1993 Ford Taurus
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1993 Taurus are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #BC9584961001
INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN. *TT Read More »
-
TSB #95191
THE POWER STEERING SYSTEM MAY HAVE A 'GRUNT' AND/OR 'GROAN' NOISE. THIS MAY BE CAUSED BY HYDRAULIC FLUID MOVEMENT WITHIN THE POWER STEERING RACK. Read More »
-
TSB #9716
SOME POWER STEERING HOSES HAVE BEEN REPLACED WITH A REVISED DESIGN AND SHOULD NO LONGER BE USED FOR SERVICE. *JD Read More »
-
TSB #5897
EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT Read More »
-
TSB #12570
SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT Read More »
-
TSB #9534
RATTLING OR CLUNKING NOISE FROM THE FRON SUSPENSION. *TW Read More »
-
TSB #9511
PREMATURE WEAR ON THE INNER EDGES OF REAR TIRES. *TW Read More »
-
TSB #98S15
SAFETY RECALL AND OWNER NOTIFICATION TO INSTALL PROTECTIVE SPRING SHIELDS ON THE FRONT COIL SPRINGS OF AFFECTED VEHICLES TO REDUCE THE POSSIBILITY OF TIRE PUNCTURE SHOULD SPRING FACTURE OCCUR. Read More »
-
TSB #98S15
SAFETY RECALL INVOLVING INSTALLATION OF THE PROTECTIVE SPRING SHIELDS ON CERTAIN VEHICLES FRONT COIL SPRINGS - STABILIZER LINK REPLACEMENT PARTS ON NATIONAL BACKORDER. *TT Read More »
-
TSB #9556
PREMATURE WEAR ON INNER EDGES OF REAR TIRES MAY BE CAUSED BY REAR CAMBER AND TOE SETTINGS THAT ARE NOT WITHIN SPECIFICATION. *TW Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #985A7
SERVICE BRAKE PEDAL MAY HAVE A SLIP / STICK CONDITION WHEN THE BRAKE IS APPLIED. *TT Read More »
-
TSB #99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »
-
TSB #985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »
-
TSB #985A20
A SQUEALING NOISE MAY COME FROM THE REAR BRAKES ON SOME VEHICLES WHEN BRAKING. *TT Read More »
-
TSB #96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW Read More »
-
TSB #9674
EXPERIENCING A SQUEAL NOISE COMING FROM THE REAR BRAKES ON SOME VEHICLES WHEN BRAKING. *TT Read More »
-
TSB #985A13
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC Read More »
-
TSB #9562
ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »
-
TSB #9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »
-
TSB #985A6
SOME VEHICLES MAY CYCLE WHEN BRAKES ARE APPLIED ON ROUGH ROADS OR ON AN INCLINE WHILE MAKING A SHARP TURN. *YC Read More »
-
TSB #95212
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. Read More »
-
TSB #94251
ANTI-LOCK BRAKES - BRAKE PEDAL HAS SLIP/STICK CONDITION AFTER APPLICATION - NOISE/VIBRATION ON SLOW APPLY AND RELEASE. *TW Read More »
-
TSB #94251
BRAKES - ANTILOCK- BRAKE PEDAL HAS SLIP/STICK CONDITION AFTER APPLICATION. *TW Read More »
-
TSB #9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »
-
TSB #01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »
-
TSB #9874
A NEW SILICONE GASKET AND SEALANT. *YC Read More »
-
TSB #9811329
INFORMATION REGARDING THE THE AVAILABILITY OF THE REVISED HEADGASKET FOR COOLANT LOSS CONDITIONS ON SOME ENGINES. *TT Read More »
-
TSB #97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »
-
TSB #9743
BLOWER MOTOR- "CHIRP" OR "SQUEAK" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »
-
TSB #ONP92M77
SUPPLEMENT TO ONP92M77 - PROGRAM EXPANDED TO INCLUDE 1992/93 FORD TAURUS AND MERCURY SABLES. *TW Read More »
-
TSB #0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
-
TSB #14584
SUBJECT REGARDING FLEX FUEL VECHICLE OIL AND FUEL RECOMMENDATIONS. *JB Read More »
-
TSB #99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT Read More »
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #9582
A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW Read More »
-
TSB #9849
CONCERNS WITH COOLANT MAY LEAK FROM THE HEAD GASKETS AND / OR THE VEHICLE MAY OVERHEAT. *YC Read More »
-
TSB #95153
TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS. *SD Read More »
-
TSB #982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »
-
TSB #9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
-
TSB #94227
OBJECTIONABLE ODOR FROM THE EXHAUST SYSTEM. *TW Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #9521
VEHICLES MAY NOT INDICATE FUEL LEVEL PROPERLY. *TW Read More »
-
TSB #96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »
-
TSB #4665
SOME FLEX FUEL VEHICLES WITH PREVIOUSLY SERVICED FUEL SENDERS MAY EXHIBIT A FUEL GAUGE INDICATOR THAT STAYS AT APPROXIMATELY << TANK. *TT Read More »
-
TSB #11782
SOME FLEX FUEL VEHICLES WITH PREVIOUSLY SERVICED FUEL SENDERS MAY EXHIBIT A FUEL GAUGE INDICATOR THAT STAYS AT APPROXIMATELY << TANK. *TT Read More »
-
TSB #5290
SOME VEHICLES MAY EXHIBIT A SPEEDOMETER POINTER WIVER CONCERN. *TT Read More »
-
TSB #12209
SOME VEHICLES MAY EXHIBIT A SPEEDOMETER POINTER WAIVER CONCERN. *TT Read More »
-
TSB #12967
VEHICLES MAY EXHIBIT SPEEDOMETER POINTER WAVER. *MJS Read More »
-
TSB #985027
VEHICLES MAY EXPERIENCE SPEEDOMETER POINTER WAVER. *TT Read More »
-
TSB #12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. Read More »
-
TSB #97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC Read More »
-
TSB #12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT Read More »
-
TSB #BC7235961101
VEHICLE MAY EXHIBIT A CHATTER WHEN RELEASING THE CLUTCH IN REVERSE GEAR. *TW Read More »
-
TSB #9802169838
TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC Read More »
-
TSB #BC0678961025
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT Read More »
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #12099
VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »
-
TSB #BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD Read More »
-
TSB #BC9683961001
PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES. *TT Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #94247
THE FORWARD CLUTCH PISTON MAY CRACK ON ITS OUTSIDE DIAMETER. *TW Read More »
-
TSB #14811
INFORMATION ON ADDITIONAL PARTS REQUIRED WHEN REPLACING TRANSFER CASE ON VEHICLES EQUIPPPED WITH AX4S TRANSAXLE. *TT Read More »
-
TSB #12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT Read More »
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
-
TSB #96713
SOME CUSTOMERS MAY EXPERIENCE OVERDRIVE NOT ENGAGING WHICH IS RELATED TO NO TORQUE CONVERTER CLUTCH ENGAGEMENT IN COLD WEATHER. *TT Read More »
-
TSB #95157
THE TORQUE CONVERTER IDENTIFICATION CODES HAVE BEEN REVISED AS OF 3/1/95. *SD Read More »
-
TSB #01181
BRAKE SHIFT INTERLOCK.*JB Read More »
-
TSB #0117
SUBJECT REGARDING REMANUFACTURED AX4S SHO TRANSAXLES BUILT WITH A UNIQUE TRIPLE CLUTCH PACK ASSEMBLY AND DRIVEN SPROCKET SUPPORT. *TT Read More »
-
TSB #95177
TRANSAXLE-REVISED CLUTCH CLEARANCES-AXODE/AX4S. *SD Read More »
-
TSB #982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC Read More »
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
-
TSB #97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Read More »
-
TSB #94263
SOME VEHICLES MAY EXHIBIT A NO-CRANK CONDITION DUE TO CORROSION AT THE STARTER SOLENOID CONNECTOR. *TW Read More »
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
-
TSB #96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Read More »
-
TSB #9543
SOME VEHICLES MAY NOT INDICATE FUEL LEVEL PROPERLY. *TW Read More »
-
TSB #95102
VEHICLES MAY HAVE A DISCONNECT OF THE IGNITION CONTROL MODULE (ICM) CONNECTOR OR MOISTURE BUILDUP WITHIN THE CONNECTOR. *TW Read More »
-
TSB #97613
TRANSAXLE- AX4S/AX4N- DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744 STORED IN MEMORY AFTER TRANSAXLE EXCHANGE. *JD Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »
-
TSB #02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »
-
TSB #96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW Read More »
-
TSB #95203
A 'GROANING' NOISE MAY COME FROM THE FRONT POWER WINDOWS AFTER THE GLASS IS POWERED FULL UP. THIS NOISE IS CAUSED BY IMPROPER LUBRICATION ON THE WINDOW REGULATOR MECHANISM SLIDING SURFACES. Read More »
-
TSB #011201
THIS INFORMATION IS A SUPPLEMENT TO THE WIPER SYSTEM SERVICE INFORMATION PROVIDED IN THE WORKSHOP MANUALS. THIS SERVICE INFORMATION IS INTENDED AS AN AID TO ASSIST IN DIAGNOSIS AND REPAIR OF ERRATIC WIPER SYSTEM CONDITIONS. Read More »
-
TSB #02107
TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT Read More »
-
TSB #9582
A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW Read More »
-
TSB #9546
WIPER MOTOR REPLACEMENT - UPGRADED SERVICE KITS. *TW Read More »
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
-
TSB #9592
UNKNOWN Read More »
-
TSB #95511
CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW Read More »
-
TSB #9566
CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #9671
SOME VEHICLES MAY EXPERIENCE THE AIR BAG DIAGNOSTIC LIGHT FLASHING. *TT Read More »
-
TSB #FD950526
UNKNOWN Read More »
-
TSB #9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »
-
TSB #95151
WHEEL COVER - DISTORTED OR MELTED VEHICLES WITH BOLT-ON WHEEL COVERS. *SD Read More »
-
TSB #9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD Read More »
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »
-
TSB #97090297184
SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC Read More »
-
TSB #RCL/94E55
UNKNOWN Read More »
-
TSB #02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #9848
ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC Read More »
-
TSB #BC1371950906
REVISED LARGER DIAMETER COMPRSSOR CLUTCH PULLEY AVAILABLE TO CORRECT A MOANING NOISE CONDITION EMITTED FROM THE COMPRESSOR. *TW Read More »
-
TSB #95168
AIR CONDITIONING-A/C COMPRESSOR MOAN - VEHICLES WITH 3.8L ENGINE. NOISE -'MOAN' - A/C COMPRESSOR-VEHICLES WITH 3.8L ENGINE.*SD Read More »
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #98L20
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT Read More »
-
TSB #9817
CONDITIONS WITH THE MALFUNCTIONING OF THE INDICATOR LAMP. Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »