The contact owns a 2006 Hyundai Sonata. While driving at 15 mph, the ABS indicator illuminated. The contact maneuvered the vehicle to the side of the road where it was discovered that the rear driver side tire was outwards. The contact stated that the tire was able to be adjusted back into place, but was not safe to drive. The vehicle was towed back to the contacts residence. The vehicle was not diagnosed or repaired. The vehicle was serviced under NHTSA campaign number: 13V354000 (suspension); however, the failure recurred. The contact stated that the dealer did not repair the cross member assembly and only sprayed the cross member with a coating. The manufacturer was not made aware of the failure. The failure mileage was 220,000.

- Jacobsburg, OH, USA

On 17 August 2015, I was driving my 2006 Hyundai Sonata at 75 mph in the left lane of I-64 near nitro, wv. As I passed a tractor trailer while entering a slight curve to the left, without warning my car violently fishtailed causing the rear end of my car to momentarily go under the tractor trailer while my front end was headed toward a four foot high concrete median. By the grace of god I was able to steer out of the situation without hitting either the truck or the wall. Corrosion of the steel cross member in the rear end caused the left rear control arm to detach suddenly. I had the vehicle towed to the local Hyundai dealer where I had previous routine maintenance and recall work performed. Later that evening I researched the NHTSA site for recalls on my vehicle and found the following notice which I had not received: Report receipt date: Aug 12, 2013 NHTSA campaign number: 13V354000 component(s): Suspension when I questioned the service personnel as to why I did not receive the notice, their records showed my vehicle as registered to the original owner. I purchased the vehicle in 2007. There appears to be gross negligence on the part of both the dealer and Hyundai in not informing me of this recall. As stated above, the dealer had performed recall work on my vehicle while it was in their shop for routine maintenance over the past 3.5 years.

- Hurricane, WV, USA

Problems with right control arm and from strut mounts. Thump noise when bumps are there. Initially, the dealer said everything looks fine. I asked them to check thoroughly and they said that problem with right front lower control arm. The dealer reported that it cost around $1220 to repair. I am concerned about the safety me and my family. A similar recall has been done (number 113). It is too expensive to hear with no fault of ours. The Hyundai need to take care of it. It still makes a noise under hood.

- Lubbock, TX, USA

Car has started making clunking sound from rear end of car. Took to an auto mechanic replaced struts wheel bearings has spent hours on trying to find noise, even to the point of riding in the trunk for 15 blocks.very concerned this could lead to something bad.

- Blueeye, MO, USA

At 110,615 mileage on car had installed link assy fr stabilizer, bush-stabilizer, link assy-fr stabilizer, joint assy-cv LH and washer-inr also replaced: Lf cv axle shaft and swaybar linkages and bushings. Above was due to clunk type noise front when turning both direction:they found swaybars bushings worn and swaybar linkages had excessive play causing knocking type noise. They also mentioned something was rusted? not sure, as they did not note that verbal comment on service report. Since I had this car brought in at 99,000 miles for a complete warranty check and was told all was good and I have had all my maintenance done at the dealership repairs were a onetime goodwill repair. Now my car is brought back in at 111,000 due to a clunking, knocking in the back! seems to happen when at 20-30mph and breaking. Car has been with the dealer since May 21, 2014 today is May 26, 2014 and they still do not know what is wrong.

- New Port Richey, FL, USA

The contact owns a 2006 Hyundai Sonata. The contact stated that he was notified while NHTSA recall campaign number 13V354000 (suspension ) repair was being performed that the front engine support had deteriorated. The dealer also stated that the front engine support needed to be replaced in order to repair the vehicle. The vehicle was not repaired. The manufacturer was not notified of the defect. The approximate failure mileage was 86,586.

- Rexford, NY, USA

Had to replace front tie rods and bottom plate holding right front strut. Part failed again and replaced the plate and strut a year later. Still, problem of rough ride on any bump, crack or rut in the street occurs. Appears that front suspension is non-existent except on smooth streets and freeway. Hate driving this car. Only has 68,000 miles on it now.

- Arlington, TX, USA

The contact owns a 2006 Hyundai Sonata. The contact received notification of NHTSA campaign number: 13V354000 (suspension) the contact stated she was concerned to drive the vehicle. The manufacturer was made aware of the problem. The VIN was not available. The contact had not experienced a failure.

- Wintersville, OH, USA

The contact owns a 2006 Hyundai Sonata. The contact stated that there was an abnormal vibration in the vehicle when driving various speeds. The vehicle was repaired under NHTSA campaign number: 13V354000 (suspension) but to no avail. In addition, the air bag warning light was illuminated. The vehicle was taken to a dealer where the technician was unable to diagnose the problem. The manufacturer was made aware of the problem. The approximate failure mileage was 70,000.

- Houston, TX, USA

The contact owns a 2006 Hyundai Sonata. The contact stated that a loud noise was heard from the front end of the vehicle while driving an unknown speed. The vehicle was taken to the dealer for inspection where the failure was located at the front lower control arm, which was severely corroded. The lower control arm was replaced. The failure and current mileage was 159,000.

- Park Forest , IL, USA

This vehicle was taken to the authorized service center of Hyundai on October 29,2013 for the safety recalls received from Hyundai motor America (NHTSA campaign number 13V-354 and failure of OCS recall by NHTSA).since the service personnel insisted to do 70,000 mile service I agreed and after 1 hour he called me and said there is a leak in the radiator hose. This car has always been serviced by authorized Hyundai service centers and always had persistent problems like oil leaks (changed gaskets (paid$400), power steering leaks (paid $300), brake rotors problems which I had to pay $1300 to replace at 30,000 miles etc etc.this car comes with 10 year/100,000 bumper to bumper warranty that is fake.I had also paid ($1200) for an extended coverage for this vehicle when I bought this brand new. But Hyundai did not honor it since it was a dealer package and that dealer no more exist. On October 29,2013 after the recall service I paid $400 since the service manager said he did all that is urgent for this car. Next day morning I found my car in a pool of multiple fluids.I decided to take it back to the Hyundai dealer, but on the way the car was engulfed in smoke. I pulled over to the gas station which had a work shop, found that no coolant in the car. They filled the coolant and put a new clamp on the hose which was loose. I made a complaint to the Hyundai motor America after 2 days. Case number is 6156086. Since then I escalated the case calling them several times, but no reasonable effort from there side to help me. On November 13, the car again burned and got engulfed in huge smoke when my wife was parking in the drive way after returning from work. (I have the video on my cell phone). Again I called Hyundai America and they told me to contact the dealer. I called the dealer (Hyundai of paramus) and they said the service manager will call back. But never did.

- Bergenfield, NJ, USA

Back when I purchased this 2006 Sonata I went back in airbag light was on the car was in less than ten minutes dealer said all set and I went in to a local garage for inspection but the car legally shouldn't pass inspection due to said airbag issue and the gentleman put it through but said airbags will not deploy due to the fuse was pulled put one in been on since and it is all over Hyundai forum same problem/2 my front suspension is rattling bad and come to find out same thing on Hyundai forum they always don't know what this noise is/3 my check engine light on code search says evap leak but need 2 say yes its not fuel cap this is a known Sonata problem fuel tank is plastic and there is a part in top that is metal rust out and causes fuel tank to crack this part alone is 1500 plus labor these cars are lemons will not buy another one this is all in 2 yrs of owning not counting there was a recall I just had done but never got notice on any prior to his I want to see all that were supposedly done thanks very dis satisfied customer.

- Coventry, RI, USA

2006 Hyundai Sonata. Consumer writes in regards to vehicle front control arms recall notice. The consumer was informed the control arms needed to be replaced, due to the fact the bushings were starting to separate. The consumer asked about the cause, and the dealer stated it was due to wear and tear. The consumer began to research the issue, and discovered a recall was issued for the front control arms. The consumer filed a complaint and Hyundai responded by saying they did not show any open campaigns on his vehicle. In October 2013, the consumer received a recall # 13V354000 which outlined an issue with corrosion that could result in detachment of the inboard control arm mounting points. As a result of the notice, he contacted the dealer and was told, it appeared to be related and that it would be fixed at no cost. Consequently, when he call the Hyundai dealership and was told the issue identified in the notice and his issue with the bushings that were starting to separate were two different issues and that the initial issue would not be a part of the recall. The consumer stated the only thing the dealer did, was add a corrosion kit under-coating aero and rust preventive V. the service department informed the consumer, they were not replacing the cross-member on any vehicles, they were merely using some kind of protectant to prevent further corrosion.

- Montgomery Village, MD, USA

Upper control arms failed & were replaced 9/27/2012. This required another dealer alignment. Front tires then wore out 6,200 miles later. Tires wore down to metal belt core; could have easily blown out. I had 3 previous dealer alignments and was told by dealer in April 2013 there is no more camber/caster adjustment possible, my car is "out of specs", that I need a $650 aftermarket camber adjustment kit. Dealer told me to rotate tires every 3,500 miles which is much sooner then the factory recommended 7,500 miles. I was told tires will lose 50% or more of tread life. My April 17, 2013 dealer alignment failed, could not be done. I had dealer alignments Sept 26, 2012 (with new upper control arms), Jan 22, 2010, July 29, 2010, July 29, 2009. I have good photos of the severe tire damage, steel belting clearly visible. I am original owner and have detailed repair records from the dealer.

- Moreno Valley, CA, USA

Noticed a shimmy vibration louder than normal while driving to work on highway, upon exiting on main road heard very loud thump bang on left rear drivers side. I assumed it was a blow out as I couldn't steer the car (pulling to right) but managed to make into parking lot off the main. Upon inspection left rear tire still on car not flat, but on a total slant approx 45 degree. I was very glad to be off highway however still this is a major safety issue. After towing to garage, mechanic called me later and said the entire rear sub-frame rotted and broke from car needing to replace everything suspension sub-frame, including control arms, and would need an alignment, he also said that's why my tires wore down quicker than usual due to suspension issue. I didn't contact dealer since car no longer on warranty, after checking the internet for used parts (could not afford new parts as mechanic's estimate was already at the $1800 mark) was surprised to see the hundreds of complaints already posted with this same issue. I did repair the car with a total bill (used/recycled parts) for $1567. I still did not feel safe driving this car. Why would it take so long to have a recall...it is obvious this is a defect which could cause serious crash, fatality serious injury and should be covered by Hyundai for repair or full reimbursement.

- Fishkill, NY, USA

The contact owns a 2006 Hyundai Sonata. The contact stated that while driving 30 mph, the vehicle fishtailed as the electronic stability control warning lamp illuminated. The vehicle was repaired and was diagnosed as having a rusted rear driver's side control arm. The manufacturer was made aware of the issue. The approximate failure mileage was 156,000 and the current approximate failure mileage was 158,000.

- Underhill , VT, USA

Driving home one night car pulled to the left tire almost was off the car thank goodness that I was not traveling fast and not on a highway and my children were not in the car. Find out that my cross member in the rear of my car had snapped now this is a car that is garage kept and to the car dealer that I had bought it from brand new and suppose to check it with a 10 point system everytime I get the coupon in the mail which is about every 4 - 6 months was never seen the crack from reading the internet this is not the 1 St car to do this. Please try to get this problem corrected. Please make this car safer before someone gets killed thank you !

- Aliquippa, PA, USA

Earlier in the day when I was driving with my nephew and sister, the ESC light came on. The next time I drove it, the light did not come on and was not on at the time of this incident. I was driving in my neighborhood, turning a corner, when I heard a loud clunk from the driver rear side. I stopped and saw a large rusty metal piece had detached from the frame on that side and was dragging on the road, the wheel was tipped out wobbly. I knew it could not be driven. I called aaa and had it towed to a local garage. Due to holiday weekend, my husband saw the mechanic on Monday 7/8/13, who diagnosed it as a rear subframe corrosion and failure. He advised us to check for a recall as he was familiar with a prior front frame recall a few years ago. He had other repairs ahead of us, so we had it towed to our mechanic 15 miles away. When our mechanic got it on the lift we were told the damage was very severe: The rear end was rotted, needing removal/replacement of rear crossmember, 2 upper and 2 lower arms, L/R upper control arm and joint, with rear shocks and mounts, and alignment.we called Hyundai regional office, opened case # 5870260. The agent reported no recalls and this was not under warranty, but he stated he was "very familiar" with this type of problem in other years and models. He advised contacting the dealership, as they may be able to do something. (herb chambers of auburn, MA.) the service manager at the dealership advised us to have it towed to them at our expense (40mi.) his lack of empathy and telling us that Hyundai would take little or no responsibility for repairs, outside of a recall, prompted us to have our mechanic do the work. Repairs were done with Hyundai factory parts, ($2,640 including labor). We are convinced that the vehicle has a defect which could have caused a crash, serious injury, and/or death had it happened in any other circumstance.

- West Brookfield, MA, USA

I went to a sears auto center back in December 2012 to get an alignment. In the first week of May 2013, I went back to sears to have my alignment rechecked because I was experiencing shaking while braking. They told me my rear brake shoes were corroded and falling apart and I needed to change them, along with getting new rotors and brake pads. After have these parts installed, the mechanic called me over regarding my alignment and said the rear suspension frame was corroded and rusted in 2 places, causing the tow to go out of alignment. They said I needed to either replace the whole subframe or have a steel beam welded to it for stability so they could get the correct alignment specs. If I didn't fix it, the alignment would always be off. They also warned me that if I traveled with my vehicle long distance, the frame could break where the corrosion occurred, causing an accident. 2 weeks ago, I was driving at about 35 mph in my neighborhood when my steering wheel listed to the left about 45 degrees and my rear wheels started to lean in. The driver's side rear wheel was also turned outwards which caused the car to fishtail and swerve uncontrollably during driving. I felt very unsafe and my car has been parked in my driveway since until I can get it towed to a repair shop.

- Schenectady, NY, USA

While driving home from the grocery store, my ESC light came on. Had trouble steering the car and there was a squealing noise coming from the back end. I was informed by my mechanic that the problem is that the rear axle housing is cracked/rusted and that the wheel is crooked. The car is currently undriveable. I had read in the paper about rust causing problems with the rear suspension control arms and believe that I am experiencing the same problem. I contacted the Hyundai dealership where the car was purchased to see if this would be covered under the 100,000 mile drivetrain warranty (car has approx. 80,000 miles on it), but was told that they weren't sure. I have an appointment scheduled for repair, but will not be able to have it done, unless it is covered.

- Springbrook Township, PA, USA