This is the second time my blower motor and blower motor resistor has blown out in two months. Me and my two children had to drive from Alabama to Virginia on our family vacation in 110 degree weather without any air. SUV smelled liked melted wires. When I took it in again to have it diagnosed. Mechanic said these keep having the same problems. This is horrible. Another repair out of state will cost me $550, GMC needs to recall these [xxx] trucks!!! information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Northport, AL, USA

Fuel gauge has stopped working properly. When tank is filled, the gauge reads empty and fuel light is on. When the fuel level begins to decrease below the full level from driving the vehicle, the gauge fluctuates between the completely full mark and the empty mark. This fluctuation can occur during a trip that is less than a few miles.

- Ellabell, GA, USA

When turning the key on the vehicle sometimes does not start and has twice from when I got it in Feb 2012 all the internal electronics have shut down while driving

- Vestal, NY, USA

Tried to turn on the air conditioning and discovered the fan did not work. After quite a bit of research and an expensive diagnosis, was informed the blower motor resistor was burned out. This appears to be a common, frequent, and expensive problem if done by the dealership. There are several potential hazards to families and children which include; the possibility of fire caused by the heated & melted wire, loss of air conditioning in the heat of the day which may cause heat stroke or worse, and loss of heat during the winter months making it impossible to drive safely without the windows icing over and inhibiting vision. A recall in order to repair the problems with the blower motor resistor is necessary. Mechanic states that both Chevrolet and GMC model vehicles from 2004 to 2007 are being repaired with this exact problem. He has repaired 5 vehicles this month in the state of Alabama. Mechanic also states that mileage is not the issue as he has seen low mileage GMC and Chevrolet come in for repairs with this exact same problem. Please respond to this very expensive safety/ health issue as a vehicle recall.[xxx] information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Northport, AL, USA

When I went out to my truck in the morning my vehicle was full of smoke, the drivers side electrical on the door doesn't work, door lock. Windows don't work, mirror doesn't work keyless entry either, I went to the dealer they said it was a drivers side master doorswitch failure, they wanted $350 to fix we only had the vehicle less than 30 days didn't make 1st payment yet. We saw in the newspaper that these vehicles have this problem so were hoping you can generate enough energy into this problem so we can get this fixed.

- Mount Morris, MI, USA

The contact owns a 2006 GMC Envoy. The contact started the ignition and the fuel gauge displayed an inaccurate reading even though fuel had been dispensed into the fuel tank. While driving, the fuel gauge reading fluctuated which caused difficulty in determining the actual fuel tank level. In addition, the air bag warning indicator illuminated continuously whenever the vehicle was operative. There were also electrical issues which contributed to the radio not to function and the instrument panel cluster lights would not illuminate. The fuel sensor was replaced previously by the dealer and the failure recurred three years later. The vehicle had not been repaired for the most recent fuel gauge malfunction. There were no repairs performed in relation to the other failures. The manufacturer was notified of the problem. The approximate failure mileage was 23,000. Updated 4/2/12 the consumer stated the fuel level sensor failed twice. Also, ai =R bag warning light was fixed by moving the SRS wiring under the driver's sat. The radio and dash lights were replaced as well, due to inferior parts. Updatd 04/16/12

- Ormond Beach , FL, USA

When driving my Envoy home from work the window starting going down by itself and then it made a horrible noise like a grinding noise. Then the window started going back and smoke started poring out of the door locks and by the vent on the drivers side of the door. Smoke was pouring out I had to pull over and when I got out it smelled liked burnt rubber. It continued to smoke for about 5 mins. And then it stopped. The smell is still in my car but I have no electric functions on the drivers side door. My windows do not work, the outside mirror does not work, the seat controls do not work, the heated seated seats do not work.

- Oxford, MI, USA

The heat and air fan resistor caught on fire causing the electrical system to catch on fire. Smoke coming from under the dash and from the glove box. The surge had caused the head light wires to burn into. Such a mess...fuel gauge had stopped working about a year prior to that.now the power steering is having a problem. What next.....

- Hiawassee, GA, USA

Fuel gage stopped working. Fuel gage needle stayed on E after filling up. Stalled in left lane of interstate 80 in denville, New Jersey with my two daughters. Their ages at time of incident were eight and eleven. Almost rear-ended by tractor trailers. All three of would have been killed if the truck driver had not been alert and swerved to avoid us as I slowed and navigated to right shoulder.

- Bridgewater, NJ, USA

The fuel gauge does not read correctly. This has caused the vehicle to run out of gas several times now in the middle of traffic due to the gauge telling me I had more fuel than I actually had.

- Troy, MI, USA

Well I have a 2006 Envoy, the battery hand bounces between 0-14 volts replaced the battery, had the alter nator checked and its fine. I talked to the guy at a GMC deal he said its the dashboard switches.. and the check engine light comes on and off, he said its a sensor or the dash panel. Who knows. You shouldn't have to go thru al this hassel. I want mine fixed.......

- Rilpey, TN, USA

While driving GMC Envoy wipers move by themselves. Then stop after a min. Or so! as we pull out of the driveway water sprays and windshield wipers move constantly by themselves. All of these factors create horrible visability!

- Hollywood Fl, FL, USA

Electrical system has issues. The truck (with a new battery) need to be jumped. Occasionally it will turn without a jump, the radio and other electrical items reset. The stabilitrac light comes on.

- Mooresville, NC, USA

I have had 2 problems with this vehicle. The first one was at 28000 miles, about 3 weeks after I bought the vehicle. The resistor for the heat/ac fan caught fire while I was driving at about 5 mph in heavy traffic. The fire went out on it's own by the time I had room to pull over (about 15-20 seconds). I was unable to get the part replaced right away so I had to drive around in cold and icy conditions without even being able to run the defroster. The second problem was that at about 32000 miles my gas gauge broke. I had just filled the tank and was driving at about 65 on the highway. The gas gauge needle dropped to empty and stayed there. I made sure that I was not leaking gasoline and continued on my way. It worked intermittently for a while but is now completely broken. When I fill up my tank the engine light comes on for the first 25-100 miles and the gauge reads empty with the fuel light on. I am uncomfortable with using the 4WD or towing very much because even though I keep track of miles driven these things eat up more fuel. I don't want to run out of gas in the middle of the road. I have not gotten it fixed because of the repair cost.

- Willits, CA, USA

Driving at normal highway speed, the fuel gauge would register full, then would register empty, the low fuel warning light would illuminate, and the fuel gauge would not work again. The check engine light would come on and when I took the car to a mechanic, I was informed that I had a bad fuel sensor. This is a common problem and urge the safety administration to force GM to issue a recall. The safety factor, is running out of fuel with no warning on a street or highway and no safe way to pull off the roadway out of harms way.

- Raeford, NC, USA

The contact owns a 2006 GMC Envoy. The contact stated the air conditioner was activated and there was an abnormal burning odor. The vehicle was taken to a local repair facility where the mechanic advised that the harness switch had overheated and burned. The vehicle was not repaired. The manufacturer was not contacted. The VIN was unavailable. The failure mileage was 117,450.

- Addison, TX, USA

2006 GMC Envoy; replaced timing chain, failure of fuel pump, oil pump, electrical system driver's side door, washer fluid pump, tailgate latch failure and rear wash fluid line failure. Replaced or fixed all issues except, tailgate latch, rear washer fluid line, oil pump issue and SUV will not hold oil pressure.

- Gibsonia, PA, USA

Driving when three lights showed up on instrument panel stabilitrak, check engine and reduced engine power light came on the Envoy completely turned it self off. I waited a few minutes then started the car. It started the check engine light was the only light on. I got home and restarted car all lights disappeared. Next day driving the same thing happen. Three more times on the way to mechanic the Envoy turned itself off. Find out the programmable control module PCM was defective. This car was purchased as a certified used vehicle 07/08. I then find out the part is readily available and not a special order. They refurbish this part with a one year warranty. I can not believe that GMC would engineer a car to entirely shut down when driving this could have been very dangerous had I been on the freeway going 65 mph, also that this should not happen as it is not a wear and tear issue. The codes that showed up were apparently not covered by GMC. With this part being readily available I must not be the only one who has had this happen. This was a costly repair, and I feel that someone should look to see if this has happen to others, before someone gets hurt or killed.

- West Hills, CA, USA

The contact owns a 2006 GMC Envoy. While driving at speeds of 65 mph, the power door lock switch caught on fire. The dealer advised the vehicle could be repaired but the part needed to make the necessary repairs was not available and would not be available for another six months. The vehicle had not been repaired. The current and failure mileages were 65,000. Updated 11/03/10.

- Shadyside, OH, USA

Incorrect fuel level reading may result in the vehicle running out of fuel without warning to the driver

- Hope, IN, USA