1997 Hyundai Sonata
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1997 Sonata are official communications between Hyundai & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #20-SS-001H
This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years. Read More »
-
TSB #21-BR-002H
This bulletin provides best practice recommendations when performing brake service procedures. Read More »
-
TSB #20-BR-002H
This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area. Read More »
-
TSB #9850002
SPECIFICATION ON REAR BRAKE DISC MINIMUM THICKNESS. *YC Read More »
-
TSB #TSB-11-BR-002
HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM Read More »
-
TSB #21-EM-004H
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required ... Read More »
-
TSB #21-EM-003H
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. Read More »
-
TSB #0236030
OBD-II READINESS TEST DRIVE CYCLE. *TT Read More »
-
TSB #97110120013
DESCRIPTION AND INFORMATION ON A NEW FRONT CASE. *YC Read More »
-
TSB #97110120014
PROVIDED PROCEDURES FOR THE INSTALLATION OF A BLOCK HEATER. *YC Read More »
-
TSB #97100120012
SHOP MANUAL CORRECTION ON CYLINDER HEAD BOLT TORQUE SPECIFICATION. *YC Read More »
-
TSB #97090136003
SUBJECT PERTAINING TO THE CRANKSHAFT AND CAMSHAFT POSITION SENSOR LOCATION. *YC Read More »
-
TSB #97090120009
INSTALLATION INSTRUCTIONS ON BLOCK HEATER. *YC Read More »
-
TSB #133
PRE-CONDITIONS FOR READINESS MONITORS. *TT Read More »
-
TSB #0636006
EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *KB Read More »
-
TSB #117
INFORMATION ON EXHAUST GAS RECIRCULATION. *SLC Read More »
-
TSB #9836009
INFORMATION ON FUEL INJECTOR CONFIGURATION. *YC Read More »
-
TSB #21-AT-006H
Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. Read More »
-
TSB #20-AT-016H
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
-
TSB #97100140032
INFORMATION REGARDING END CLUTCH RETAINER AND CLUTCH PLATE MODIFICATION. *YC Read More »
-
TSB #5NP-S9D9P-10
THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). Read More »
-
TSB #9840003
VEHICLES MAY EXHIBIT A HARSH 3-2 DOWNSHIFT. *YC Read More »
-
TSB #9790002
ATM 3RD TO 4TH GEAR UPSHIFT DELAY DURING CRUISE CONTROL OPERATION. *TW Read More »
-
TSB #97090140029
THROTTLE POSITION SENSOR AND IDLE SWITCH ADJUSTMENT PROCEDURE. *YC Read More »
-
TSB #20-EE-003H
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days. Read More »
-
TSB #20-BE-001H
This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. Read More »
-
TSB #9936004
SUBJECT PERTAINING TO ( ELECTRICAL TROUBLESHOOTING MANUAL ) ETM CORRECTION FOR GROUND DISTRIBUTION . *TT Read More »
-
TSB #9806-9836004
SHOP MANUAL ON DOHC SPARK PLUG WIRE ROUTING. *YC Read More »
-
TSB #20-BD-014H
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
-
TSB #23-BD-002H
This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
-
TSB #9701998
RECALL 97V-026 - THE WINDSHIELD WIPER MOTOR THERMAL SWITCH CIRCUIT CONTACT POINTS MUST BE CLEANED ON CERTAIN HYUNDAI VEHICLES WHICH FALL INTO THE FOLLOWING PRODUTION RANGES TO CORRECT A POSSIBLE INTERMITTENT INTERRUPTION OF WIPER ... Read More »
-
TSB #9890005
SUBJECT ON AIRBAG REPAIR KIT PART NUMBERS. *TT Read More »
-
TSB #9880005
VEHICLES MAY EXPERIENCE A WIND NOISE IN THE AREA AROUND THE RIGHT Read More »
-
TSB #97110160006
SERVICE PROCEDURE AND INSTALLATION OF THE TRUNK MOUNTED SPOILER. *YC Read More »
-
TSB #97110160007
INFORMATION ON TORSION BARS, GAS STRUTS AND CHMSL. *YC Read More »
-
TSB #97110199004
VARIOUS INFORMATION ON PROPER CARE FOR VEHICLE EXTERIORS AND CORRECTIVE STEPS FOR ENVIRONMENTAL DAMAGE. *YC Read More »
-
TSB #20-SS-004H
This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. Read More »
-
TSB #20-SS-002H(1)
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. Read More »
-
TSB #20-SS-004H
This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. Read More »
-
TSB #20-SS-002H(1)
This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. Read More »
-
TSB #19-BE-011H-1
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. Read More »
-
TSB #19-BE-011H-1
The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. Read More »
-
TSB #21-EM-004H
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required ... Read More »
-
TSB #21-BR-002H
This bulletin provides best practice recommendations when performing brake service procedures. Read More »
-
TSB #21-EM-003H
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. Read More »
-
TSB #20-BD-014H
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
-
TSB #20-BD-007H-1
This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products. Read More »
-
TSB #20-EE-003H
This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days. Read More »
-
TSB #9790005
AUDIO SYSTEM CONNECTOR REPLACEMENT. *TW Read More »
-
TSB #20-AT-016H
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
-
TSB #21-BR-002H
This bulletin provides best practice recommendations when performing brake service procedures. Read More »
-
TSB #20-BD-014H
This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. Read More »
-
TSB #20-AT-016H
The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: Read More »
-
TSB #20-BD-007H
This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products. Read More »
-
TSB #19-GI-006H
This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Read More »
-
TSB #0290009
SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG Read More »
-
TSB #9880007
INSTALLATION PROCEDURES ON WOOD INTERIOR TRIM. *YC Read More »
-
TSB #9730002
IDLE SPEED CONTROL ACTUATOR (SHOP MANUAL CORRECTION). *TW Read More »
-
TSB #9720002
THE CYLINDER HEAD TORQUE SEQUENCE FOR IN-LINE 4 CYLINDER ENGINES NOTED IN THE LISTED SHOP MANUALS IS INCORRECT. *JD Read More »