There were absolutely no warning lights on my dashboard for the engine, engine oil or anything. I was on a busy 2 lane road with my 7 year old on December 21, 2023 and suddenly the Charging System Warning light and the Immobilizer Indicator came on and the car stopped accelerating. I had to coast off of the road where there was no where to pull over. There are only 61,355 miles on my car and I had just had the safety inspection completed by Kia on September 7, 2023. I had the car towed to the Kia dealership in Leesburg as I always trusted them with servicing my car. They now want me to pay $9,899.72 to replace the long block, starter motor, and intake manifold OR they said they will pay me $500 for my car. The car is in the Kia dealerships lot right now because we would have to tow it somewhere else. The only symptom started 2 days before the incident. When starting the car it made a clicking sound. There were absolutely no other symptoms.

- Purcellville, VA, USA

The contact owns a 2016 Kia Sedona. The contact became aware that the radiator was overheating while driving. There was no warning light illuminated. The contact replaced the thermostat, the radiator cap, and flushed the coolant and radiator system. While driving at an undisclosed speed, the contact noticed that the temperature gauge was indicating that the vehicle had started overheating. Due to the failure, the vehicle was towed to the dealer. Upon inspection of the vehicle, the mechanic discovered that the head bolts on the cylinder heads had been stretched, causing coolant to leak into the engine cylinders. The contact was informed that the engine needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not repaired. The failure mileage was approximately 100,000.

- Vacaville, CA, USA

No warning lights ever came on. We took the vehicle to the KIA dealer because the fan stayed on when we shut off the engine and the heat stopped working. The KIA dealer said the vehicle needs a new engine due to head gasket leakage. This vehicle clearly has a major engine defect that could cause the vehicle to breakdown at any time with a failed engine. How does an engine fail without the engine light ever coming on? The vehicle has been properly maintained with timely oil changes and fluid checks.

- Fanwood, NJ, USA

Engine failed without warning on a trip to urgent care with our daughter. Was running normally, then started losing some acceleration and knocking loudly. Further inspection showed almost no oil in car, with no evidence of a leak. Car is parked in same spot on driveway daily and there isn-??t even a drop of leaked oil. Both the loss of power on the freeway and failure with no warning during an emergency left us and others at risk. Our son, a certified mechanic, has confirmed a thrown rod bearing. It failed October 6, Kia can-??t even look at it until the 26th. I-??m currently incurring the cost of a rental vehicle in addition to the cost of replacing the engine. No warning lights were illuminated before the failure, and none are illuminated after the failure.

- Thornton, CO, USA

We were driving with FIVE kids and my 2016 Sedona lost power while driving & wouldn't accelerate over 30mph. Drove home couldn't go over 30 mph even with the pedal to the floor. Got home, checked oil and it was bone dry. Check engine light NEVER came on and the oil light NEVER came on. The check engine light only came on AFTER it lost power and went into limp mode. Oil was not leaking as I park on a concrete driveway and would have seen any leaks immediately. $2,000 later at the mechanic (they replaced value covers and sensors) and the check engine light still wouldn't go off and the car continued to lose power after driving for about 20-30 minutes. I can turn the car off, wait a few minutes, turn it back on and it runs FINE for a while (20 mins. max). Also, the car runs absolutely fine until it loses power. No noises, no knocking, nothing to indicate there is an engine issue. The mechanic who couldn't fix it recommended; I take it to the dealer for a complete diagnostic workup. After a week at the Kia dealer with little to no feedback / info as to what was going on, I was finally given an estimate for $7,800 worth of repairs and told that still may not fix the issue as there could be internal engine failure because it ran out of oil. After a cursory google search, this appears to be a common problem with the Kia 3.3 GDI engines like mine. There were recalls and Kia extended the engine warranties on various other models with the same engines due to the exact same issue, but they have not extended the same benefits to Kia Sedona owners. There was even a class action lawsuit regarding this issue but again, not with the Sedona. My concern is this is a MAJOR safety issue. FIVE kids in the car on a normally busy highway (it was early so there weren't many people on the road). Had it been as busy as it normally is, we would have been rear-ended which could lead to MUCH worse on a busy highway. Please investigate this before someone is seriously hurt or killed.

- Marlton, NJ, USA

The vehicle started making a rattling noise, but there were no lights on the dash at all!. My husband checked the oil and there was no oil. (It wasn't even due for an oil change yet.) Even after adding 5 quarts of oil, the engine threw a rod through the oil pan while it was being driven down the road. Then the engine caught on fire. Thankfully, my husband was able to get the car to the side of the road without causing an accident or getting burned. There were chunks of metal and oil sprayed all over the road. We had to have it towed and upon an independent mechanic's inspection, found out that the engine was completely destroyed and would have to be replaced and would probably cost about $8,500 (not including the added cost of a rental vehicle while the engine is replaced.) We had just had the oil leak recall completed in May and the local Kia dealership said everything was fine. My husband attempted to call Kia directly as well as the local Kia dealership, but no resolution has been reached.

- Roanoke, IN, USA

A few weeks ago, we were taking FIVE kids to the beach (a one-hour drive) when after about 25 minutes, the van (2016 Kia Sedona SXL with a 3.3L V6 GDI engine) would not accelerate above 35MPH. We drove it home in "limp mode" on the shoulder and going 30MPH. I took it to my regular mechanic who informed me the engine oil was completely dry and the recommended $1900 in repairs to replace damaged valve covers and sensors. After picking it up, the check engine light came on only a few miles from the mechanic. I took it back and they recommended taking it to Kia for a complete diagnostic workup. After a week at the dealership, they gave me an estimated repair bill of just under $8,000 and stated after all that work then engine could possibly still not work due to total engine failure because it ran out of oil. I get the oil changed on a regular basis. absolutely NO warning lights came on prior to the vehicle failing to accelerate onto a busy highway. We had five kids in the car - two of which were friends of my kids. We were lucky that no one was zooming by when we tried to merge onto the highway because the engine completely lost power. It could have been a very dangerous situation. Now, after reading literally HUNDREDS of posts and complaints stating the EXACT same issue, I'm wondering why Kia has not recalled this particular model of car. They have, however, recalled the exact same engine in different models. I'm genuinely confused as to why SO many people are having the EXACT same issue and Kia is refusing to acknowledge it's an issue on their end that they should be fixing. I have a 2016 van which is otherwise in perfect condition sitting at my house needing a completely new engine. I should not be needing the engine replaced after only 108,000 miles - of which it has been regularly services. It's absolutely infuriating. The dealership basically threw up their hands and said they couldn't do anything except replace the engine for $8,500!!!!

- Marlton, NJ, USA

I was driving on 2 two lane highway and starting to go up an incline. All of a sudden the vehicle started making a low rumble type sound and even though my foot was on the accelerator, the vehicle would not continue to drive. Everything basically stopped working. I was able to pull over onto the shoulder and put the vehicle in park. The engine light started blinking and then several lights started coming on. I turned the vehicle off for a few minutes and the restarted. Same thing happened. The engine light came on and the vehicle would not go after I put it in drive. Same rumble as well. I was able to get it towed to a trusted independent mechanic. After checking out the vehicle, he found there was no oil. What? We get it serviced on a regular basis and wasn't due for an oil change. There was NO WARNING LIGHT to alert me that the oil was gone. This ruined our engine. Our mechanic stated Motor is bad, no compression on 2 4 6 bank of engine. There was only 126, xxx miles on this vehicle. I am beyond upset as the vehicle is still in great condition and will now have to spend almost $5,000 on a replacement engine with 100,000 plus $1,000 in labor. This is unacceptable!!!!!

- Mountain View, AR, USA

Engine caught fire while traveling on the highway. It was towed to the dealer. Dealer told us that engine failure and fire had been caused by oil leak, which occurred even with us bringing the car in for routine maintenance regularly and as recommended by Kia. Yes, our safety was put at risk as our engine failed and caught fire while we were traveling at high speed on a highway. There was no warning prior to this happening, and I had just brought the car into the dealer for routine maintenance within two weeks prior to the fire. With that said, I had been bringing the car to the dealer for routine maintenance regularly and bringing to their attention that the "low oil" warning light would appear intermittently, which it should not have done as I WAS bringing the car in for regular maintenance and oil changes. They did not seem to feel that that was an issue and would replenish the oil and send us on our way.

- Chapel Hill, NC, USA

While driving down the road, the car started sputtering and smoking. There were no warning lights on the dash, or irregular readings. My son pulled over and flames were coming from underneath the vehicle. Upon immediate inspection, there was an oil trail in the road behind the vehicle and pieces of the rod and oil pan. They said it looked like the engine threw a rod, damaging the oil pan, and causing the fire. We are still awaiting an independent inspection and solution from Kia, but they-??re taking their time. Thankfully my son was able to exit the vehicle quickly and safely.

- Lemoore, CA, USA

My car was at a stop sign. Upon accelerating after the stop, the engine stopped working without any warning. There were no warning indicators that there was a problem prior to the car ceasing to work. Itook the car to my usual mechanic and he indicated that the engine would need to be replaced. In his assessment, at only 68,800 miles, the engine should not have been an issue. The car has been at a local dealership for a week now, and I am waiting to hear their assessment of this situation. The car stopped directly in the middle of an intersection, and prior to this we were on the a highway. This would have been a much more significant issue had it stopped in the middle of the highway. Additionally as there were no warning lights prior to the issue, a driver would have no indication that there is a problem.

- Philadelphia, PA, USA

Our Kia Sedona had the cooling fan harness negative Cable melt and caused making our engine overheat. When we took our vehicle to get serviced they told us that the cooling fan harness melted and then it's a common problem with kias. They fixed the pigtail cooling fan harness but are cooling fan does not turn on anymore and they said that it is now an electrical issue and this was from a Kia dealership in Dodge City Kansas. They recently did a recall on sliding doors because they weren't shutting all the way and it worked for exactly one day after the recall and now it's back to not shutting and making a really loud noise when it attempts to shut. When this happens we can't lock our doors because the doors won't lock when doors open and we have to constantly shut off our interior lights so that they don't stay on because the doors don't shut. We've notified the Kia dealership that have done our recall on it and told them that it didn't fix it but they refuse to make it right. We only have 106,000 MI I've got a new cooling fan resistor and put it in and a new pigtail harness and put it in but the cooling fan is still not turning on the low speed and the air conditioner doesn't work either. Our engine constantly smells very hot but it doesn't indicate that it's overheating. We haven't had this vehicle for very long and because of all the problems we've had with it are considering on getting another vehicle and we're considering a carnival but are afraid to because of the way Kia handles their issues.

- Dodge City, KS, USA

The engine failed. It burned through all of the oil, didn't give any warnings or light and just died.

- Apopka, FL, USA

While driving engine started making a rattling noise and then died. Checked and there was no oil. No warning lights came on at all. No oil light, no check engine light; nothing. Van only has 96,000 miles. Service is performed regularly on van. Was 2 hours away from home and had to have vehicle towed. After researching I found that the 3.3 liter engines on some Kias are failing due to oil starvation caused by the oil light sensor not coming on. Kia has addressed this issue in some of their other vehicles but have yet to add the Sedonas to the engine recall. Now I-??m stuck with a vehicle that more than likely needs a new engine and a company that will not take responsibility for their failure to include the Sedonas in the engine recall.

- Arab, AL, USA

The engine oil leaking for any anywhere, first look like transmission fluid leaking, but clear it didn't find any leaking, and check engine oil tank didn't find any leaking, find from recall have same problem but not my Vin number, and in my car didn't show warning light.

- Oviedo, FL, USA

Was driving down the highway on a road trip and the Sedona developed an engine rattle. Pulled over into the nearest gas station to inspect. I checked the oil and the oil was 3 quarts low -- even though my vehicle received regular oil changes/maintenance! I filled up but the damage was too far gone; motor had a clanking noise and would not stay started. Had vehicle towed to my dealership where it still is awaiting a motor swap. Dealership confirmed engine damage and recommended the full swap. It's been 3 weeks. Kia has no open recall for this even though a growing number of Sedona owners are experienced the same issues.

- Waukegan, IL, USA

We have a 2016 Kia Sedona, bought in 2017 as a Kia certified. We have had several recalls since our ownership. For the last 2-3 years we have driven it sparingly. We took it to the Kia dealership for regular oil change at 97,000 + miles. There was no mention of any major engine concerns. We again took it in to the Kia dealership, for a spare tire cable issue at 99,186 miles again no mention of engine issues. The Kia dealership performed a multipoint inspection, and repaired a turn signal issue, and suggested some other maintenance items, that would need attention soon, brakes ect. At 102,866, we took the vehicle to a repair shop, we have used before, for an oil change. We were informed that someone had put stop leak in the coolant system. They said we should take it to the dealership for a head gasket issue. We took it to another full service shop, where, they didn't detect a coolant leak. We did notice coolant was running low, but none was spotted on the ground. We took it back to the previous repair shop, where they informed us of a possible blowned head gasket, but couldn't confirm, because of oil all over the under carriage, through all of this there were no warning signal or lights, until the temp gage moved towards high and the oil light flickered a couple of times. We were told that the engine was probably shot. The vehicle is again at the Kia dealership. No resolve yet. We now understand that that Kia has recalled quite a number of their vehicles for simular engine issues. We got a recall for a leaking oil switch, which we informed the dealership of. Are the Kia Sedona's on the recall list?

- Evansville, IN, USA

I was driving the car and noticed a smell. I looked down and saw the the temperature gauge was in the red zone but there were no dashboard lights or any sounds to let me know there was a problem. I pulled over and called AAA. They took the car to a AAA repair shop. The repair shop called me and said the head gasket was blown and that the car needed a new engine as the cost to repair would be even more money.

- Waxhaw, NC, USA

My 2016 Kia Sedona has only 79900 miles on it, yet needs an engine replacement. It is experiencing the EXACT same issues as the other kia engines that have been recalled/replaced by kia, yet they will not help fix it, because "there are no problems with my engine, but there are with the other kia engines" A vehicle should not need a new engine at 79000 miles. There were zero warnings to this. No check engine lights. No oil lights. Nothing. In fact there are still no lights, even after having this problem diagnosed at the dealer. If my engine fails in the middle of the road, I am putting myself, my 4 children, my husband, and anyone else on the road at risk. This should not be happening at such low mileage, especially with no warning lights. The dealer confirms I need a new engine. Other auto shops claim kia should cover this repair because this engine is defective.

- Lake Saint Louis, MO, USA

The contact owns a 2016 Kia Sedona. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud rattling sounds with black smoke coming from the engine. Additionally, there was oil leaking onto the ground while driving. The vehicle was towed to the dealer where it was determined that the engine needed to be replaced. The dealer replaced the engine. The manufacturer was not made aware of the failure. The failure mileage was approximately 117,000.

- Lenexa, KS, USA