2000 Pontiac Montana
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2000 Montana are official communications between Pontiac & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #030232049
RELEASE OF NEW OUTER TIE ROD ENDS FOR SERVICE. *TT Read More »
-
TSB #3069
RATTLE NOISE OR CLUNK FROM THE LEFT REAR SUSPENSION. *TT Read More »
-
TSB #010523011A
CONCERNS WITH RATTLE TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE. *TT Read More »
-
TSB #010523011
SOME CUSTOMERS MAY COMMENT ABOUT A RATTLE TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE UNDER 30 MPH AND WHILE DRIVING OVER BUMPS. *TT Read More »
-
TSB #010523006A
THIS BULLETIN IS BEING ISSUED TO REVISE THE FASTENER REQUIREMENTS FOR THE FRONT AND REAR BRAKE CALIPER BRACKET REPLACEMENT PROCEDURES IN THE DISC-BRAKE SUB-SECTION OF BRAKES IN THE APPROPRIATE SERVICE MANUAL. Read More »
-
TSB #010523006
SUBJECT REGARDING REVISED FASTENER REQUIREMENTS FOR FRONT AND REAR BRAKE CALIPER BRACKET. *TT Read More »
-
TSB #01521
REAR PARKING BRAKE CABLE RATTLE NOISE LEFT REAR SUSPENSION. *TT *MJ Read More »
-
TSB #PIP5029G
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. Read More »
-
TSB #PI1394A
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. Read More »
-
TSB #000601012F
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. Read More »
-
TSB #030601010
ENGINE OIL OR COOLANT LEAK. *TT Read More »
-
TSB #03-06-01-010
ENGINE OIL OR COOLANT LEAK. *TT GM REMINDER. *TT INSTALL NEW LOWER INTAKE MANIFOLD GASKET. UPDATED 7/18/08 *PE Read More »
-
TSB #010845005
HARD START, NO START, STALL, AND/OR FUEL GAUGE INOPERATIVE OR FLUCTUATES. *YH UPDATED *EH Read More »
-
TSB #020601014
SUBJECT REGARDING REVISED LOWER INTAKE MANIFOLD INSTALLATION. *TT Read More »
-
TSB #010601010A
SUBJECT REGARDING POLYMER SERVICE PISTONS. *TT Read More »
-
TSB #200900
SOME CUSTOMERS MAY HAVE EXPERIENCED INTERMITTENT NO START OR HARD START CONDITIONS. *TT Read More »
-
TSB #020604053
REVISED DIAGNOSTIC TROUBLE CODE (DTC) EXHAUST GAS RECIRCULATION (EGR) SOLENOID CONTROL CIRCUIT. *TT Read More »
-
TSB #000730007A
SUBJECT REGARDING WHINE NOISE IN PARK OR NEUTRAL, SERVICE ENGINE SOON OR SERVICE VEHICLE SOON LAMP ILLUMINATION. *TT Read More »
-
TSB #000730002B
CONCERNS WITH SLIPS, HARSH UPSHIFT OR GARAGE SHIFTS, LAUNCH SHUDDERS, FLARES, ERRATIC SHIFTS AND INTERMITTENT CONCERNS, DIAGNOSTIC TROUBLE CODE P1811 OR P0748 SET. *TT Read More »
-
TSB #010730032B
SOME OWNERS MAY COMMENT ON A TRANSMISSION OIL LEAK. *TT UPDATED *EH Read More »
-
TSB #00704A
THE 4T65E AUTOMATIC TRANSMISSION MAY EXHIBIT A CONDITION OF A HARSH GARAGE SHIFT INTO REVERSE OR DRIVE ON A COLD START. *TT Read More »
-
TSB #030730017
GRIND NOISE OR NO VEHICLE MOVEMENT WHEN SHIFTING INTO DRIVE OR REVERSE. *TT Read More »
-
TSB #040601
SOME VEHICLES MAY EXPERIENCE NO FORWARD, DELAYED FORWARD, OR THE TRANSMISSION MAY LOCK UP IN REVERSE INTERMITTENTLY, SOME VEHICLES WILL NOT MOVE WHEN PLACED IN REVERSE INTERMITTENTLY. *SLC Read More »
-
TSB #260201
SOME VEHICLES EQUIPPED WITH THE 4T65E TRANSMISSION MAY EXPERIENCE A CONDITION WHERE THE FOURTH CLUTCH IS BURNT UP. *TT Read More »
-
TSB #010101
GM POWERTRAIN IS CURRENTLY SEEKING INFORMATION REGARDING 4T65E TRANSMISSIONS WITH A WHINE NOISE IN PARK AND NEUTRAL. *TT Read More »
-
TSB #020730048
PRESSURE CONTROL SOLENOID REPLACEMENT FOR 4T65-E, 4T40-E, AND 4T45-E TRANSAXLE/TRANSMISSION.*MR Read More »
-
TSB #010101
GM POWERTRAIN IS CURRENTLY SEEKING INFORMATION REGARDING RIGHT SIDE (PASSENGER) AXLE LEAKS ON THE 4T65E TRANSMISSION. *TT Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC-5050-A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIC4935E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #01574
INTERMITTENT ERRATIC INSTRUMENT PANEL CLUSTER (IPC) SWEEP WITH POSSIBLE ABS OR SIR LAMP ON. SIT BULLETIN 1413054. *MN UPDATED 8/12/09. *PE Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #02038
DIAGNOSTIC TROUBLE CODE B1000. *MR Read More »
-
TSB #030402
INFORMATION REGARDING PILOT PROGRAM - ELECTRICAL PROBLEMS. *TT Read More »
-
TSB #110501
SOME CUSTOMERS MAY COMMENT THAT THE INTERIOR AND / OR THE EXTERIOR LAMPS VARY IN INTENSITY (FLICKER). *TT Read More »
-
TSB #3042
BATTERY DRAIN ON VEHICLES EQUIPPED WITH POWER SLIDING DOORS. *TT Read More »
-
TSB #3571
POWER DOOR LOCK INOPERATIVE. *SC Read More »
-
TSB #PIC-4935-E
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. Read More »
-
TSB #01740
CROSS INJECTOR WIRES CAUSING MISFIRE AT STEADY STATE SPEED AND RPM, MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED, AND A P0300 SET. SIT BULLETIN 1460291. *TT Read More »
-
TSB #57
WIRE HARNESS MAY BE STRETCHED, OR THE PCS MAY NOT BE ORIENTED IN THE SAME POSITION, AFTER INSTALLING A SERVICE REPLACEMENT VALVE BODY ASSEMBLY. GM TECH LINK. *TT Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #030842007
TAIL LAMP/BRAKE LAMP BULB INOPERATIVE. *TT Read More »
-
TSB #010603005
SOME CUSTOMERS MAY COMMENT THAT THE INTERIOR AND / OR EXTERIOR LAMPS VARY IN INTENSITY (FLICKER). *TT Read More »
-
TSB #3136
DAYTIME RUNNING LAMPS (DRL) DISABLE OFFICIAL GOVERNMENT VEHICLES ONLY. *TC Read More »
-
TSB #020858005
CONCERNS WITH WIND NOISE AT THE BASE OF THE WINDSHIELD. *TT Read More »
-
TSB #050901
SOME VEHICLES MAY EXPERIENCE A WINDSHIELD ITCH TYPE NOISE. *SLC Read More »
-
TSB #110102
SOME VEHICLES HAVE ENCOUNTERED THE SITUATION WHERE THE PLUNGERS ON THE POWER SLIDING DOOR ARE GROUNDING OUT ON THE DOOR SKIN. *TT Read More »
-
TSB #000864007
SOME CUSTOMERS MAY COMMENT THAT THE FRONT DOOR GLASS IS SLOW OR NOISY WHEN MOVING UP OR DOWN OR THE WINDOW IS INOPERATIVE. *TT Read More »
-
TSB #99048
CONCERNS WITH A SOFTWARE ERROR IN THE POWER SLIDING DOOR CONTROL MODULE. *TT Read More »
-
TSB #141101
INFORMATION ON WIND NOISE FROM OUTSIDE REARVIEW MIRRORS. *TT Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #01507
SECOND ROW SEAT BELT WILL NOT RETRACT PASSENGERS SIDE. SIT BULLETIN 1403282. *TT Read More »
-
TSB #000940001
EXCESSIVE LATERAL MOVEMENT (SIDE TO SIDE) WHEN USING CERTAIN AFTERMARKET CHILD SEATS. THIS CONDITION OCCURS IN VEHICLES EQUIPPED WITH SECOND AND THIRD ROW BUCKET SEATS. *TT Read More »
-
TSB #072301
ON SOME VEHICLES THE SECOND ROW PASSENGER SEAT BELTS MAY EXPERIENCE A CONDITION WHERE THE SECOND ROW PASSENGER SIDE SEAT BELT WILL NOT RELEASE. *TT Read More »
-
TSB #00067
SUBJECT REGARDING PRODUCT SAFETY CAMPAIGN SEAT BELT BUCKLE CORRECTIONS AND CLARIFICATION. *JB Read More »
-
TSB #00067
CAMPAIGN PARTS BULLETIN FOR SEAT BELT BUCKLES THAT DO NOT MEET THE PULL TEST REQUIREMENT. *JB Read More »
-
TSB #00067
GENERAL MOTORS HAS DECIDED THAT CERTAIN VEHICLES HAVE SEAT BELT BUCKLES THAT DO NOT MEET THE PULL TEST REQUIREMENT. *JB Read More »
-
TSB #09-09-40-001A
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. Read More »
-
TSB #130701
SUBJECT REGARDING PROPER FUNCTIONING OF THE CHEST STRAP AND THE INTEGRAL CHILD SEATS. *TT Read More »
-
TSB #040402
SUBJECT REGARDING WIND NOISE WHILE DRIVING. *TT Read More »
-
TSB #190901
CUSTOMERS MAY COMPLAIN OF A WATER LEAK AT THE CENTER OF THE WINDSHIELD OR FROM THE OVERHEAD CONSOLE. *SLC Read More »
-
TSB #191000
SUBJECT REGARDING CONCERNS OF HARD STARTS CAUSED BY POOR CONTACT TO CONNECTOR SEAL C305, WIRING HARNESS SHAPES AT THE RADIATOR CORE SUPPORT, THE ACCUMULATOR STUD AND THE TRANSMISSION BELL HOUSING, STARTER RELAY BRANCH CHASE AT THE ... Read More »
-
TSB #01933
WATER LEAKS AT OVERHEAD CONSOLE MAP. *TT Read More »
-
TSB #01362
WATER LEAK INTO JACK COMPARTMENT WITH POWER SLIDING DOOR. *TT Read More »
-
TSB #030857003
FRONT CARPET WET AFTER EXTENDED DRIVING. *TT Read More »
-
TSB #020858003
SOME CUSTOMERS MAY COMMENT THAT ROAD NOISE CAN BE HEARD COMING FROM THE AREA BEHIND THE FRONT SEATS. *TT Read More »
-
TSB #020867006
SOME CUSTOMERS MAY COMMENT THAT THERE IS RUST FORMING AROUND THE FRONT OR REAR PORTION OF THE ROOF. *TT Read More »
-
TSB #020864011
SOME CUSTOMERS MAY COMMENT THAT THE POWER SLIDING DOOR WILL REVERSE ON CLOSING OR THE DOOR WILL APPEAR CLOSED, BUT THE ALARM WILL COME ON WHEN THE TRANSMISSION IS MOVED OUT OF PARK. *TT Read More »
-
TSB #050402
ISSUE REGARDING EXCESSIVE ROAD NOISE MOST PREVALENT IN THE SLIDING DOOR AREAS, LEFT, RIGHT OR BOTH. *TT Read More »
-
TSB #070102
SUBJECT REGARDING RECALL 01013 AND 01059 POWER SLIDING DOORS. *TT Read More »
-
TSB #010851004A
PREMATURE ALUMINUM HOOD CORROSION / BLISTERING. *TT Read More »
-
TSB #010851004
INFORMATION REGARDING PREMATURE ALUMINUM HOOD CORROSION. *YH Read More »
-
TSB #020867006B
ROOF PERFORATION. *TT Read More »
-
TSB #020864006A
ROOF PERFORATION. *TT Read More »
-
TSB #01854
POWER DOOR LOCKS INOPERATIVE. *MR Read More »
-
TSB #SB-10-08-50-003B
GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. Read More »
-
TSB #PIC5491J
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. Read More »
-
TSB #PIP5226A
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. Read More »
-
TSB #010846008B
INFORMATION ON UPGRADING FACTORY INSTALLED ONSTAR GENERATION 2.0 EQUIPPED VEHICLES TO GENERATION 2.6. *TT UPDATE. *TT Read More »
-
TSB #3047
99 THROUGH 05 YEAR VEHICLES, EQUIPPED WITH THREE-BUTTON ONSTAR SYSTEMS. *TT Read More »
-
TSB #01352
INFORMATION ON UPGRADING FACTORY INSTALLED ONSTAR GENERATION 2.0 EQUIPPED VEHICLES TO GENERATION 2.6. SUPPLEMENT TO 01-08-46-008. *TT Read More »
-
TSB #PIC5050A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. Read More »
-
TSB #PIC3278F
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. Read More »
-
TSB #08-089
BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. Read More »
-
TSB #000846004A
RE-ESTABLISHING COMMUNICATIONS WITH ONSTAR CENTER AFTER BATTERY DISCONNECT. ORIGINAL NOT YET RECEIVED. *TT Read More »
-
TSB #16NA260
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO ... Read More »
-
TSB #PIT5485B
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #PIT5389A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS. Read More »
-
TSB #PIT5485A
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE. Read More »
-
TSB #08089-B
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE Read More »
-
TSB #01045A
INFORMATION REGARDING ONSTAR GLOBAL POSITIONING SYSTEM (GPS) *JG Read More »
-
TSB #01045A
THIS CUSTOMER SATISFACTION CAMPAIGN INVOLVES VEHICLES EQUIPPED WITH A FACTORY OR DEALER INSTALLED ONSTAR SYSTEM. Read More »
-
TSB #010844005A
INFORMATION ON ERROR CODES ON RADIO DISPLAY THEIR CAUSE AND CORRECTIVE ACTION. *EH Read More »
-
TSB #000940001B
EXCESSIVE LATERAL MOVEMENT (SIDE TO SIDE) WHEN USING CERTAIN AFTERMARKET CHILD SEATS. THIS CONDITION OCCURS IN VEHICLES EQUIPPED WITH SECOND AND THIRD ROW BUCKET SEATS. INCLUDING THE 1997 - 1999 OPEL SINTRA. Read More »
-
TSB #020730022B
SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT Read More »
-
TSB #020730022A
SERVICE ENGINE SOON LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0716 AND / OR P0717, P0730, P0753, P0758, P1860, P1887 OR OTHER MISCELLANEOUS TRANSMISSION TROUBLE CODES SET. *TT Read More »
-
TSB #020730014A
INFORMATION ON SERVICING 4T65-E TRANSAXLE SPACER PLATE AND GASKETS FOR VARIOUS MODELS FROM 1997 THROUGH 2002. *TT Read More »
-
TSB #020730002
SOME CUSTOMERS MAY COMMENT THAT THE SERVICE ENGINE SOON (SES) INDICATOR IS ILLUMINATED AND THAT WHILE THE LIGHT IS ILLUMINATED, TRANSMISSION SHIFTS ARE EXTREMELY HARSH. *TT Read More »
-
TSB #020730014
INFORMATION ON SERVICING 4T65E TRANSAXLE SPACER PLATE AND GASKETS. *TT Read More »
-
TSB #000604037A
SOME CUSTOMERS MAY COMPLAIN THAT THE SERVICE ENGINE SOON (SES) INDICATOR IS ILLUMINATED WITH HARSH TRANSMISSION SHIFTS. *TT Read More »