When filling the gas tank, gas will squirt out before the nozzle can shut off. There appears to be a defect with the gas tank that causes air to not vent properly during the filling process. This air builds up pressure until it pushes gas back out the filler tube potentially onto the person filling the tank, down the outside of the vehicle and onto the ground. Not only a safety issue but an environmental one that many others have also reported.

- Hastings, MN, USA

The fuel tank began to have a problem with overflowing when refueling. It is nearly impossible to fill the tank without gas pouring out of the vehicle. I am concerned about the potential fire hazard.

- Moscow, ID, USA

The gas tank spews out fuel when you let it fill.

- Novi, MI, USA

My 2006 Jeep Liberty has a defective gas tank. When filling the tank completely full, the fuel pump nozzle will shut off only to have gasoline come pouring out of the tank onto me, my clothes, the outside of the vehicle, and all over the ground. After investigating the problem, it turns out I'm not the only one with this problem. Jeep should be held responsible for installing gas tanks that are deemed to fail. The cost of this gas tank alone, quoted by the dealership is $1400, and the filler line is an additional $300. This is ridiculous. Engine problems are one thing, parts due wear over time and this is understandable. But to have a gas tank that is potentially dangerous by spewing gasoline at consumers and being an environmental hazard is not acceptable. And Chrysler/Dodge/Jeep not taking responsibility for their faulty manufacturing is not acceptable. And lets not forget that the government spent millions of dollars to bale them out, which turns out to be taxpayers money, our money, and they won't stand by their products. Shame on you!! looks like I'll be purchasing a Toyota fj cruiser instead of an american made classic in the future. Thanks for nothing Jeep

- New London, WI, USA

Gas tank overflows when fueling because it doesn't sense when its full. I have to stop fueling before I think its full so this doesn't happen, so I am unable to fill tank completely. Spills all over my clothes, on the ground and down the side of my vehicle. Also I smell an electrical burning smell when I'm driving my vehicle sometimes which is very scary.

- Reynoldsville, PA, USA

Last year around Aug 2011 my key stuck in the key slot couldn't even get it out had after a while figured out if U push the brake all the way in then put in park then sometimes the key would come out started workin after about 2 to 3months later then on Feb 27 12 it started 2 stick again then it wouldn't start we called Chrysler. They told us 2 have it hauled 2 some where 2 have it checked its at lee auto in aurbon Maine they we are now paying 200$ and they have not figured out what it is -Chrysler, gave us a case num [xxx] and they told my husband if it is a faulty part they might help pay for it. Its has only 72000 2 74000 miles on it we had 2 put a new fuel pump in it already in 2011-I think we got the lemon right now I have 2 really on some one 2 give me a ride 2 work oya we all so went through a set of tire 1 year after alignment. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Lisbon, ME, USA

When filling the gas tank, I let the pump shut off by itself. When the pump shuts off, a few ounces of gasoline spill on the ground. This happens consistently.

- Algonquin, IL, USA

The contact owns a 2006 Jeep Liberty. The contact stated that when refueling, fuel would overflow and spew from the filler neck. The fuel tank could not be filled to capacity and the failure was a frequent occurrence. The dealer was contacted and a claim was filed. The vehicle was neither diagnosed nor repaired. The failure mileage was 40,000 and the current mileage was 103,000.

- Goldens Bridge , NY, USA

When filling up the tank at the gas station the tank has overflowed quite a bit of gasoline onto the ground as the pump stops. This has happened on several different occasions at several different filling stations.

- Keene, NH, USA

When filling fuel tank, gas overflows out the filler tube. It does this know matter how you fill the tank_man. Or auto.

- Erie, PA, USA

When filling the gas tank, the gas pump clicks like the tank is full then it starts overflowing.

- Daphne, AL, USA

My Liberty started having fuel spill problems about a month ago. Now, every time I fill the tank, the pump doesn't 'click off' fast enough and there is an overflow (~1/4 gallon) of gasoline. This has happened at every gas station I've tried lately.

- Beavercreek, OH, USA

The contact owns a 2006 Jeep Liberty. The contact stated when refueling the vehicle, fuel spilled on him and the vehicle. The dealer was notified and stated there were no recalls. The manufacturer also confirmed there were no recalls and advised the contact to take the vehicle to the dealer for inspection. The vehicle was not repaired. The failure mileage was 78,000 and the current mileage was 98,000.

- Berlin, PA, USA

On each fill up, gasoline shoots out of the nozzle receptor. This occurs with the operator holding the handle in or with the latch pushed down to hold the handle down. Approximately a quarter cup of fuel shoots out of the tank upon overfill. I have called several dealers and the dealer insists the tank has been compromised by "ethanol based" fuels. I have never filled up with anything but 87 octane. The dealer wants me to pay $5000 for a new gas tank. This occurs at every gas station and I have tried to fill the tank on the slowest setting. Neither method helps the overfilling. This is not only a safety concern for me, but an environmental hazard.

- Pickerington, OH, USA

Gas overflows every time I fill up. I have not caught on fire yet, but I worry for me and my children.

- Denver, CO, USA

I purchased a used Jeep in Wisconsin that does not follow NHTSA or epa standards. The Jeep overflows when filling the gas tank and spills gas on the ground at every gas station. This is a common issue with Jeep and needs to be recalled. It often requires replacement of the fuel tank or lines. My car is not under warranty since it was purchased used. I am extremely concerned of fire, pollution and my wife's safety with this hazardous issue.

- Milwaukee, WI, USA

Hi, I have owned this Jeep Liberty since 2008 and bought it with 2700 miles on it. The problem I have and many others have is with the filler neck on the fuel tank. It overflows gas every time you fill. Even if I slow it at the approx time the meter says it should be getting full. The internet research shows that the new gas tank assembly from Jeep has a new/fixed safety valve in the filler neck that is supposed to help with a rollover accident but apparently slaps shut when filling causing the gas puke on clothes, shoes, ground, etc. It is not good for the environment, pocket book, or other people at the gas station as spilled gas is a significant safety concern. It is a chronic failure and Jeep should do something. Sell part at loss/severe discount, replace for free would be nice, acknowledge the problem is a big issue and stand up and fix it even though it is not the classic, "this causes accidents and we better do something so we don't get sued" type of safety recall. Thanks in advance for the help.

- Savona, NY, USA

After viewing some recommendations online about Jeep Liberty crd vehicle fires I decided to check the component listed as having possible issues on my vehicle. The electrical connection for the fuel heater located on the fuel filter assembly was in fact scorched and soaked through with diesel. A fire has not occurred, however I am seriously concerned that it could and that there is not a mandatory recall on this product. I have left the connection unplugged but winter is coming and I live in an area where that heater is necessary.

- Minden, NV, USA

2006 Jeep Liberty gas shut off valve does not engage and gas overflows upon filling up gas tank. Has happened everytime I fill up the gas tank over the past 4 months.

- Austin, TX, USA

Upon filling gas tank with fuel, the shutoff engages too late, and gasoline pours out down the side of the vehicle onto the ground. This does not matter which gas station is utilized, but happens whenever reaching a full tank, even when care is taken not to engage the spout at its maximum capacity. This is an ongoing issue, since I purchased the car last September, and so the following "approximate incident date" should be - ongoing.

- East Lansing, MI, USA