Truck is at the Jim Gauthier GMC dealership on Mcphillips in Winnipeg, Canada. Engine endured catastrophic failure and is currently waiting for a new engine.

- Winnipeg , WY, USA

- 6.2 engine lost propulsion & warninng light on dash flashed about 3-5 times. After that the trucks engine completely malfunctioned. When this happened i was traveling at 70mhp on interstate I-69 when the the truck lost power to the engine, steering and power braking. The truck was inspected by a GM dealer and they found the engine had blown & with that it caused damage to the coolant system & to the catalytic converterin which all was replaced at full customer cost. Prior to the engine failure 2 other times it lost power and had a rough ilde and trouble starting. 1st time the dealer could not replacate the issue the next time found a camshaft postioning sensor was bad which was placed at customer cost.

- Hanson, KY, USA

I was driving with my wife about to merge into traffic on the interstate when I had a huge power loss. It was a busy part of the interstate where I could have been ran over. There was a lot of traffic and was fortunate the Semi driver was alert and slowed down. I was not aware of any failures of this motor or received any notices from GM. After conducting research I found that this was a know issue that GM failed to report. My truck has been serviced regularly and until that point had not given any signs of a upcoming failure, I have read that GM is looking into other years such as 2019 which mine is. I have had no luck with GM customer care with the only response being I need to crunch the numbers from my claim advisor. I have the 6.2 L87 motor and know of the clip failure do to poor assembly and parts and debris getting into the motor causing the failure. I am looking to report this and request any assistance available. My first stop was the dealership, then GM customer care

- Texarkana, TX, USA

Driving down the highway at approximately 65mph, when I accelerated to 70mph my truck began to shake violently flashing a check engine light, service parking brake light, and service ESC light, the engine began to violently shake and make a rough knocking noise Had the vehicle towed to the mechanic where I was informed that the lifter on cylinder 2 had collapsed and that it would be $12,500 to replace all 16 lifters as well as the cam shaft on my engine My safety was at risk as my truck went into a -??limp-?? mode and essentially shut off on the side of the road, others were at risk due to my truck becoming a hazard, the tow operator was at risk having to pickup my truck on the side of a 70mph freeway The only check engine code I had was a misfire on cylinder 2 Dealership stated that it was a known issue but that my truck was outside of warranty, and not apart of recall so there was nothing they could do Had truck towed to different shop that is repairing the problem Requested that all parts be kept in case of inspection request

- Knightdale, NC, USA

My 2019 GMC Sierra Denali shut off suddenly while I was stopped in traffic. The engine died, the steering wheel locked, and the dashboard displayed warning messages including -??ESC, -?? -??power, -?? and another I didn-??t catch. The truck would not restart despite attempts. The check engine light is now on. This happened without warning, and I had no prior mechanical issues. The vehicle is well maintained, garage-kept, and recently received a full service including oil change, brake work, and 75K-mile recommended service. I fear this is related to a known issue affecting other GMC engines under investigation for sudden power loss.

- Millersville, MD, USA

There is a common lifter failure issue with the 5.3 V8 engine in these vehicles and local mechanics I've spoken too are very aware. The 6.2L was recalled for the same reason. GM would not honor or cover any of this as it was "out of warranty", however, I strongly feel this should be investigated.

- Clayton, DE, USA

The engine failed and needs full replacement. Known GM issue with lifters. Engine style 6.2L. We contacted GM and they are not responsive and they provided a claim number. To repair is over 9,000$ and I still owe about 7000$ and the truck was purchased brand new. GM cannot furnish a replacement engine. The dealer showed 34 in stock when ordered. The dealer contacted us later stating GM canceled the order and they do not have an ETA when they can send an engine for the vehicle. We are paying on a vehicle that is stuck at dealer and cannot be repaired.

- Maurice, LA, USA

I had a 2019 GMC Sierra with a 6.2L gas engine. The engine failed while I was driving on the highway at 65 mph. The truck began shaking badly, check engine light and all kinds of warning lights came on. I pulled over and drove slowly 10 miles to a GM dealer who then told me that I should not be driving the truck due to safety concerns and it could lose power and lead to an accident. I had it towed back to my home town ($500 later) to the GMC dealer where I purchased the truck. They told me the same thing, it could not be driven. GM has since recalled vehicles with this same 6.2L engine manufactured in model years 2021-2024. I believe that recall should have included my 2019 truck. I was at risk of serious injury or death due to engine failure, fortunately I did not crash. However, I lost $14,000 in value of the truck thanks to the faulty engine. I believe the recall should be expanded and I should be compensated by GM for the engine failure. I have attached the estimate for the repair.

- Lees Summit, MO, USA

I am reporting a serious mechanical and safety issue with my 2019 GMC Sierra 1500 (5.3L engine). The truck began misfiring, running rough, and would frequently -??jump-?? and shut off while driving -?" creating an unsafe situation on the road. We attempted several repairs to resolve the issue: -??Transmission flush -??Replaced the intake manifold gasket -??Replaced all eight fuel injectors -??Inspected all ignition coils -??Replaced faulty sensors The vehicle repeatedly showed a Cylinder 8 misfire, even after these repairs. Eventually, it was diagnosed that both the lifters and camshaft are bad, and the engine now needs a full replacement. This is extremely concerning because the truck has only about 47,000 miles on it. We brought it to the dealership in September 2024, while it was still under warranty, and told them it wasn-??t running right. The dealership said there was nothing wrong. Now that the warranty has expired, GM is refusing to help with any repairs. This appears to be a manufacturing defect that was not properly diagnosed while under warranty. Engine failure at such low mileage, especially with early warning signs and repeated diagnostic errors, should be investigated as a serious reliability and safety concern.

- Mcminnville, OR, USA

The engine lifters failed with out notice twice. Upon inspection of the vehicle it was determined that there was no issues that contributed to this failure. I paid to have the problem fixed within a year the same problem happend again. I was on the expressway and my car just shut off with out warning while cruising at expressway speeds and refused to cut back on for about 2 hrs.

- Lynwood, IL, USA

Since I bought the truck, it has had transmission problems. The truck will violently jerk forward between Park - 1st - 2nd gears (up and down) pretty frequently. The dealership denied being able to recreate the issue and nothing was wrong. After dropping the vehicle off a few times, the dealer service dept said they recreated the problem and replace the torque converter. It did not work and the service dept manager told me that they knew about the problem the whole time but were instructed by General Motors to not attempt to fix the issue. I called GM Company and a supervisor eventually admitted to knowing of the transmission and engine issues all along but the GM engineers have not found a solution yet but they are working very hard to figure it out. Since those calls, my lemon law claim with BBB Auto was approved, but suddenly denied with no explanation. Following that, the #2 lifter failed and damaged the cam shaft. All were replaced and that was at 70,000 miles. The transmission has not been fixed.

- Metairie , LA, USA

The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed and slowing down to stop, the vehicle suddenly shut off and failed to restart. The vehicle was eventually towed to the residence. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The contact was informed of the NHTSA Action Number: PE25001 (ENGINE, ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the NHTSA Action Number. The failure mileage was 115,000.

- Albany, GA, USA

I was driving down the road no lights on the dash, when suddenly the dash lit up saying shift to park to restart. Ended up having to hurry and shift to neutral in order for the vehicle to not cause an wreck and coasted into parking lot. I tried to restart my truck and engine would not start. Had it towed to a dealership and lifters had ate through the cam shaft. Luckily I had an extended warranty and only had to pay a deductible for a new engine. They put a new engine in and I already have a rattle coming from it with less then 10,000 miles on it.

- Taft, TN, USA

My engine suffered a catastrophic failure, at 139468 miles. 2019 GMC Sierra Denali 1500. I had the engine replaced with a new engine date June 2024 GMC 6.2 engine failures is happening with more than just 21-24 models years.

- Knoxville, TN, USA

I am writing to formally document an ongoing and serious issue with our 2019 GMC Sierra 1500 (VIN: [XXX] ), which I strongly believe may be related to the current GM recall involving L87 V8 engines-?"despite my vehicle not yet being included. Early last year, our family experienced a sudden and frightening loss of power while driving at full speed on a curve, with our children and their car seats secured in the back. The vehicle lost power abruptly, accompanied by a loud ticking noise from the engine. This incident could have easily led to a serious accident and was terrifying for all of us. Since that time, the truck has spent more than half the year in and out of repair shops. The initial repair estimate was nearly $20,000-?"unmanageable for us, especially since the vehicle is paid off. Fortunately, a family friend was able to repair it for significantly less, but the problems have persisted. Most recently, the check engine light returned and we experienced another episode of reduced power, suggesting an unresolved or recurring failure likely tied to internal engine components such as the long block, crankshaft, connecting rods, timing chain, or camshaft. This truck is essential for our family-??s daily life-?"including commuting to work and school, and especially out-of-town travel. Our other vehicle, a 2007 Honda Accord, is much smaller and insufficient for our growing family. This ongoing issue has caused substantial disruption, stress, and financial strain. It has also delayed our ability to upgrade to a larger family vehicle, something we had planned and budgeted for before this ordeal. Given the severity and duration of the issue-?"and its apparent connection to the same engine problems affecting newer models-?"we want to ensure this situation is documented with the NHTSA and GM. We sincerely hope that the scope of the current recall will be expanded, and that appropriate relief or support will be offered to affected vehicle owners like us. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.

- Chandler, TX, USA

I was driving on the highway at 60mph and the engine shut off. I was fortunate enough to be able to get the truck off the road without incident. The instruments instructed me to try to start the vehicle again. Upon doing so the engine made very loud and erratic knocking noises and I shut it off. I towed the truck to the GMC dealership where they told me the engine had thrown 2 rod bearings. They told me this was VERY common with the 6.2L engine. The truck was extremely well maintained with all services at the dealership, and only had 70,000 miles on it. GM quoted me $15,436 to replace the engine. I did open a case with GM when the incident occurred. Case # [XXX]

- Bluffton, SC, USA

I-??m contacting you regarding my 2019 GMC Sierra 1500 with the 5.3L V8 engine. The vehicle is currently experiencing a cylinder 8 misfire (code P0308), accompanied by engine backfiring, ticking noise, and exhaust fumes inside the cabin. Additionally, the ESC (Electronic Stability Control) warning light is on, and performance is noticeably affected. To date, I have: -??Replaced all spark plugs and fuel injectors -??Verified proper ignition coil function -??Had an oil change on September 23, 2024, during which I reported early concerns about engine performance (shortly after the powertrain warranty expired) -??Had a transmission flush on March 17, 2025, in an attempt to resolve continued drivability issues Despite these efforts, the issue persists. Given the known issues with AFM lifters and camshaft wear on this engine, I suspect a mechanical failure related to that system.

- Mcminnville, OR, USA

2019 GMC SIERRA 1500 AT4 2019 VIN: [XXX] On 10/31/2023 the transmission was replaced at Mileage: 72,875. The transmission at Jim Ellis Buick, GMC, after the truck would not drive over 40 miles in speeded. 12/23/23, 86788215, Engine Oil Cooler Hose had to be changed. Truck had to be towed from a public parking lot to the mechanic. The engine is burning oil, the warning messages say add oil, I have been adding oil once a month 1 quart. The steering wheel was locked and the truck had to be towed from a public parking lot to the mechanic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Mableton, GA, USA

2019 GMC Sierra AT4 with 6.2L engine failed while driving 45 mph. No warnings and no check engine lights prior to engine failure. Coasted off the road, engine would not restart. Upon attempted restart the check engine light came on showing code P0016 for crankshaft/camshaft position sensor. Towed vehicle to dealership where engine replacement was required.

- Columbia, MO, USA

Just purchased this vehicle, at 84000 miles had engine failure and electrical issues while traveling down interstate with my family. Lost power steering and all warning lights popped up. Safely exited busy interstate -- avoided major accident. This engine should have been included in the recent GMC recall - After a diagnostic $7000 plus to fix. UNSAFE ENGINE ISSUE!! Please help the consumer!!

- Branchville, SC, USA