2004 Nissan Titan. Consumer writes in regards to faulty wire harness recall notice. The consumer stated the recall remedy failed and was only a temporary fix. The consumer stated the vehicle failed a state inspection, because the air bag light was on. The consumer stated since the fix did not eliminate the potential hazardous condition of the faulty wiring harness installed by the manufacturer, he believed he was entitled to refund of $ $185.60 when he had to pay for the repairs, that should have previously been made under the recall.

- Roanoke, VA, USA

I received a recall notice in the mail this week: Recall 06V-459 about the airbag warning light flashing, seat belts not working properly, etc. My vehicle is having all of the problems listed so as instructed I brought my vehicle to the Nissan dealership along with the letter. They informed me that they would not fix the problem because it "was not in their system". stating they do not understand why I got a notice in the mail. Clearly my vehicle is having these exact problems and they are required to fix them, but they still refused to fix or diagnose for free as required by law. Very disappointing in Nissan for disregarding my family's safety...updated 08-07-13

- Gaffney, SC, USA

Driving vehicle on expressway at approximately 60 mph and vehicle lost engine power and turned off. Dangerous experience.

- Brownsville, TX, USA

I was traveling towing a 33 ft camper. Usually tow at about 62 mph. All of a sudden the truck cuts out then turns back on and "bucks". my lights on my dash light up like a color blinking christmas tree. My speedometer goes all the way to 140 mph, my rpms max out, my fuel gauge goes up and down along with the temp gauge. Furthermore all the gauges and warning lights flash or move in no form or fashion. Steering gets stiff along with the brakes because the truck shuts off. I controlled the truck to avoid crashing in between the on and off periods. This happened several times. Thought it was wiring from camper or brake controller. However, over the last few weeks from about mid Sept it has progressively gotten worse. Now I can't go out of the driveway before the truck starts acting up. There is a bad accident waiting to happen. In my past experience with Nissan is they are reluctant to say anything is wrong and to fix things. I have had enough go wrong with my truck from brakes, electrical, and rear end unit. Just last weekend 20 Oct 12 I took the truck on about a 15 mile round trip and it acted up again. Between July and Sept 2012 the truck would start the shut completely off in parked position. It still does that now too. The truck is now parked until I figure what is the problem. I don't have mega bucks to fix it! someone said Nissan has a computer recall but I have not been notified and I contacted a dealer but they have not called back. Its been 3 days now. They said the description I gave them matches the recall"????????"

- West Chazy, NY, USA

On May 3, 2012, I saw my side mirror lights were not turning off, even while driving. I scheduled work for my truck for May 5, 2012. My truck was parked at my place of employment from around 6 am to 2 pm on May 3, 2012. When trying to leave work I tried to start my truck and it would not turn over, tried to jump start with no success and even had a tow truck company attempt to start the truck. After the truck was towed to local shop the truck started up with no problem and the mechanic said since its not showing any issues that it did before there was nothing they could do. On May 5, 2012 I took my truck in for the electrical problem and they also fixed a recall with the ECM relay. On the same day around 6 pm in the afternoon the truck would not start again. The truck was towed back to the Nissan dealership on May 6, 2012 and on May 7, 2012 the technicians at Nissan contacted me stating it was my BCM which was in the same area as the ECM. I had to pay about 600 dollars for a new BCM. I believe the BCM went out due to the recall work that was performed earlier.

- Stafford, VA, USA

The wiring harness, in the back door has broken, because of a Nissan engineering problem, both the harness and wires have broken, which according to NHTSA the front passenger side airbag will not deploy, resulting in my having an unsafe truck according to NHTSA, I contacted Nissan and was told that the campaign had ended, so they refuse to repair my truck according to the guidelines set by NHTSA. At what point does Nissan decide that they can decide which trucks to repair, I have to wonder how many other unsafe Nissan trucks are on the highways.

- Kingsport, TN, USA

I took my truck in for the service manager at wallace Nissan, kingsport, tn, to find out if they would repair the broken wire in the wiring harness in the rear door, I was told by the service manager and by Nissan Consumer Affairs office that Nissan would not repair the broken wire, even though the NHTSA had a recall for this problem, Nissan told me that the campaign had ended and they would not do anything about the problem, as I recall in the NHTSA recall the wiring affects the passenger side airbag, which would explain why the passenger side airbag has been flashing continuously for about 3 months, I have been in contact with Nissan Consumer Affairs office but they have quit answering my emails to them, all I am asking is for Nissan to repair the wiring harness and broken wires on my unsafe vehicle. Recall # 06V459000.

- Kingsport, TN, USA

On certain king cab trucks, the wires in the harness were routed through the rear doors and into the body. These wires may break due to over bending of the harness as the door is opened and closed. The harness contains wires for the driver seat belt pretensioner and for the front passenger seat belt which is part of the occupant classification system. Wires for the rear audio speakers are also contained N the harness. Consequence: If the wires for the seat belts and speaker wires break and make contact, there is a possibility that the pretensioner may deploy. If this happens when the seat belt is retracted, it will not be possible to use the seat belt. If one of the wires on the right side harness for the seat belt tension sensor breaks, the passenger side front air bag will not deploy as designed in a frontal collision increasing the risk of a crash and personal injury. I went to wallace Nissan, kingsport, tn, on 07/18/2012 and described the above mentioned problem, and was told that the campaign had ended and they would not repair this problem, I explained that the dome lights and the door lock were effected by this flawed design problem, . I am very much afraid that the broken wires will short out and start a fire.

- Kingsport, TN, USA

The contact owns a 2004 Nissan Titan. The vehicle was included in the recall under NHTSA campaign id number: 06V459000 (electrical system) and was taken to the dealer for the replacement of the front passenger side wiring harness. After the repair, the SRS light was illuminated on the instrument panel. The vehicle was taken to the dealer for diagnostics. The technician stated the wiring harness on the front driver side would have to be replaced but also stated that the part needed for the repair would have to be ordered. The contact did not hear back from the dealer and contacted them after some time. The technician then advised that another diagnostic test would have to be performed in order to determine the failure because the part had arrived and was sent back. The technician stated that the repair would not be covered under the recall. The vehicle was not repaired. The approximate failure mileage was 65,000.

- Culver City, CA, USA

2004 Nissan Titan the rear wiring harness is routed over the frame rail directly next to the tailpipe causing it to melt in the event of an exhaust leak. This happened to me and now I'm stuck splicing wires together as the local dealer in saint john nb want over $1000 to replace, this problem seem to be a common one among other owners I have talked to and poses a serious fire hazard / potential accident due to complete sudden loss of all power. Nissan Canada should be made aware of this (I'm sure they already are) to avoid any legal problems that may arise due to them not recommending an inspection / notice or recall of the rear wiring harness.

- New Brunswick, Canada, E5n5v7, ME, USA

While traveling to go on a 13 hour drive, all of our engine lights came on and the truck became sluggish. We had truck towed and got a call from dealership saying what happen was muffler/exhaust unit fell off during travel and the unit remaining got so hot it burned out entire part of truck including, ECU, rear right harness, and 3 other things. Cost to fix over $3,000. After paying hefty bill shop manager said this was the 5th Titan in our small town he had same issue with and that he agrees this is the worst place for a unit on a truck and manufacturer should of put other location. I then filed a complaint with Nissan Consumer Affairs. They acted like they cared and then 3 weeks later they denied helping me at all saying it was out of warranty. I did research on line and lots of people are having same issue. This is a huge safety concern and I think needs to be recalled and I need to be reimbursed for my repairs. I find it odd that the exhaust manifold also cracked on the truck on the right and left side and Nissan covers that until 80,000 miles.

- Rapid City, SD, USA

I received a factory recall notice for an engine control module relay that can cause engine performance issues. I made an appointment for the recall for today 04/13/2011. When I got to the dealer ( North dartmouth, MA Nissan dealership) I was told the recall could not be done because the check engine light was on and that in order to correct that there would be a $127 charge. So much for free recall!!

- Dartmouth, MA, USA

I live in the cold northeast and have to warm my vehicle before I drive to work. My truck is a 2004 Nissan Titan SE with 79K miles on it. I brushed the vehicle off and started it turning the defroster to high and turning on the side mirror defrosters as well. I went back inside to grab the rest of my stuff for work and was inside for approximately 5 minutes. When I came back outside I was surprised to see the drivers side of my truck on fire. Fire engulfed the drivers side mirror and the dripping plastic was burning up the side of the truck. I returned inside and grabbed a fire extinguisher and was able to get the fire out. Luckily my vehicle was far enough away from the garage as to not be a concern as to burning down my house. I was shocked to see that the mirror defrost switch was still active and had not tripped any fuses. I immediately turned the switch to the off position and the light went out. This just happened this morning and I have not repaired the trouble as yet. The mirror of course is totally destroyed and the paint on the drivers side is damaged. I am writing this out of concern for the safety of the public as this could have easily evolved into a full blown house fire.

- Auburn, NY, USA

Called Nissan about my recall to tell them we haven dealer in our area. That we would have to travel over 70 miles one way and could we have a local service take care of recall and they would be reimburse. They said that I would have to take it to a dealer. I don't understand with is recall (ECM) my vehicle could stop at any time, why would I want to travel over 70 miles. How can I get Nissan to pay my local serv person who is only 4 miles.

- Eagle River, WI, USA

Several times in the past month while driving on the highway the truck has stalled followed by a loud thud from the transmission - all of the dash lights come on, and the vehicle restarts, but the transmission does not engage for several seconds and only one gear is available until the vehicle is shut off and restarted. Also have had some problems starting the vehicle since the first 2 occurrences on the highway. Replacing the ipdm as this is a known issue with the vehicle. This is a very unsafe problem that needs to be corrected immediately.

- Sanford, NC, USA

Just driving down the road the brake light comes on in the dash and the brake pedal goes to floor. You have very little brakes and it makes a grinding noise. If you turn off the vehicle it goes away. It has happened three times in the last year or so. Im taking it to a Nissan dealer next week and they say its going to cost me 100 dollars to reprogram the computer. I have read hundreds of reports of other people having the same problem. If its that big of a problem shouldn't there be a recall on this and Nissan have to pay for it?

- Lucernemines, PA, USA

My 2004 Nissan Titan caught fire and burned to the ground on 7/29/10 at 4:30pm. It all started as I was backing up and I noticed an electrical burning smell. I looked down and saw smoke and inspected it closer and noticed that the smoke was blooming from an electrical component which appeared to be the computer. I took some video of it as proof of what was going on not knowing that my truck would be engulfed in flames minutes later. The video is clear that it was manufacturer defect. I tried to stop it by disconnecting the battery but that was not successful. Later my fire inspector said it was Nissan BCM that failed! he was very happy had the video otherwise he would have never been able to identify. He said the video is really clear and apparent what happened. Nissan never recalled just sent service bulletins. My insurance may cover the remainder of the loan but that does not put me another vehicle. I have contacted Nissan on this matter and they say there is nothing they can do to let my insurance deal with it, which I explained above how that does not work for me. I feel like this is Nissan fault and they should help me but they are not. Apparently I need to hire an attorney that deals with fire and I have been informed that this is very expensive, which I can not afford. I told Nissan I had the video but they did not care. You would think after all the Toyota incidents that they may help especially since I had the video of proof and they did not. I have sent the video and all pictures I have to my insurance company as well but all they will probably get is the money they paid for loan. So my insurance company is covered but I'm left out to dry. Please read this part. The fire inspector for my insurance company and an outside independent fire inspector have concluded it was the BCM ( body control module). Nissan knew of the problem but just sent out service letters and not recalls. My insurance will be pursuing Nissan as well !

- Midlothian, VA, USA

While pulling my boat to the lake yesterday at approximately 65 mph on the interstate with my 2004 Titan 4X4 king cab (mileage approximately 78,000), the ABS, slip, and vdc lights illuminated. Before I could reach an exit to pull off, the engine shut down. This happened within a matter of less than 3 minutes. I was able to pull to the side of the interstate but the engine would not re-fire. Upon inspection, I noticed smoke pouring from rear passenger wheel well. I got all occupants out of the truck and when I returned seconds later, I spotted a fire coming from the wiring harness just where it goes over the frame rail in the rear passenger wheel well. Luckily I had a fire extinguisher on the boat and was able to put the fire out before causing major damage to the truck, my family or passers-by. I have had the vehicle towed to the dealership to be inspected and they "believe" a new wiring harness will fix the problem although they have "no idea" how a fire could have happened. A "belief" that the problem is fixed is not comforting.

- Paducah, KY, USA

About 3 months ago my wife was driving on a side road doing 25-35 mph and her 2004 Nissan Titan cc suddenly lost power and then engine shut off. She came to a stop and the truck restarted immediately. On Feb 26th, 2010 my wife was at a friends house and the truck would not start. She had given me the wrong description of what happened to the truck I thought it was just a dead battery. So I jump started the truck and it fired right up so I replaced the battery. On Feb 27th, 2010 my wife and I were sitting at a stoplight and the truck's engine just shut off without warning. The engine would not restart and this caused a major traffic jam and we were almost hit my multiple vehicles. Luckily a couple bystanders helped direct traffic and helped push the truck off the road. The truck would not start and nothing else was visibly wrong such as battery or any other common items. After approximately 10 minutes the truck started right up with no problems. After much research online through multiple Nissan Titan forums it came top my attention that this was a common problem that has been known about by owners for some time. The intelligent power distribution module (ipdm) in the truck were faulting causing the ECM relay on the truck to stop working. The short term fix for this was to replace the relay. The long term fix for this is to replace the ipdm. So I replaced the ipdm and have not seen a problem since. When I went to the parts counter at korum Nissan in puyallup to pick up my $178 part I asked how many people have ordered this part. I was told by there parts rep mike that he has sold a lot of these units for various reasons. He said it was a common known issue by the parts reps and the service reps. What I don't understand is how such a thing could be known so well but no safety recall has happened. My problems were relatively minor compared to others who have experienced such problems at high speeds where death or injury could occur.

- Tacoma, WA, USA

Brakes go into in ABS mode for no reason, truck becomes hard to stop; road conditions were dry- 80 degrees and sunny. I was coming home from the Nissan dealer because of a brake, slip, vdc light (anytime) and brake light - ABS coming on (only during braking), both are intermittent. The Friday before I had Nissan look at this very condition(s) they agreed I had a problem, and upgraded the software. 2 days later the light still came on and stayed on. The only difference was after shutting down the truck and restarting, the lights would stay on, something that did not use to happen... Nissan has a brake issue, I've seen many of complaints that are the same as mine- loss of braking because the ABS kicks on (brake light comes on when this happens) and will not correct/stop it-self until the engine is shut down and restarted. Restarting the truck when the ABS is hampering the stopping ability is not very practical, and very dangerous in most driving conditions. When this happened to me I came very close to hitting the car in front and swerved to the edge of the road. Since the 2nd visit to Nissan I had the master cylinder with stability control option replaced, that was the dealership recommendation after they downloaded the codes(X2), they stated the part had to be ordered. Cost for repair was quoted at $650.

- New Vienna, OH, USA