1997 Ford Windstar
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1997 Windstar are official communications between Ford & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #15767
SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT Read More »
-
TSB #97120897251
THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC Read More »
-
TSB #BC1031597020
POWER STEERING LINE LEAKS ON 95/96 3.8L TRAILER TOW EQUIPPED TUBE AND FIN COOLER SYSTEMS SEE OASIS MESSAGE 4685. *JD Read More »
-
TSB #02152
SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT Read More »
-
TSB #02132
GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT Read More »
-
TSB #97110
SUSPENSION-DIAGNOSTIC AAN INSPECTION FOR FRONT SUSPENSION NOISE (S)- SERVICE TIP. *AK TIP. Read More »
-
TSB #12114
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS Read More »
-
TSB #985137
SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT Read More »
-
TSB #BC1016397230
BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD Read More »
-
TSB #982535
EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC Read More »
-
TSB #11474
SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT Read More »
-
TSB #16987
SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT Read More »
-
TSB #99194
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Read More »
-
TSB #11505
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT Read More »
-
TSB #985A11
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Read More »
-
TSB #96222
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW Read More »
-
TSB #985020
SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. Read More »
-
TSB #15719
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT Read More »
-
TSB #14656
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT Read More »
-
TSB #982465
SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC Read More »
-
TSB #985A5
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Read More »
-
TSB #9814
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Read More »
-
TSB #6392
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT Read More »
-
TSB #12230
ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
-
TSB #985A48
ON SOME VEHICLES THE ANTI-LOCK BRAKE SYSTEM (ABS) PUMP MOTOR MAY RUN WHILE APPLYING THE BRAKE WHEN TURNING AND DRIVING OVER A BUMP. *TT Read More »
-
TSB #97211
BRAKES - ANTI-LOCK - ABS PUMP MOTOR ACTIVATION WHILE BRAKING OVER A BUMP OR AN INCLINE - VEHICLES WITH TRACTION CONTROL - VEHICLES BUILT THROUGH 9/15/96. *TW Read More »
-
TSB #15682
EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT Read More »
-
TSB #12808
SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT Read More »
-
TSB #BC0083970201
IF RED BRAKE LAMP OR THE YELLOW ABS LAMP IS ON, VERIFY THE MASTER CYLINDER IS FULL WITH BRAKE FLUID. *JD Read More »
-
TSB #BC1014497020
COMPLAINTS OF THE RED BRAKE LAMP OR THE YELLOW ABS LAMP ON, CHECKING THE MASTER CYLINDER BRAKE FLUID LEVEL SHOULD BE THE FIRST STEP. *JD Read More »
-
TSB #9845
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC Read More »
-
TSB #985A28
SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC Read More »
-
TSB #99207
SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT Read More »
-
TSB #13186
INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS Read More »
-
TSB #99131
CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT Read More »
-
TSB #02221
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ Read More »
-
TSB #870197
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. Read More »
-
TSB #01124
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Read More »
-
TSB #6996
INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT Read More »
-
TSB #6997
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT Read More »
-
TSB #13180
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS Read More »
-
TSB #5518
INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT Read More »
-
TSB #97610
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD Read More »
-
TSB #97516
ENGINE- 3.8L - "CHIRPING" NOISE DURING NORMAL ENGINE OPERATION. *JD Read More »
-
TSB #BC0990961021
INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT Read More »
-
TSB #BC9666961001
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT Read More »
-
TSB #0214
SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT Read More »
-
TSB #01246
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT Read More »
-
TSB #01205
SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT Read More »
-
TSB #0147
SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT Read More »
-
TSB #99183
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT Read More »
-
TSB #13242
INFORMATION REGARDING TSB 97-20-08 FOR 3.8L ENGINES ONLY. *MJS Read More »
-
TSB #99816
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Read More »
-
TSB #982511
SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC Read More »
-
TSB #12174
SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS Read More »
-
TSB #983108
EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK Read More »
-
TSB #BC0122970201
UNIQUE COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD Read More »
-
TSB #BC1013097020
COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD Read More »
-
TSB #982010
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC Read More »
-
TSB #9864
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT Read More »
-
TSB #983581
SOME VEHICLES MAY EXHIBIT CONDITIONS OF EXHAUST DRONE AT 1700 RPM. *TT Read More »
-
TSB #982310
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Read More »
-
TSB #981512
A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK Read More »
-
TSB #7120
SOME VEHICLES MAY EXHIBIT BLACK SOOT EMITTED FROM THE TAILPIPE LEAVING DEPOSITS ON RIGHT REARL LOWER QUARTER PANEL. *TT Read More »
-
TSB #13309
SOME VEHICLES WITH 3.8L ENGINE MAY EXHIBIT BLACK SOOT ON THE LOWER SECTION OF THE RIGHT REAR QUARTER PANEL. *TT Read More »
-
TSB #98-0316
CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT Read More »
-
TSB #BC105909705
INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW Read More »
-
TSB #96225
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW Read More »
-
TSB #0398
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT Read More »
-
TSB #17358
GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT Read More »
-
TSB #15370
SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT Read More »
-
TSB #15392
SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT Read More »
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
-
TSB #12178
INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. Read More »
-
TSB #97111097237
CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC Read More »
-
TSB #12559
CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT Read More »
-
TSB #0015
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS Read More »
-
TSB #99152
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Read More »
-
TSB #13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »
-
TSB #12099
VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS Read More »
-
TSB #9888
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Read More »
-
TSB #982512
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC Read More »
-
TSB #980304
INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK Read More »
-
TSB #BC2380970501
HARSH 1-2 UPSHIFT. *TW Read More »
-
TSB #97511
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Read More »
-
TSB #BC1017197230
VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTRY INTO THE TRANSAXLE RANGE SENSOR. *JD Read More »
-
TSB #BC0011970201
A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD Read More »
-
TSB #BC0141970201
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD Read More »
-
TSB #BC101209702
VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD Read More »
-
TSB #962613
TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW Read More »
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #BPI9904
CONDITIONS WITH THE TRAC OFF LAMP ILLUMINATING INTERMITTENTLY AND THER MAY ALSO BE STORED TROUBLE CODES U1009 AND / OR U1027. Read More »
-
TSB #98153
THIS TSB IS BEING REPUBLISHED IN ITS ENTIRETY TO REVISE THE POWER TRAIN CONTROL MODULE (PCM) CALIBRATION CROSS REFERENCE AND REVISE PCM SERVICE PART NUMBERS. *AK Read More »
-
TSB #981519
TRACTION CONTROL LAMP FLASING INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODES U1009 AND/OR U1027. *AK Read More »
-
TSB #12616
INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT Read More »
-
TSB #03148
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Read More »
-
TSB #5131
SUBJECT REGARDING VEHICLES WITH THE AX4S TRANSAXLE HAVING AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *TT Read More »
-
TSB #03123
TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT Read More »
-
TSB #14773
INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT Read More »
-
TSB #962612
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW Read More »
-
TSB #96249
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW Read More »
-
TSB #01181
BRAKE SHIFT INTERLOCK.*JB Read More »
-
TSB #01171
TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM Read More »
-
TSB #99184
SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT Read More »
-
TSB #996735
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »
-
TSB #13024
SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT Read More »
-
TSB #98221
INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *YC Read More »
-
TSB #BC0011972301
BUZZ NOISE IN AX4S TRANSAXLES. *JD Read More »
-
TSB #BC0680961024
VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL. *TT Read More »
-
TSB #BC5197961001
SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT Read More »
-
TSB #982675
A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC Read More »
-
TSB #03203
MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. Read More »
-
TSB #03181
REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT Read More »
-
TSB #98246
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Read More »
-
TSB #12227
FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT Read More »
-
TSB #97111097234
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Read More »
-
TSB #99222
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT Read More »
-
TSB #96246
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Read More »
-
TSB #BC3370972301
THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD Read More »
-
TSB #9943
INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT Read More »
-
TSB #962214
SERVICE MANUAL - POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON BOARD DIAGNOSIS II (OBD II) - COVER PAGE REPLACEMENT TO INCLUDE 1997 WINDSTAR. *TW Read More »
-
TSB #BC3274970207
REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS ... Read More »
-
TSB #99139
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Read More »
-
TSB #02176
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Read More »
-
TSB #96221
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW Read More »
-
TSB #BC3381972301
ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD Read More »
-
TSB #BC1022097230
ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD Read More »
-
TSB #01156
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC Read More »
-
TSB #982677
SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC Read More »
-
TSB #16-0065
For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount ... Read More »
-
TSB #14222
CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT Read More »
-
TSB #9855
WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC Read More »
-
TSB #983101
SOME VEHICLES MAY EXHIBIT A NOISE WHILE TURNING OR BRAKING. *TT Read More »
-
TSB #9831
REPAIRS TO VINYL COVERED SURFACES. *YC Read More »
-
TSB #9833
SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC Read More »
-
TSB #971110972311
CONDITIONS WITH NOISE COMING FROM THE RIGHT UPPER A-PILLAR AREA DURING TURNS. *YC Read More »
-
TSB #99-8-15
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT Read More »
-
TSB #98416
EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT Read More »
-
TSB #983094
SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT Read More »
-
TSB #983303
CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT Read More »
-
TSB #9811349
VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT Read More »
-
TSB #BC1013697020
INOPERTIVE AUTOLOCK SYSTEM. *JD Read More »
-
TSB #8249
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT Read More »
-
TSB #13931
SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT Read More »
-
TSB #9775
HOOD- SERVICE REPAIR TIPS. *JD Read More »
-
TSB #98127
EXPERIENCING ACCELERATOR PEDAL "BUZZING" NOISE AND / OR EXHAUST "DRONING" NOISE AT APPROXIMATELY 1700 RPM WHLE DRIVING. *TT Read More »
-
TSB #BC1024997230
A HARSH 1-2 SHIFT ON LIGHT THROTTLE, AT NORMAL SHIFT SPEEDS OF 10-15 MPH. *JD Read More »
-
TSB #5203
SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT Read More »
-
TSB #9852
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Read More »
-
TSB #04L23
LITERATURE PROGRAM 04L23. CUSTOMER MAINTENANCE REMINDER - ALUMINUM WHEEL LUG NUT TORQUE. *TT Read More »
-
TSB #9751
INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD Read More »
-
TSB #99129
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Read More »
-
TSB #9873
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Read More »
-
TSB #02208
CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH Read More »
-
TSB #
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT Read More »
-
TSB #99195
SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT Read More »
-
TSB #99196
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT Read More »
-
TSB #9913073
CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT Read More »
-
TSB #985086
SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT Read More »
-
TSB #98125
VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT Read More »
-
TSB #97624
AIR CONDITIONING- WATER DRIPPING ONTO FLOOR DRAIN TUBE DURING A/C SYSTEM OPERATION. *JD Read More »
-
TSB #9735
AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD Read More »
-
TSB #982011
CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC Read More »
-
TSB #15373
SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT Read More »
-
TSB #01157
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC Read More »
-
TSB #011701
INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET Read More »
-
TSB #981617
FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD Read More »
-
TSB #99111
INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT Read More »
-
TSB #991210
FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT Read More »
-
TSB #98259
SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. Read More »
-
TSB #98-4723
ENGINE CHECK LAMP ON, AND MISFIRE DTC (S) PO300-PO306 ACTION. Read More »
-
TSB #4639
INFORMATION ON DIAGNOSTIC PROCEDURES FOR VEHICLES EXHIBITING CHECK ENGINE LAMP ON AND MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0306. *TT Read More »
-
TSB #980311
CHECK ENGINE LAMP ON AND MISFIRE DTC (S) P0300-P0306. *YC Read More »
-
TSB #9811484
SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT Read More »
-
TSB #98515
SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC Read More »
-
TSB #BC2295970501
INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW Read More »
-
TSB #9768
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Read More »
-
TSB #97115
SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD Read More »