Poorly designed sunroof drainage system (specifically drain nipple at end of tubing) causing severe leaks to inside cab along driver and passenger front doors and floor. Water damage to power windows, locks, mirrors. Water damage to ip to body harness connector under front driver side kick plate causing computer to produce false check engine codes related to app and forcing engine into reduced power mode at high speeds creating possibility for accidents.

- Oceanside, CA, USA

Received recall notice about 3 years ago regarding fuel tank. However, it specified certain states of origin. I disregarded notice since I was not residing in one of those states. My car periodically smells of gas, my check engine light and low performance light goes on/off and my mechanic suggested recall. My suspension issues have required replacement of bearing and sway bar on more than one occasion. My passenger airbag light stays on all the time and dings as a reminder every time I start my vehicle.

- Eastlake, OH, USA

Very strong odor of gas after car has been running. Have read there are recalls on this car but the VIN does not say it has one.

- Southaven, MS, USA

I starded smelling gas real strong when I got out of my car so I checked to see if there were a recall on it I found one on cartruckinfo.com so I called mcclinton dealership and told them what I found they said they didn't have a recall on it but they had something else that would cover it so I take it in after a while they call me tell me it's not covered because in has a salvage title and would coast me 2, ooo and something dollar's I live on $735 a month that is the only transportation I have

- Parkersburg, WV, USA

We notice a fuel odor while the vehicle is being driven or after it is parked. A crack has become large enough for fuel to be observed dripping onto the ground and vehicle performance has been affected. (#09275C)

- Crystal, MN, USA

The contact owns a 2007 Saturn Ion. While driving at any speed, the fuel tank leaked without warning. The dealer was not contacted and the manufacturer was not made aware of the failure. The failure was not diagnosed. The vehicle was not repaired. The failure mileage was 192,000.

- Crystal, MN, USA

Had to have fuel pump module replaced for exact problem as described in recalls of same model year Ion's but not for this VIN. Have retained photos and failed pump module assembly. Fuel odor from rt rr of vehicle first noted, then within days started dripping fuel from just in front of rt rr wheel well - found to be cracked pump module

- Racine, WI, USA

The contact owns a 2007 Saturn Ion. While the vehicle was parked, the contact noticed fuel leaking out of the vehicle onto the ground. On several other occasions, the contact noticed a strong fuel odor. The vehicle was taken to dick genthe Chevrolet (15600 eureka rd, southgate, mi 48195) where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and stated that the VIN was not included in NHTSA campaign number: 12V459000 (fuel system, gasoline). The approximate failure mileage was 174,000.

- Southgate, MI, USA

Same issue as your recall from 2012, the fuel module cracked and leaked gasoline. NHTSA campaign number: 12V459000 was your previous information and my car, although not included in the original recall, just had the same dangerous issue

- Cincinnati, OH, USA

My gas peddle sticks!

- South Holland, IL, USA

The contact owns a 2007 Saturn Ion. While idling, the vehicle experienced misfires and had an abnormal fuel odor. Additionally, the check engine and air bag warning indicators illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact referenced NHTSA campaign number: 09V419000 (fuel system, gasoline), but the VIN was excluded. The failure mileage was approximately 114,000.

- Ocala, FL, USA

Gas leaks only at the clip

- Cockeysville, MD, USA

Strong gas smell noticed outside the vehicle as it was parked. Two days later had the oil changed at a local shop and they pointed out there was gas leaking by the exhaust pipe area at a connection. Took to draper Chevrolet who locally handles Saturn recalls and was told the gas line needed to be replaced and not covered by special case scenario. The repair was quoted at $568. Repair has not been made. Leaking fuel is an immediate hazard if in the presence of an open flame or possible accidents. It appears there are a huge number of cases where the fuel line has leaked on this model. It should be covered.

- Saginaw, MI, USA

Fuel leaking from gas tank area, became aware when passenger cabin filled with fuel vapor, noticed gas smell for the past few years when walking near rear of vehicle fuel mileage has been terrible since vehicle was only 2 years old. Had vehicle into dealership and complained about mileage, I believe was loosing fuel for a long period of time before this major leak occurred. It made my wife and myself along with my family dog very sickly. Had into dealership 3 monts ago and was told there was no leak, but they failed to drop tank and inspect as per GM recall 09226. Now at another dealership and they are telling me I have to pay for the repair to gas tank/sending unit out of my own pocket. This is not what is stated on recall from GM global warranty management on bulletin 09226C dated July 19th 2015

- Whitby Ont Canada, NY, USA

The contact owns a 2007 Saturn Ion. The contact stated that there was premature rust and corrosion associated with the heat shield around the supply lines on the rear driver's side wheel. There were also strong fumes entering the vehicle due to the failure. The dealer stated that the supply and return lines needed to be replaced. The manufacturer had a service campaign for the fuel pump, but the remedy provided no solution. The manufacturer was notified of the failure and provided no solution. The approximate failure mileage was 74,000. Updated 02/22/2017 consumer stated the heat shield (fiberglass w/aluminium covering) was wrapped around both the fuel and brake lines where they run close to the exhaust by left rear wheel. It appears the brake lines weren't affected because of some type of black coating. Fuel lines were lightly plated with some type of metal and it didn't work very well. The heat shield created this problem. Updated 6/22/18

- O' Fallon, MO, USA

Entire fuel line from gas tank to engine needs to be replaced due to corrosion/rust. Gas is leaking near rear drivers side rear tire from fuel line. Material used for gas line should be non corrosion. My vehicle had fuel tank module recall done 12 months ago and now fuel lines need to be replaced. Fuel lines should never corrode since it may lead to fire.

- Triangle, VA, USA

The contact owns a 2007 Saturn Ion. The contact sated that the engine hesitated to start and the vehicle emitted a strong fuel odor. The contact took the vehicle to an independent for diagnostic testing, which located a fuel line leak at the rear driver side wheel area. The fuel line was found fractured due to corrosion. The vehicle was not repaired. The manufacturer was not notified. The approximate failure mileage was 115,000.

- Triangle, VA, USA

The contact owns a 2007 Saturn Ion. While driving various speeds, a fuel odor entered the vehicle. Upon further inspection, a fuel leak was discovered under the vehicle. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA campaign number: 12V459000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 109,000.

- St. Paul, MN, USA

The car wouldn't start right away after not running for awhile. It also smelled like gasoline. Upon taking it to the dealer, it was discovered there was a fuel leak and the fuel pump was replaced. After investigating recalls on the 2007 Saturn Ion I discovered a recall in effect for cars in certain states, Ohio was not one of them. The recall mentioned that it was for cars registered or sold in the "hot" states. The dealer wouldn't even let my daughter drive it while waiting for parts. This recall should have been more widespread.

- Bluffton, OH, USA

The contact owns a 2007 Saturn Ion. The contact had not experienced any failures with the vehicle until the dealer repaired it per a fuel pump assembly recall. Months later, the contact noticed strong fuel fumes emitting inside the vehicle. The manufacturer was not notified. The VIN was not available. The approximate failure mileage was 83,000.

- Orlando, FL, USA