2004 Mercedes-Benz C230
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2004 C230 are official communications between Mercedes-Benz & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #462046
PLAY IN THE RACK AND PINION STEERING SYSTEM. MODELS 203, 209, 210, 211, 215, 220, 230. MERCEDES BENZ. *KB UPDATED 5/13/09. *PE Read More »
-
TSB #462046
PLAY IN THE RACK AND PINION STEERING SYSTEM. MODELS 203, 209, 210, 211, 215, 220, 230. MERCEDES BENZ. *KB UPDATED 5/13/09. *PE Read More »
-
TSB #010104
THE HIGH PRESSURE HYDRAULIC DISTRIBUTION HOSE OF THE ACTIVE BODY CONTROL (ABC) MAY DETERIORATE OVER TIME DUE TO EXCESSIVE EXPOSURE TO HUMIDITY AND HIGH TEMPERATURES. Read More »
-
TSB #424638
BLEED BRAKE SYSTEM AND CHECK BRAKE SYSTEM FOR AIR ON THE SENSOTRONIC BRAKE CONTROL (SBC) SYSTEM USING STAR DIAGNOSIS. ALSO INCLUDES MERCEDES-BENZ 211 MODEL MY2004. *TT Read More »
-
TSB #LI-43-10
MERCEDES BENZ (DAIMLER): UNSATISFACTORY BRAKE SERVO ASSISTANCE AFTER A COLD START, PRIMARILY WHEN MANEUVERING. LOW VACUUM IN THE INTAKE MANIFOLD DUE TO WIDE OPEN THROTTLE VALVE. RETROFIT ELECTRIC BRAKE BOOSTER VACUUM PUMP (M56). Read More »
-
TSB #PB-42-30-103
MERCEDES VEHICLE: THE ANTI-LOCK BRAKE SYSTEM (ABS) RETURN FLOW PUMP RUNNING WITHOUT CONTROL WITH CORRESPONDING FAULT CODE C1401, CLEAN AND INSULATED THE CONNECTOR FOR THE RETURN FLOW PUMP RELAY. MODELS 202 AND 208. MODEL YEARS UNKNOWN. Read More »
-
TSB #PB-42-30-103
MERCEDES VEHICLE: THE ANTI-LOCK BRAKE SYSTEM (ABS) RETURN FLOW PUMP RUNNING WITHOUT CONTROL WITH CORRESPONDING FAULT CODE C1401, CLEAN AND INSULATED THE CONNECTOR FOR THE RETURN FLOW PUMP RELAY. MODELS 202 AND 208. MODEL YEARS UNKNOWN. Read More »
-
TSB #422049
NOISES FROM PARKING BRAKE CABLE. *TT Read More »
-
TSB #033008
CHECK ENGINE LIGHT ON / FAULT CODES FC1200 / FC1208 STORED IN ME-SFI CONTROL UNIT. MERCEDES-BENZ MODEL C230, C280, C350, SLK280, SLK350, CLK350, CLK550, E350, E550, CLS550, S600, AND SL550. EQUIPPED WITH M272 ENGINE OR M273 ENGINE. Read More »
-
TSB #2004070012
REPLACEMENT OF ABC PRESSURE SUPPLY VALVE UNIT HYDRAULIC LINE. *TT Read More »
-
TSB #2005060017
COOLANT HOSE AT THE BOTTOM RIGHT OF THE RADIATOR MUST BE CHECKED TO DETERMINE WHETHER THE TWO CATCHES OF THE COOLANT HOSE ARE LATCHED CORRECTLY. INSPECT LATCHING OF LOWER RADIATOR HOSE, REPLACE RADIATOR IF NECESSARY. Read More »
-
TSB #2003110006
INSTALLATION OF WIRING HARNESS ADAPTER FOR ENGINE COOLING FAN MALFUNCTION. *TT Read More »
-
TSB #2008020002
MERCEDES-BENZ: DAIMLER AG HAS DETERMINED THAT THE ENGINE VENT HOSE ON SUBJECT VEHICLES MAY NOT CONFORM TO SPECIFICATIONS. CRACKS MAY DEVELOP IN THE VENT HOSE OVER TIME AND IN THE WORST CASE RESULT IN A ROUGH RUNNING ENGINE. Read More »
-
TSB #2008020002
MODEL C230, MODEL YEARS 2003-2005 - REPLACE ENGINE VENT HOSES. *NJ Read More »
-
TSB #2008010001
MERCEDES-BENZ - CHECK CATALYTIC CONVERTERS AND REPLACE IF NECESSARY - MODELS 203, 209, 211, 215, 230 - MODEL YEARS 2004-2005. *NJ UPDATE 8/7/2008. *PE Read More »
-
TSB #PB-61-10-07
MERCEDES: REPLACING THE LONGITUDINAL MEMBER (LEFT AND RIGHT) BELOW THE MAIN FLOOR PANEL ON ALL MY 204 UP TO 12/31/07. (C300, C350, C300 4-MATIC, C63 AME). *PE Read More »
-
TSB #470036
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
-
TSB #PB-61-10-07
MERCEDES: REPLACING THE LONGITUDINAL MEMBER (LEFT AND RIGHT) BELOW THE MAIN FLOOR PANEL ON ALL MY 204 UP TO 12/31/07. (C300, C350, C300 4-MATIC, C63 AME). *PE Read More »
-
TSB #470036
MERCEDES: THE FUEL LEVEL INDICATED IN THE INSTRUMENT CLUSTER DOES NOT MATCH THE ACTUAL FILL LEVEL. THIS MAY BE CAUSED BY A FAULT IN THE FUEL LEVEL SENSOR FUNCTION CHAIN: HYDRAULIC AND ELECTRICAL LINES AND THEIR CONNECTIONS, REAR SAM OR ... Read More »
-
TSB #2006020008
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
-
TSB #2006020008
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
-
TSB #2006020008
INSPECT TRANSMISSION PILOT BUSHING AT ELECTROCHYDRAULIC UNIT AND REPLACE IF NECESSARY. THE TRANSMISSION PILOT BUSHING MAY HAVE BEEN INSTALLED ON THE CONTROL UNITS WITH NON-TEMPERED SEALING RINGS WHICH MAY CAUSE A SMALL LEAK TO OCCUR. Read More »
-
TSB #276064
LEARNING IN SELECTION RANGE SENSOR NOT POSSIBLE AFTER EHS REPLACEMENT. *TT Read More »
-
TSB #2005100004
THE PVC SEAM SEAL ON THE TRANSMISSION SUPPORT BRACKET MAY NOT HAVE BEEN PROPERLY APPLIED. INSPECT TRANSMISSION SUPPORT SEAM SEAL, RESEAL IF NECESSARY. *TT Read More »
-
TSB #276053
ROUGH DOWNSHIFTING WHEN ACCELERATING. *TT VARIOUS MODELS INCLUDING 2005 MERCEDES-BENZ 219 AND 220. *TT Read More »
-
TSB #PB-91-60-53A
MERCEDES VEHICLE: THE SRS INDICATOR LAMP IS ILLUMINATED AND CODE B1058 AND B2DBO ARE STORED, REPLACE THE SRS CONTROL UNIT. MODELS 203 AND MODEL 209. MODEL YEARS UNKNOWN. *PE Read More »
-
TSB #SB-2009100001
MERCEDES: REPLACE THE CAMSHAFT ADJUSTMENT SOLENOID(S) AND INSTALL ADAPTER HARNESS(ES). DUE TO THE SETTLING PROPERTIES OF THE SEAL OF THE CAMSHAFT ADJUSTMENT SOLENOID SPECIFICATION, OIL MAY ENTER THE ENGINE WIRING HARNESS(ES) THROUGH THE ... Read More »
-
TSB #SB-2009100001
MERCEDES: REPLACE THE CAMSHAFT ADJUSTMENT SOLENOID(S) AND INSTALL ADAPTER HARNESS(ES). DUE TO THE SETTLING PROPERTIES OF THE SEAL OF THE CAMSHAFT ADJUSTMENT SOLENOID SPECIFICATION, OIL MAY ENTER THE ENGINE WIRING HARNESS(ES) THROUGH THE ... Read More »
-
TSB #PB-82-10-376F
MERCEDES VEHICLES: THE XENON OR BI-XENON HEADLAMP NOT FUNCTIONING. A FUNCTION DESCRIPTION CAN BE FOUND IN WIS DOCUMENT GF8S.10-P-20010 (203), GF82.10-P-0003Q (209); GF82.10-P-3002R (230). MODEL YEARS UKNOWN. Read More »
-
TSB #887039
SEAL BETWEEN EXTERIOR REAR VIEW MIRROR HOUSING AND DOOR. *TT Read More »
-
TSB #PB-91-60-53A
MERCEDES VEHICLE: THE SRS INDICATOR LAMP IS ILLUMINATED AND CODE B1058 AND B2DBO ARE STORED, REPLACE THE SRS CONTROL UNIT. MODELS 203 AND MODEL 209. MODEL YEARS UNKNOWN. *PE Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #010104
VOLUNTARY RECALL CAMPAIGN 2003 SEAT BELT BUCKLE. *JB Read More »
-
TSB #2005100008
INSPECT BOOT ON BOTH FRONT DOORS. THE BOOT AT THE DOOR CONNECTING TO THE A PILLAR MAY NOT HAVE BEEN CLIPPED CORRECTLY LEADING TO INSUFFICIENT SEALING. *NM Read More »
-
TSB #2004050015
THE TRUNK LID SPRINGS COULD FAIL IN THE CLOSED TRUNK LID POSITION DUE TO EXTENSIVE EXPOSURE TO VERY HIGH TEMPERATURES. VOLUNTARY RECALL CAMPAIGN. COVER LETTER, RECALL CAMPAIGN BULLETIN AND LETTER TO OWNERS. Read More »
-
TSB #8285434
COMAND HEAD UNIT HANGS AT THE STAR SYMBOL WHEN BOOTING UP. *TT UPDATED *EH Read More »
-
TSB #8285443
COMAND HEAD UNIT DISC DRIVE MALFUNCTIONS AT LOW TEMPERATURES. VARIOUS MODELS INCLUDING MERCEDES-BENZ MODEL 215, AND 220 2004 AND 2005. *TT Read More »
-
TSB #8270314B
HIGH-PITCHED WHINING NOISE HEARD ON TELEPHONE/VCS/TELE AID CALLS. *TT Read More »
-
TSB #8285433
SD FLASH TELEMATICS CD STUCK IN COMAND HEAD UNIT WHEN PERFORMING A SOFTWARE UPDATE. *TT Read More »
-
TSB #8285326A
COMAND INTERMITTENTLY INOPERATIVE. MODEL 220 ALSO INCLUDED. *TT Read More »
-
TSB #8200300
DIAGNOSTIC ENHANCEMENT. 220/215 COMAND ENHANCED DIAGNOSTIC ASSISTANCE CENTER EDAC. *TT Read More »
-
TSB #8295322
TELE AID NOT ACTIVE DISPLAYED IN INSTRUMENT CLUSTER. *TT Read More »