2004 GMC Savana
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2004 Savana are official communications between GMC & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #030232003
STEERING NOISE WHEN TURNING LEFT. *TT UPDATED 3/4/11. *PE UPDATED ON 6/30/2011. *KB Read More »
-
TSB #SB-10-02-33-001
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
-
TSB #07103
STEERING IDLER ARM ATTACHING BRACKET FRACTURE. *KB Read More »
-
TSB #03102005
STEERING GEAR WHISTLE NOISE ON TURNS. *EH Read More »
-
TSB #01897
LACK OF STEERING ASSIST OR SHUDDER DURING PARKING LOT TYPE MANEUVERS. *MR Read More »
-
TSB #SB-10-02-33-001
BUICK/CADILLAC/CHEVROLET/GMC/OLDSMOBILE AND HUMMER: INFORMATION ON PITMAN ARM SHAFT SEAL SERVICE KIT. DO NOT REPLACE ENTIRE STEERING GEAR FOR PITMAN SEAL LEAK. Read More »
-
TSB #00823A
POWER STEERING FLUID LEAKING AT HYDRAULIC BRAKE BOOSTER. *TT Read More »
-
TSB #01863
LACK OF STEERING ASSIST WHEN STOPPED OR DURING PARKING LOT TYPE MANEUVERS. *MR Read More »
-
TSB #070234001
STEERING WHEEL SHAKE AND/OR TIRE WEAR (INSPECT STEERING LINKAGE). *NJ UPDATED 4/11//08. *NJ Read More »
-
TSB #3499
STEERING IDLER ARM INSPECTION PROCEDURE. *TT Read More »
-
TSB #030309002
REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ Read More »
-
TSB #020307002
REVISED FRONT CASTER AND CAMBER ADJUSTMENT PROCEDURE. ORIGINAL NOT YET RECEIVED. *TT Read More »
-
TSB #3320
CLUNK POP NOISE IN THE FRONT SUSPENSION OVER BUMPS. *TT Read More »
-
TSB #PIP4054A
EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE Read More »
-
TSB #3000A
REAR AXLE LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS. *MJ Read More »
-
TSB #030309002
REAR LEAF SPRING SLAP OR CLUNK NOISE (REPLACE SPRING INSERTS) *TT UPDATED 10/18/07. *NJ Read More »
-
TSB #02053
INFORMATION ON RESURFACING THE PARK BRAKE PORTION OF THE REAR BRAKE ROTOR. *TT Read More »
-
TSB #PIT-3665-D
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT THE HYDRO-BOOST IS NOT SERVICEABLE AND WILL NEED TO BE REPLACED IF THE BRAKE PEDAL MOVES OR APPLIES ON ITS OWN AT A FULL TURN. Read More »
-
TSB #030525007
ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS (CLEAN WHEEL SPEED SENSOR MOUNTING SURFACE). *TT UPDATED 10/23/09. *PE Read More »
-
TSB #050525002
DIAGNOSTIC INFORMATION ON ANTILOCK BRAKE SYSTEM (ABS) DIAGNOSTIC TROUBLE CODE(S) (DTC) C0035, C0040, C0050, C0055 AND/OR P0609. *TT Read More »
-
TSB #3521
ANTI-LOCK BRAKING SYSTEM (ABS) LIGHT ON SPEEDOMETER MAY BE ERRATIC. DIAGNOSTIC TROUBLE CODE (DTC) C0055 C0235 C0236 OR C0237 STORED IN THE EBCM. *TT 1998-2008 ALL CHEVROLET, GMC, BUICK, AND OLDSMOBILE MID-SIZED TRUCKS AND UTILITIES. Read More »
-
TSB #4080
ABS AND TRACTION OFF LIGHTS COMES ON INTERMITTENTLY. *TT UPDATED 03-01-07. *KB Read More »
-
TSB #060522006
HYDRO-BOOST UNIT/POWER BRAKE BOOSTER APPEARS TO BE LEAKING. *KB Read More »
-
TSB #020526001B
REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT Read More »
-
TSB #3521
ANTI-LOCK BRAKING SYSTEM (ABS) LIGHT ON SPEEDOMETER MAY BE ERRATIC. DIAGNOSTIC TROUBLE CODE (DTC) C0055 C0235 C0236 OR C0237 STORED IN THE EBCM. *TT 1998-2008 ALL CHEVROLET, GMC, BUICK, AND OLDSMOBILE MID-SIZED TRUCKS AND UTILITIES. Read More »
-
TSB #020526001B
REAR PARKING BRAKE SHOE RETAINING SPRING CLIP SERVICE KIT FOR DRUM-IN-HAT (DIH) EQUIPPED VEHICLES. *TT UPDATE. *TT Read More »
-
TSB #PIP5029G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
-
TSB #PI1394A
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. Read More »
-
TSB #000601012F
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. Read More »
-
TSB #PIP-4138K
GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM Read More »
-
TSB #040602008
COOLANT LEAK AT CAP OF COOLANT RECOVERY RESERVOIR. *TT Read More »
-
TSB #040604028
VARIOUS DRIVEABILITY CONCERNS CHECK ENGINE LIGHT ON DIAGNOSTIC TROUBLE CODE SET. *EH Read More »
-
TSB #040602002
THROTTLE BODY COOLANT RETURN HOSE FALLING OUT OF CLIP. *EH Read More »
-
TSB #040603001
INCORRECT AMP CODE GENERATOR. *EH Read More »
-
TSB #040603002
DIAGNOSTIC INFORMATION FOR INTERMITTENT VEHICLE NO CRANK DEAD BATTERY. *EH Read More »
-
TSB #01494
COOLANT LEAK. SERVICE VME. SIT BULLETIN 1401332. *TT Read More »
-
TSB #3103
NO ENHANCED EVAP DATA LIST ON TECH ON TECH 2 *SC Read More »
-
TSB #3097
OIL PAN OR OIL COOLER LINE LEAK. *SC Read More »
-
TSB #3239
LIGHT IS ON AND DIAGNOSTIC TROUBLE CODES P1125 AND P2125 SET. *EH Read More »
-
TSB #UIB-117
GENERAL MOTORS: AN OPTIONAL ENGINE BLOCK HEATER PLUG IN FOR ONBOARD AC POWER AND WITH CONTINUOUS USAGE WILL RESULT IN SHORTING OF WIRES, OVER HEATING SYSTEM, ELECTRICAL FAILURE AND COMPARTMENT ENGINE FIRES. Read More »
-
TSB #PIP-4492P
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
-
TSB #PIP-4851
GM: THERE IS AN INTERMITTENT ENGINE LIGHT ON DUE TO FIVE POSSIBLE INTERNAL TROUBLE CODES. THERE MAY ALSO BE AN EXTENDED CRANK AFTER FILLING THE FUEL TANK. *RM UPDATED 5/31/11. *PE UPDATED ON 06/16/2011. Read More »
-
TSB #050308019
DIAGNOSTIC INFORMATION FOR NOISE IN STEERING AND INSPECTION OF IDLER ARM BRACKET. *KB UPDATED ON 09/19/07. *NJ Read More »
-
TSB #030604030
MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT Read More »
-
TSB #050604046
CRANK AND NO START, REDUCED POWER, INTERMITTENT HESITATION, HESITATES IN HIGH ALTITUDE/HIGH AMBIENT TEMPERATURES. *TT Read More »
-
TSB #050604077
LACK OF POWER LU3 ENGINE) AT HIGH AMBIENT TEMPERATURES ONLY (IF NECESSARY, REPROGRAM PCM WITH NEW SERVICE CALIBRATION).*AK Read More »
-
TSB #050601014
OIL LEAK UNDER EXTREME COLD TEMPERATURES (-34 DEGREES C) (-30 DEGREES F) OR COLDER). *TT Read More »
-
TSB #040601020
ENGINE OIL LEAK NEAR OIL FILTER. *TT Read More »
-
TSB #040604043
UNABLE TO RESET ENGINE OIL LIFE MONITOR. *TT Read More »
-
TSB #030604033
REVISED DIAGNOSTIC TROUBLE CODE P0336. *TT UPDATE. TO INCLUDE 2004 ISUZU NQR COMMERCIAL MODELS. *TT Read More »
-
TSB #030849012
CHANGE ENGINE OIL LIGHT ON. *TT UPDATE. *TT Read More »
-
TSB #01587
FUEL PUMP DOES NOT OPERATE CAUSING A CRANK, NO START CONDITION. SIT BULLETIN 1414213. *TT Read More »
-
TSB #01485A
TIMING CHAIN TENSIONER BREAKPOINTS FOR SERVICE KIT OR PRODUCTION FIX FOR VEHICLE EXHIBITING RATTLE-TYPE NOISE COMING FROM THE ENGINE AT APPROXIMATELY 1800 TO 2200 RPMS. SIT BULLETIN 1408407. *TT Read More »
-
TSB #01485
TIMING CHAIN TENSIONER BREAKPOINTS FOR SERVICE KIT OR PRODUCTION FIX. RATTLE-TYPE NOISE COMING FROM THE ENGINE AT APPROXIMATELY 1800 TO 2200 RPMS. 4.3L LU3 L35 ENGINE. *TT Read More »
-
TSB #01485B
TIMING CHAIN TENSIONER BREAKPOINTS FOR SERVICE KIT OR PRODUCTION FIX. RATTLE-TYPE NOISE COMING FROM THE ENGINE AT APPROXIMATELY 1800 TO 2200 RPMS. 4.3L LU3 L35 ENGINE. *TT Read More »
-
TSB #01119A
ROLL-OUT FOR THE GEN III SMALL BLOCK ENGINES WITH IRIDIUM SPARK PLUGS. ALSO INCLUDES 2003/2004 M/L VANS. *TT Read More »
-
TSB #01972
ERRATIC OIL PRESSURE GMT 610 OR GMT800 WITH CODES P0522 OR P0523. *TT 01972A REPLACED AND UPDATED 01/01/04. *SC Read More »
-
TSB #00700A
4.3L L35 ENGINE WIDE OPEN THROTTLE DIAGNOSTIC TROUBLE CODE (DTC) P0335, P0336, P0339. *TT *MJ Read More »
-
TSB #02088
HIGH ALTITUDE STALL WITH HOT AMBIENT TEMPERATURES. *TT Read More »
-
TSB #01353
ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT Read More »
-
TSB #3015
6.0L LQ4 VIN U ENGINE RESTRICTION. *TT Read More »
-
TSB #3018
ENGINE CYLINDER HEAD CUP PLUG COOLANT LEAK. *MJ Read More »
-
TSB #3025
04 MODEL YEAR 4.8.5.3.7.6.0 GEN III ENGINE PISTON PIN INFORMATION. *MJ Read More »
-
TSB #3088
STALL WHILE DRIVING AT HIGH ALTITUDE. ALSO A CRANK, NO START, HARD START, LACK OF POWER OR ROUGH RUNNING CONDITION UNTIL THE VEHICLE COOLS DOWN. *TT Read More »
-
TSB #3038
ENGINE TICK, RATTLE OR KNOCK NOISE AFTER CYLINDER HEAD GASKET REPLACEMENT ON THE 6.0L ENGINE. *TT Read More »
-
TSB #3055
SERVICE ENGINE SOON LIGHT WITH A P0300 MISFIRE DUE TO MISFIRES MAINLY ON CYLINDER 7. *TT Read More »
-
TSB #3058
GOODWRENCH ENGINE AND REPLACEMENT CRANKSHAFT INFORMATION. *TT Read More »
-
TSB #01275C
SOME OWNERS OF 03 G-VANS OR 04 C/K TRUCKS DRIVING AT HIGH ALTITUDE WITH WARM AMBIENT TEMPERATURES MAY COMPLAIN OF A STALL AND OR LACK OF POWER OR RUNNING ROUGH CONDITION UNTIL THE VEHICLE COOLS DOWN. Read More »
-
TSB #030603001A
STARTER CRANKS AFTER KEY IS RELEASED (NORMAL CONDITION). *TT Read More »
-
TSB #030601023
HIGHER THAN EXPECTED OIL CONSUMPTION <8500 GVW. VARIOUS MODELS INCLUDING 2003-2004 CHEVROLET KODIAK (C4500-C5500 SERIES MODELS)AND GMC TOPKICK (C4500-C5500 SERIES MODELS). *TT Read More »
-
TSB #3056
CHECK ENGINE LIGHT WITH A P0300 DUE TO 2-4 CYLINDERS MISFIRING ON THE SAME BANK OF THE ENGINE. *TT Read More »
-
TSB #3232
1999 - 2005 GEN II COLD ENGINE MISFIRE AT IDLE WITH POSSIBLE P0171 AND/OR P0174. *TT Read More »
-
TSB #3048A
SUPPLEMENT TO 03-06-01-024B 4.3L LU3 L35 TIMING CHAIN TENSIONER. RATTLE-TYPE NOISE COMING FROM THE ENGINE AT APPROXIMATELY 1800 TO 2200 RPMS. *TT Read More »
-
TSB #3691B
GENERATION III V8 ENGINE PISTON REPAIRS. *TT Read More »
-
TSB #010605003
VIBRATION OR RATTLE-TYPE NOISE COMING FROM THE EXHAUST SYSTEM AT IDLE WITH ENGINE RPMS BETWEEN 613 AND 712. *TT THIS BULLETIN REPLACED 01-06-05-003 DATED 07/01/2001. *TT Read More »
-
TSB #3048
TIMING CHAIN TENSIONER BREAKPOINTS FOR SERVICE KIT OR PRODUCTION KIT. SUPPLEMENT TO 03-06-01-024B. *TT Read More »
-
TSB #3068
OIL SEEPAGE FROM TURBO AIR CHARGE COOLER HOSES OR HOSE BLOWING OFF DURING ACCELERATION. POSSIBLE DIAGNOSTIC TROUBLE CODE P0299. *TT UPDATED 04-24-07. *KB Read More »
-
TSB #030604017I
THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. Read More »
-
TSB #PIP-4629
CHEVROLET/GMC: DIESEL ENGINE TURBO DTC P2563 OR P003A. MAY ENCOUNTER A CONCERN OF SES LIGHT, REDUCED POWER, LOW POWER. *PE Read More »
-
TSB #PIP-4629
CHEVROLET/GMC: DIESEL ENGINE TURBO DTC P2563 OR P003A. MAY ENCOUNTER A CONCERN OF SES LIGHT, REDUCED POWER, LOW POWER. *PE Read More »
-
TSB #702
COOLANT LEAK FROM THE LOWER RADIATOR HOSE. *TT Read More »
-
TSB #3375
COOLANT LEAK FROM THE LOWER RADIATOR HOSE. *TT Read More »
-
TSB #3304
UPPER RADIATOR HOSE MAY HAVE A COOLANT LEAK, BECAUSE IT HAS RUBBED THROUGH ON THE FAN SHROUD. *TT Read More »
-
TSB #050604021
REVISED INSPECTION/MAINTENANCE (I/M) EVAPORATIVE EMISSION (EVAP) SYSTEM SET PROCEDURE. *TT Read More »
-
TSB #PIP-4492P
BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. Read More »
-
TSB #PIP3343
POSSIBLE ENGINE OIL LEAK DUE TO PCV FREEZE-UP, EQUIPPED WITH THE 4.8, 5.3, 6.0, AND 6.2 V-8 ENGINES. *NJ Read More »
-
TSB #SB-12167-A
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #G-12167
12167 - SPECIAL COVERAGE. WATER AND ROAD CONTAMINATES MAY BECOME TRAPPED IN THE PROTECTIVE CONDUIT THAT COVERS THE FUEL FILLER PIPE AND MAY CAUSE THE PIPE TO CORRODE. Read More »
-
TSB #SB-12167
CHEVROLET/GMC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME TRUCKS, PIPE MAY CORRODE DUE TO ROAD CONTAMINATES AND WATER BECOMING RAPPED IN PROTECTIVE CONDUIT COVERING FUEL FILLER PIPE AND PRESENCE OF FUEL ODOR MIGHT BE OBSERVED ... Read More »
-
TSB #SB-12167
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #3280
RUST FOUND IN THE INJECTOR INLET FILTER DURING INJECTOR REPAIRS. *TT Read More »
-
TSB #3491
HIGHWAY SPEED EXCESSIVE SMOKE AND FUEL KNOCK. *TT Read More »
-
TSB #SB-11359
GM: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT- FUEL FILLER NECK CORROSION. Read More »
-
TSB #3110
ERRATIC OIL PRESSURE WITH DIAGNOSTIC TROUBLE CODE'S P0522 AND/OR P0523. *SC Read More »
-
TSB #040604065
ENGINEERING INVESTIGATION (EI #04073) HIGH, LOW OR ERRATIC OIL PRESSURE GAUGE READING SETTING DIAGNOSTIC TROUBLE CODES P0522 AND/OR P0523. 2004 ISUZU W4 ALSO INCLUDED. *TT UPDATE. *TT Read More »
-
TSB #04019
4L80E / 4L85E TRANSMISSION MAY HAVE A CONDITION IN WHICH THE TRANSMISSION OVERDRIVE GEAR SET MAY FAIL DUE TO INADEQUATE LUBRICATION AS A RESULT OF A TRANSMISSION CASTING CHANGE. CUSTOMER SATISFACTION PROGRAM BULLETIN. Read More »
-
TSB #01340B
SEIZED 2-PIECE PROPELLER SHAFT WITH THE CENTER SUPPORT BEARING PULLED OUT OF THE RUBBER. SIT BULLETIN 1400140. *TT Read More »
-
TSB #01714
THE 4L60E/4L65E AUTOMATIC TRANSMISSION MAY EXPERIENCE A LEAK, INOPERATIVE/SLIPPING IN 2ND, 3RD AND 4TH GEARS OR NO MOVEMENT (NO FORWARD OR REVERSE) DUE TO EXCESS FLUID LOSS. SIT BULLETIN 1455088. Read More »
-
TSB #01599
4L60E, 4L65E FORWARD AND LOW REVERSE WAVED STEEL CLUTCH PLATE APPEARANCE CHANGE. *TT Read More »
-
TSB #02086
4L60E, 4L65E INTERMITTENT NEUTRAL FROM A STOP OR STEADY SPEED. *TT Read More »
-
TSB #990730022A
SHIFT STABILIZATION AND TOW/HAUL MODE FEATURE FOR HYDRA-MATIC 4L60-E/4L65-E AND 4L80-E/4L85-E TRANSMISSIONS. *TT Read More »
-
TSB #3002
4L60E/4L65E INTERMITTENT NEUTRAL CONDITION WHILE ACCELERATING FROM A STOP OR WHILE DRIVING. *TT 1999-2006 GM CARS, LIGHT DUTY TRUCKS AND UTILITIES. *TT Read More »
-
TSB #3276
4L80E OUTPUT CARRIER THRUST WASHER CHANGES. *TT Read More »
-
TSB #3260
4L80E/4L85E HARSH SHIFT OR SLIP NO TCC APPLY. *TT Read More »
-
TSB #3528
REPLACEMENT TWO PIECE PROPSHAFT INFORMATION. VIBRATION WHILE DRIVING. *TT Read More »
-
TSB #3136
SLIP CONDITION IN 2ND, 3RD, OR 4TH. DAMAGED 2-4 OR 3-4 CLUTCH. *KB UPDATED 10/31/07. *NJ Read More »
-
TSB #08-07-30-015
DIAGNOSTIC INFORMATION ON MN8, MT1 SES/MIL ILLUMINATED, DTC P0757, HARSH SHIFT, DELAYED 2-3 SHIFT, 2-3 SHIFT FLARE, NO THIRD GEAR, SLIPS IN THIRD GEAR OR REVERSE. *PE Read More »
-
TSB #010730038B
THE SERVICE ENGINE SOON LAMP IS ILLUMINATED, NO 3RD AND 4TH GEAR, THE TRANSMISSION DOES NOT SHIFT CORRECTLY, THE TRANSMISSION FEELS LIKE IT SHIFTS TO NEUTRAL OR A LOSS OF DRIVE OCCURS. *TT Read More »
-
TSB #050730013
4L60-E/4L65-E AUTOMATIC TRANSMISSION SECOND GEAR START, LACK/LOSS OF POWER WHEN ACCELERATING FROM A STOP. *TT Read More »
-
TSB #08192004
TRANSMISSION SHIFT CABLE ASSEMBLY THAT MAY SEPARATE. *TT Read More »
-
TSB #00702
SLIP CONDITION IN 2ND, 3RD OR 4TH DAMAGED 2-4 BAND 3-4 CLUTCH ON THE 4L60E/4L65E AUTOMATIC TRANSMISSION. *TT *MJ Read More »
-
TSB #01626
4L60E AND 4L80E AUTOMATIC TRANSMISSION FLUID LEVEL INDICATOR (DIPSTICK) WILL NOT STAY SEATED. *MR Read More »
-
TSB #01654
SQUAWK OR GRUNT NOISE THAT OCCURS ON THE 2-3 UPSHIFT ON VEHICLES WITH 4L60E - M30, 4L60E M32 TRANSMISSION. *TT Read More »
-
TSB #030730056
4L60-E AUTOMATIC TRANSMISSION OIL PUMP FIRST AND SECOND DESIGN IDENTIFICATION. *TT Read More »
-
TSB #01432
AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT Read More »
-
TSB #3259C
4L80E, 4L85E WHINE NOISE IN FIRST AND SECOND GEAR. *TT Read More »
-
TSB #3136
THE 4L60E/4L65E AUTOMATIC TRANSMISSION SLIP CONDITION IN 2ND, 3RD, OR 4TH GEAR. ALSO TO INCLUDE THE PONTIAC GTO 2005. *TC Read More »
-
TSB #3170
HARSH 1-2 SHIFT. *EH Read More »
-
TSB #3136
SLIP CONDITION IN 2ND, 3RD, OR 4TH. DAMAGED 2-4 OR 3-4 CLUTCH. *KB UPDATED 10/31/07. *NJ Read More »
-
TSB #01483
VEHICLE HAS NO PCM (POWER TRAIN CONTROL MODULE) COMMUNICATION WITH TECH 2. SIT BULLETIN 1400427. *TT Read More »
-
TSB #020730024A
DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT Read More »
-
TSB #4070
TRANSFER CASE FRONT INPUT SHAFT SEAL IS POPPED OUT. EQUIPPED WITH (AWD). *NJ Read More »
-
TSB #040495001
REVISED WHEEL DRIVE SHAFT NUT TORQUE SPECIFICATION. *TT Read More »
-
TSB #PIP4054A
EATON LOCKING DIFFERENTIAL CHATTER SHUDDER NOISE ON TURNS, EQUIPPED WITH A LOCKING REAR DIFFERENTIAL RPO G80. *NJ UPDATED 7/17/2008. *PE Read More »
-
TSB #3001
THE SERVICE INFORMATION AND OWNERS MANUAL DO NOT SHOW A SERVICE INTERVAL FOR THE 8.6, 9.5, 9.75, 10.5, AND 11.5 INCH REAR AXLES WITH OR WITHOUT G80 (LOCKING DIFFERENTIAL). Read More »
-
TSB #3364
REAR AXLE RETAINER BUTTON BREAKAGE. *EH Read More »
-
TSB #01222A
REPEAT REAR AXLE HUB SEAL LEAK. *TT Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIP5094A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT ,WHEN TESTING ANY CIRCUIT FOR OPEN OR RESISTANCE, IT IS IMPERATIVE THAT ALL RELATED TERMINAL PIN FIT AND TENSION BE CHECKED WHEN THE TEST STEPS REQUIRE DISCONNECTION ... Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5050-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIC4935E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #3589
STABILITRAK DISABLE SWITCH IS INOPERATIVE. *TT UPDATED 2/27/08. *NJ Read More »
-
TSB #040845004
VARIOUS ELECTRICAL CONCERNS AIR BAG LIGHT ON ANTILOCK BRAKE LIGHT ON SECURITY LIGHT ON CHECK ENGINE LIGHT ON DTCS SET GAUGES INOPERATIVE. *EH Read More »
-
TSB #3089
SERVICE ENGINE SOON LIGHT AND REDUCED ENGINE POWER WITH A DIAGNOSTIC TROUBLE CODE P1516. DIAGNOSTIC TROUBLE CODES P0120, P0220, P1514, P1515, P1518 AND P2135 MAY ALSO BE PRESENT. *TT Read More »
-
TSB #3427
ADDITIONAL DIAGNOSTIC INFORMATION DTC P0757. *TT Read More »
-
TSB #3340
INSTRUMENT PANEL CLUSTER WILL NOT ILLUMINATE IN DRL MODE. *TT Read More »
-
TSB #3514
HARNESS LOCATION FOR TRAILER BRAKE INSTALLATION RPO Z82 AND/OR UY7. *TT Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #01700
STAMPING ERROR ON GENERATOR ASSEMBLY. SIT BULLETIN 1452615. *TT Read More »
-
TSB #3815
INSTALLING TRAILER WIRING HARNESS WITHOUT THE Z82 OPTION. *TT Read More »
-
TSB #07095
ENGINE COMPARTMENT FUSE BLOCK COVER ON SOME 2003-2007 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MAY BREAK WHEN THE COVER IS REMOVED, ALLOWING WATER AND ROAD CONTAMINATES TO ENTER THE FUSE BLOCK. Read More »
-
TSB #3238
PRNDL LIGHT UP WITH KEY OUT OF IGNITION AND DOOR OPEN. *EH Read More »
-
TSB #15-08-44-001H
THIS INFORMATIONAL BULLETIN PROVODES INFORMATION ON THE GM OF CANADA ONSTAR CELLULAR COMMUNICATION UPGRADE. Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #040849021
VEHICLES ORDERED WITHOUT ASHTRAY SMOKERS PACKAGE ASHTRAY AVAILABLE THROUGH SPO. *EH Read More »
-
TSB #040843004
WINDSHIELD WIPERS WON'T SHUT OFF. *EH Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #05072004
SEATBELT BUCKLE ASSEMBLY CONTAINS A LATCH WITH A BRITTLE CONDITION. *EH Read More »
-
TSB #20040130
SEAT BELT BUCKLE COMPLIANCE. *MJ Read More »
-
TSB #04025
NONCOMPLIANCE RECALL 04025 SEAT BELT BUCKLE COMPLIANCE. PRODUCT FIELD ACTION ANNOUNCEMENT. *MJ Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #030864031
MIRROR SHAKES OR VIBRATION WHILE DRIVING. *TT Read More »
-
TSB #040857006
SUNVISOR IS WET, PUDDLING WATER ON FLOOR. *TT Read More »
-
TSB #040843004
WINDSHIELD WIPERS WON'T SHUT OFF. *EH Read More »
-
TSB #040852002
RKE INTERMITTENTLY INOPERATIVE OR REDUCED TRANSMITTER RANGE. *MJ Read More »
-
TSB #070864010
VARIOUS REAR SLIDING DOOR CONDITIONS. *KB Read More »
-
TSB #3487
THE SLIDING DOOR IS HARD TO OPEN OR WILL NOT OPEN. *TT Read More »
-
TSB #060864032
SIDE CARGO DOOR IS HARD TO OPEN. INSTALL NEW HINGE PINS. *KB Read More »
-
TSB #PI-0011A
GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. Read More »
-
TSB #3051
CRUISE CONTROL AND/OR THE POWER TAKE OFF UNIT (PTO) MAY BE INOPERATIVE. *TT Read More »
-
TSB #030310002
USE OF CORRECT INSTALLATION PROCEDURE FOR LOOSE HUBCAP ASSEMBLY. THIS SERVICE BULLETIN REPLACES 030310002. *EH Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIT-5485-B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
-
TSB #050846006A
INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT Read More »
-
TSB #3050A
02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT Read More »
-
TSB #3044
GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT Read More »
-
TSB #PIT-5485-B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC5050A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #08-089
BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. Read More »
-
TSB #PIC5088F
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS. Read More »
-
TSB #040844010
NO RADIO FADE CONTROL FOR REAR SPEAKERS. *MJ Read More »
-
TSB #01864
RADIO CD SKIPS/EJECTS OR CLOCK RESETS TO 12:00. *MR *TT Read More »
-
TSB #01919
REPLACEMENT RADIO READS CAL ERROR, HAS NO AUDIO OR WILL NOT PROGRAM. *TT Read More »
-
TSB #01919A
REPLACEMENT RADIO READS CAL ERROR, HAS NO AUDIO OR WILL NOT PROGRAM. *TT Read More »
-
TSB #02060
NO AUDIO AND RADIO DISPLAY INOPERATIVE OR CLOCK RESETS. *TT Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIT5389A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #3120
ONSTAR CENTER UNABLE TO PERFORM REMOTE DIAGNOSTIC. (2004-2005 CHEVROLET YUKON, 2005 CHEVROLET TRAILBLAZER, 2002, 2003, 2005 BUICK RAINIER, 2005 CHEVROLET EXPRESS VAN, AND 2005 CADILLAC SEVILLE) *SC Read More »
-
TSB #07012004
OIL LIFE SYSTEM RESET PROCEDURES-TRUCKS. BUICK TERAZZA 2005, GMC SIERRA DENALI 2002-2003, GMC B7 CHASSIS MEDIUM DUTY 2003-2005 AND GMC 560 C-SERIES 2003-2005 *SC Read More »
-
TSB #001875
FUEL FILTER REPLACEMENT - OWNER'S MANUAL ERROR. SERVICE VME. INCLUDES 2004 CHEVROLET, GMC AND CADILLAC FULL SIZE TRUCKS/UTILITIES. *TT Read More »
-
TSB #030138019
UNDERHOOD AIR CONDITIONER RATTLE NOISE HEARD ON ACCELERATION OR A SUDDEN LOSS OF AIR CONDITIONER SYSTEM PERFORMANCE. *TT THIS BULLETIN REPLACES 03-01-38-019 DATED 11-01-2003. Read More »
-
TSB #10-00-89-017C
GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM Read More »
-
TSB #020846010E
PROGRAMMING ONSTAR MODULE FOR CANADIAN FRENCH VOICE RECOGNITION. *TT UPDATE. *TT UPDATED *EH Read More »
-
TSB #1158
STOP DELIVERY ORDER INSPECTION CLAIM SUBMISSION. ALSO INCLUDING 2004 ISUZU W-SERIES. *MR Read More »
-
TSB #1146
STOP DELIVERY ORDER ON CERTAIN VEHICLES WITH 4L80E OR 4L8E AUTOMATIC TRANSMISSION. THIS ALSO INCLUDES 2004 GMC, CHEVROLET W-MEDIUM DUTY AND ISUZU W SERIES. *TT Read More »
-
TSB #1148
STOP DELIVERY ORDER (CHEVROLET BAC 113611-114593). *MR Read More »
-
TSB #03122004
PLEASE STOP THE DELIVERY DUE TO THE LIMITATIONS OF THE GM ADMINISTRATIVE MESSAGE SYSTEM. *TT Read More »