutral and use the emergency brake to assist me in stopping the vehicle. I stopped 2 feet short of crashing into a vehicle in front of me. I pulled over and opened the hood. The brake fluid reservoir was almost empty. I stopped at a near by midas and was told that there was a massive leak from the master cylinder to the brake booster (booster was completely filled with brake fluid). I have seen that there is a recall for 2013-2014 F150S that are having the same issue. I can assure you that this problem is affecting the 2015S also. There was no warning other than the light coming on and I immediately lost almost complete braking power to the vehicle. This is a serious concern and a frightening one as it happens with children inside the vehicle.

- Miami, FL, USA

Sudden brake failure after a brake fluid low level caution. This happened after approximately 5 minutes while on the highway at 65 mph. Luckily I didn't crash into anything and was able to stop with remaining brake pressure. The dealership said it was caused by a failed master brake cylinder and caused the brake pump to fail. Total repair cist $975. This is totally unacceptable on this vehicle. Luckily I didn't crash.

- Hanford, CA, USA

The contact owns a 2015 Ford F-150. While the vehicle was in reverse, the brakes failed when depressed and the low brake fluid warning indicator illuminated. The vehicle was towed to alan jay Ford Lincoln (3201 us hwy 27 S, sebring, fl 33870, (863) 385-0144) where it was diagnosed that the master cylinder and booster needed to be repaired. The vehicle was repaired on March 20, 2019. The manufacturer was not made aware of the failure. The failure mileage was 102,000.

- Union Mills, IN, USA

The contact owns a 2015 Ford F-150. The contact stated that the brakes malfunctioned and traveled to the floorboard when the brake pedal was depressed. The contact had to use the emergency brake to stop the vehicle. The vehicle was at the contact's home when the failure occurred. Alan jay Ford Lincoln (3201 us hwy 27 S, sebring, fl 33870, (863) 385-0144) diagnosed that the master cylinder was leaking fluid into the brake booster. Both the master cylinder and brake booster were replaced. The manufacturer was not contacted. The failure mileage was 47,016.

- Maquoketa, IA, USA

I was on the highway and the hill start assist/traction control lights started coming on. A few hundred miles later, more dash lights started flashing and then all dash lights went off and the truck lost all power. I could no longer accelerate. After a moment, it started working again. After a few more miles, it did it again, and this time when it powered down, the ABS break system went on and created a terrible grinding noise and brought me to a stop on the side of the highway. I limped it on the side of the highway, trying to find an exit, and the truck repeatedly did the lights flashing/power down/breaks applied several more times at low speed. The nearest exit was about 10 miles, so I had to continue to do this for some time. Once I was at an exit, I disconnected the battery for about 20 minutes. When I re-connected the battery and started the truck, everything seemed fine, but now the check engine light was on. I decided to just risk it and keep driving, so that I could get home. About 100 miles later it started doing the same thing again. I was close enough to home to get off the highway and take back roads home. It did it a few more times and then quit doing it. This was a very dangerous situation, as my truck basically stopped while I was on the highway going 70 mph, and could have caused a serious accident, and left me no option but to either be broken down on the side of the highway or drive at very low speeds on the shoulder. The Ford dealer that I took the truck to told me that they can't replicate the issue and all diagnostics come back clean, so they are not able to fix anything. Others online that have had the same/similar issue have said that Ford said that it is a damaged throttle body that needs to be replaced, but the dealership that I went to did not suggest that as the cause.

- Norton, OH, USA

While driving on the highway, the vehicle suddenly lost all ability to brake. The foot pedal went down to the floor with no resistance or action on the vehicle. The parking brake also failed all ability to slow down or stop the vehicle. By some miracle I was able to get in the emergency lane and let the vehicle eventually slow down and come to a stop. The sudden loss of brakes happened while I was driving on a straight highway, with no obstacles of any type on the road and no evidence of damage to the vehicle. I have a video taken while waiting on the tow truck, showing the brake pedal going straight to the floor.

- Coral Springs, FL, USA

Catastrophic / complete brake failure will moving. Brake peddle went to floor while exiting highway. Seconds before applying brakes, "low brake fluid" warning came on. Thankfully it was a long exit ramp and was able to stop vehicle with down shifting and emergency brake. Very dangerous!!!!!! no prior indication of problem. Inspected fluid and it was below minimum. Vehicle had be serviced 2 weeks prior and all fluids full. Added fluid and pumping brakes several time, fluid was empty again. Had vehicle towed to dealer.

- Northfield, OH, USA

While driving straight on freeway at 75 mph, "brake fluid low" warning came on dashboard followed by complete loss of braking abilities. Road conditions allowed time for vehicle to slow its velocity, followed by use of emergency brake to stop. Vehicle was towed to dealership for inspection. This vehicle had no history of braking problems or issues.

- Scottsdale, AZ, USA

Complete loss of brakes. Loss of fluid. Thankfully it happened when I was about to leave my house so I was parked in my drive. The brake pedal went straight to the floor. When I popped the hood and looked at master cylinder the fluid was almost gone.

- Nolensville, TN, USA

Driving at 65 mph on the highway went to stop for traffic and brake pedal went to the floor. Warning light appeared and said brake fluid was low, brake light on dash board came on. Added brake fluid and within 10 miles the same thing happen again. Had to have the vechicle towed.

- Peyton, CO, USA