2005 Mercury Montego
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2005 Montego are official communications between Mercury & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #05222
NOISE FROM FRONT WHILE TURNING STEERING WHEEL. *TT Read More »
-
TSB #18479
SQUEAK FROM REAR OF VEHICLE WHEN DRIVING OVER BUMPS. *EH Read More »
-
TSB #18353
SQUEAK FROM REAR OF VEHICLE WHEN DRIVING OVER BUMPS. *EH Read More »
-
TSB #19005
GRUNT OR SQUEAK FROM FRONT SUSPENSION DURING FULL LOCK TURNS - SERVICE TIP. *TT Read More »
-
TSB #0614
NOISE FROM REAR SUSPENSION - COLD ONLY. *TT Read More »
-
TSB #0532
SQUEAK/CLUNK NOISE FROM REAR LOWER CONTROL ARM - VEHICLES BUILT 7/12/2004 THROUGH 9/21/2004. *TT Read More »
-
TSB #18417
REAR SUSPENSION NOISE WHEN COLD. *TT Read More »
-
TSB #0547
THUMPING NOISE OR ROUGHNESS FROM REAR BRAKES. *TT Read More »
-
TSB #08-4-11
TRACTION CONTROL LAMP ON--NO DTC'S PRESENT, OR DTC P1889 IN DIFFERENTIAL ELECTRONIC MODULE (DEM). *NJ Read More »
-
TSB #0759
REAR BRAKE DRAG, NOISE, DUST, AND/OR PREMATURE PAD WEAR. *KB Read More »
-
TSB #0710
FORD\MERCURY SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN 2005 THROUGH 2007 FWD AND AWD FORD FIVE HUNDRED, FREESTYLE AND MERCURY MONTEGO VEHICLES - REAR BRAKE WEAR. ALSO HAVE AN OWNER'S LETTER. Read More »
-
TSB #CSP-12N03
FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MOMENTARY ENGINE IDLE RPM SURGE MAY BE INTERMITTENT AND MAY OCCUR, DUE TO DEPOSITS BUILDUP IN THROTTLE BODY, AT LOW SPEEDS, WHILE PARKING OR ENTERING DRIVEWAY AND CHECK ENGINE LAMP ... Read More »
-
TSB #041601
WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT Read More »
-
TSB #05175
ENGINE RPM FLUCTUATION AT HIGHWAY CRUISING SPEEDS - VEHICLES BUILT PRIOR TO 8/2/2005. *TT Read More »
-
TSB #18432
VEHICLE MAY EXHIBIT AN OIL LIFE XX% MESSAGE INTHE ODOMETER MESSAGE CENTER DISPLAY PRIOR TO THE VEHICLE REACHING 5000 MILES. *EH Read More »
-
TSB #19722
MIL WITH DTC P0106 AND/OR P0109. *KB Read More »
-
TSB #0531
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM). *TT Read More »
-
TSB #0747
MIL ON WITH DTC P0191 - FUEL RAIL PRESSURE SENSOR CIRCUIT PERFORMANCE. *KB Read More »
-
TSB #06411
OIL LEAK FROM POWER TRANSFER UNIT. *TT Read More »
-
TSB #0516
HARSH OR ERRATIC UPSHIFTS/DOWNSHIFTS - WRENCH LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P2544 - VEHICLES BUILT BEFORE 1/7/2005 AND EQUIPPED WITH THE (AWF21) 6 SPEED TRANSAXLE. *TT Read More »
-
TSB #06114
CONTINUOUSLY VARIABLE TRANSAXLE (CVT) NOISE DIAGNOSIS. *TT Read More »
-
TSB #05L25
SPECIAL FIELD ACTION 05L25 - OUTPUT SHAFT SPEED (OSS) SENSOR; TURBINE SHAFT SPEED (TSS) SENSOR; TRANSMISSION FLUID TEMPERATURE (TOT) SENSOR WERE INADVERTENTLY OMITTED FROM THE CALIFORNIA LONG-TERM DEFECTS WARRANTY PARTS TABLE. Read More »
-
TSB #05245
HARSH/ERRATIC/SLOW DOWNSHIFTS OR TIP-IN HESITATION -- 6 SPEED AUTOMATIC TRANSAXLE -- VEHICLES BUILT BEFORE 10/17/2005. *TT Read More »
-
TSB #0718
TRANSMISSION SHIFTER BINDING / HIGH EFFORT BEZEL REPLACEMENT. *KB Read More »
-
TSB #06245
TRANSMISSION HARSH SHIFTING - NO DTC'S - MILEAGE OVER 20,000 MILES. *KB Read More »
-
TSB #042107
GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #04217
GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT Read More »
-
TSB #18730
VEHICLES WITH A CVT TRANSAXLE, MAY EXHIBIT A FLUID LEAK FROM THE TRANSAXLE OIL PAN AREA. *TT Read More »
-
TSB #18378
OIL LEAK FROM POWER TRANSFER UNIT. *TT Read More »
-
TSB #18361
OIL LEAK FROM POWER TRANSFER UNIT. *EH Read More »
-
TSB #0551
INTERMITTENT HEADLAMP FLICKER WITH NO KEY IN THE IGNITION - VEHICLES BUILT BEFORE 2/21/2005. *TT Read More »
-
TSB #18178
WRENCH LIGHT ON, NO ENGAGEMENT IN DRIVE OR REVERSE AND DIAGNOSTIC TROUBLE CODE P0942. *TT Read More »
-
TSB #18179
WRENCH LIGHT ON, DIAGNOSTIC TROUBLE CODE P0562 AND TRANSAXLE IN LIMP HOME MODE AFTER BATTERY JUMP START. *TT Read More »
-
TSB #19312
BATTERY LIGHT ILLUMINATED. *KB Read More »
-
TSB #19312
BATTERY LIGHT ILLUMINATED. *KB Read More »
-
TSB #0662
INTERMITTENT INSTRUMENT CLUSTER GAUGE SWEEP/RESET - MULTIPLE WARNING LIGHTS ON - REVERSE LIGHTS ON - VEHICLES BUILT BEFORE 2/17/2006. *TT Read More »
-
TSB #19087
TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS. *TT Read More »
-
TSB #06172
FUEL GAUGE ERRATIC/INACCURATE AND/OR MIL ON WITH DTC P0463, B1202, B2627, B2879, AND/OR P2068. *KB Read More »
-
TSB #06179
INTERMITTENT INSTRUMENT CLUSTER OPERATION - INCLUDING GAUGES SWEEP/RESET - MULTIPLE WARNING LIGHTS ILLUMINATED AND/OR REVERSE LIGHTS STAY ON. THIS APPLIES TO VEHICLES BUILT BEFORE 02-17-06. *KB Read More »
-
TSB #19083
INTERMITTENT BOUNCE-BACK OF THE DRIVER'S WINDOW DURING ONE TOUCH UP OPERATION. *TT Read More »
-
TSB #04189
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT Read More »
-
TSB #042616
WELD BONDING PROCEDURE. *TT Read More »
-
TSB #19107
NOISE IN RIGHT FRONT OF PASSENGER COMPARTMENT - AIR INLET DOOR ACTUATOR INOPERATIVE (RECIRCULATION). *TT Read More »
-
TSB #05197
TRUNK LID HARD TO CLOSE. *TT Read More »
-
TSB #05419
FALSE PARKING AID WARNINGS. *TT Read More »
-
TSB #04262
FALSE PARKING AID WARNINGS. *TT UPDATE. *TT Read More »
-
TSB #18399
MEMORY SEAT, ADJUSTABLE PEDALS AND MIRRORS OPERATION CONCERNS. *TT Read More »
-
TSB #18412
MEMORY SEAT, MIRRORS AND PEDALS OPERATION. *TT Read More »
-
TSB #18329
AUDIO UNIT BACKLIGHT INOPERATIVE AND OR DTC B2477. *EH Read More »
-
TSB #18504
INCORRECT COMPASS INFORMATION IN OWNERS GUIDE AND WORK SHOP MANUAL. *EH Read More »