2008 Toyota RAV4
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2008 RAV4 are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #T-TT-0255-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-TT-0255-13
Customer experiences a clunk, pop, or knock-type noise when turning the steering wheel left or right on a 2006-2008 RAV4. Read More »
-
TSB #T-TT-0223-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TSB-0318-08 REV1
TOYOTA: STEERING INTERMEDIATE SHAFT NOISE. MAY HEAR A CLUNK, POP, OR KNOCK TYPE NOISE WHEN TURN IN THE STEERING WHEEL LEFT OR RIGHT. A NEW INTERMEDIATE SHAFT HAS BEEN DEVELOPED TO ADDRESS THIS CONDITION. *PE UPDATED 5/22/2012. Read More »
-
TSB #T-TT-0223-13
The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. Read More »
-
TSB #TSB-0157-12
TOYOTA: PROCEDURAL INFORMATION PROVIDED FOR REAR TIE ROD ADJUSTMENT TO ASSURE PROPER SEQUENCE OF TIGHTENING AND USE WHENEVER PERFORMING TOE ADJUSTMENT DURING WHEEL ALIGNMENT. MODELS 2006-11 RAV4. Read More »
-
TSB #T-SB-0391-08 Obs
TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Read More »
-
TSB #T-SB-0381-09 Rev
TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Read More »
-
TSB #T-SB-0042-14
TSB: Safety Recall CSJ (?2006 ? 2011 RAV4; Rear Lower Suspension Arm No. 1?) involves inspection of the Rear Suspension Arm No. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #ER9_Remail_Regio
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
-
TSB #ER9_Remail_Deale
Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #T-SB-0080-13 Rev
TSB: Some 2006 - 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Read More »
-
TSB #TSB-0080-13
TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Read More »
-
TSB #T-SB-0042-14
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #TSB-0187-13
TOYOTA: THERE IS A CLUNKING NOISE HEARD COMING FROM REAR OF VEHICLE AND ONE OR BOTH REAR STABILIZER LINKS ARE DAMAGED. MODEL 2006-2012 RAV4. *PE Read More »
-
TSB #T-TT-0636-20 Rev
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #TTT063620
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #LSC BST Phase 3
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. Read More »
-
TSB #T-TT-0132-11
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. Read More »
-
TSB #T-SB-0014-22
TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Read More »
-
TSB #T-SB-0141-13
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #T-SB-0134-16
TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Read More »
-
TSB #BST-Region Lette
Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Region Lette
Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-TI-Smart Sto
Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #ZE7_Warranty Pol
Warranty Policy Bulletin (POL14-12): Added the Short Block Release Authorization Flow Chart. Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #POL14-12
WARRANTY POLICY BULLETIN (POL14-12): TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #Po-14-12l
Warranty Policy Bulletin (POL14-12): Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #T-TT-0372-15 REV
"TT: IN CERTAIN CASES, VEHICLES UNDERGOING THE ZE7 AZ OIL CONSUMPTION REPAIR PROCEDURE WILL REQUIRE A SHORT BLOCK REPLACEMENT. Read More »
-
TSB #ZE7_PHASE2 11/18
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_PHASE2 11/17
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #T-TT-0372-15
"TT: IN CERTAIN CASES, VEHICLES UNDERGOING THE ZE7 AZ OIL CONSUMPTION REPAIR PROCEDURE WILL REQUIRE A SHORT BLOCK REPLACEMENT. Read More »
-
TSB #ZE7_IMP 11/12
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
-
TSB #ZE7_Important Do
DD: In limited cases vehicles being serviced for ZE7 will require a replacement short block. Dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. Read More »
-
TSB #T-TT-0361-15 REV
"TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
-
TSB #T-SB-0030-15
"TSB: SOME 2006 ? 2013 MODEL YEAR VEHICLES EQUIPPED WITH THE 2AZ ENGINE MAY EXHIBIT ENGINE OIL CONSUMPTION. THE PISTON ASSEMBLY HAS BEEN CHANGED TO MINIMIZE OIL CONSUMPTION. USE THE FOLLOWING REPAIR PROCEDURE TO ADDRESS THIS CONDITION. Read More »
-
TSB #POL 14-12
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0353-15 REV
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
-
TSB #T-TT-0353-15 Rev
TT: There has been some concern with 3 Piece Ring installations for 2AZ-FE and 2AZ-FXE engines. This Tech Tip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #T-TT-0362-15
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
-
TSB #T-TT-353-15 REV1
TT: THERE HAS BEEN SOME CONCERN WITH 3 PIECE RING INSTALLATIONS FOR 2AZ-FE AND 2AZ-FXE ENGINES. THIS TECH TIP CONTAINS THE ACCEPTED INSTALLATION METHOD REQUIRED FOR TOYOTA VEHICLES. Read More »
-
TSB #T-TT-0361-15
TT: BASED ON CURRENT PART ORDER ALLOCATION, SOME PISTON TYPES HAVE BEEN INCORRECTLY IDENTIFIED WHILE UNDERGOING THE ZE7 2AZ OIL CONSUMPTION REPAIR PROCEDURE. Read More »
-
TSB #T-TT-353-15 Rev1
TT: There has been some concern with 3 Piece Ring installations for 2AZ-FE and 2AZ-FXE engines. This Tech Tip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #WPB (POL 14-12)_
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. TOYOTA IS NOW ANNOUNCING THE PART REPLACEMENT PHASE OF WARRANTY ENHANCEMENT PROGRAM ZE7 FOR VEHICLES EXHIBITING EXCESSIVE ENGINE OIL ... Read More »
-
TSB #T-TT-0086-11
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
-
TSB #ZE7_Service Cons
Warranty Enhancement: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive ... Read More »
-
TSB #ZE7_WEP_Region L
RL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_WEP_Dealer L
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_Dealer Daily
DD: Toyota has updated the Customer Handling Reference Guide to include the expansion vehicles; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #ZE7_Dealer Daily
DD: Toyota has updated the Customer Handling Reference Guide; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #ZE7_WEP_Warranty
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_Part Status
Electronic Communication: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of ... Read More »
-
TSB #ZE7_Part Status
Electronic Communication: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of ... Read More »
-
TSB #ZE7_Part Status
Electronic Communication: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of ... Read More »
-
TSB #ZE7_Part Status
Electronic Communication: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of ... Read More »
-
TSB #T-SB-0012-13 REV
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
-
TSB #TSB-0012-13 Rev2
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
-
TSB #ZE7_Region Lette
Region Letter: As part of our continual efforts to ensure the best in customer satisfaction, Lexus is preparing a Warranty Enhancement Program to extend warranty coverage to address customer compaints of Excessive Engine Oil Consumption ... Read More »
-
TSB #ZE7_Region Lette
Region Letter: As part of our continual efforts to ensure the best in customer satisfaction, Lexus is preparing a Warranty Enhancement Program to extend warranty coverage to address customer compaints of Excessive Engine Oil Consumption ... Read More »
-
TSB #ZE7_Dealer Lette
Dealer Letter: As part of our continual efforts to ensure the best in customer satisfaction, Lexus is preparing a Warranty Enhancement Program to extend warranty coverage to address customer compaints of Excessive Engine Oil Consumption ... Read More »
-
TSB #TC-14-036
TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES THE RUBBER OIL SUPPLY HOSE, FOR VVT-I ACTUATOR, IS DEGRADING OVER TIME AND CAUSING A LEAKAGE OF OIL, FROM OIL HOSE, PRODUCING AN ILLUMINATION OF OIL PRESSURE ... Read More »
-
TSB #T-TT-0010-10 Rev
Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft ... Read More »
-
TSB #TSB-0001-10
TOYOTA: UPDATED INFORMATION REGARDING THE RESPONSE OF THE AIR FUEL RATIO SENSOR, THAT IS INCORRECT AND ALSO, AN INCORRECT OXYGEN SENSOR OPERATION MAY BE PRESENT, DUE TO ECM/PCM PROCESSOR P0606 DTC. Read More »
-
TSB #TSB-0192-12
TOYOTA: INTAKE CAMSHAFT GEAR ASSEMBLY WAS IMPROVED TO PREVENT CONDITION OF ENGINE EXHIBITING INTERMITTENT MIL ON. MODEL 2006-2012 CAMRY, CAMRY HV, COROLLA, MATRIX, RAV4, SOLARA. *PE Read More »
-
TSB #T-PANT-2024-004-
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
-
TSB #G0Y Region Lette
Region Letter Email: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (Cold Climate ... Read More »
-
TSB #G0Y Dealer Packa
Dealer Package Email: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate ... Read More »
-
TSB #G0Y Dealer Packa
Dealer Package: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate ... Read More »
-
TSB #G0Y TI RAV4 0119
Technical Instructions: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate ... Read More »
-
TSB #ZE7 Phase 2 POL1
Warranty Policy Bulletin: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #T-TT-0372-15 Rev
TT: In certain cases, vehicles undergoing the ZE7 AZ Oil Consumption repair procedure will require a short block replacement. Read More »
-
TSB #ZE7_Phase 2_Warr
WPB: The engine is covered under the Toyota New Vehicle Limited Warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). Read More »
-
TSB #ZE7_Phase 2_Warr
WPB: The engine is covered under the Toyota New Vehicle Limited Warranty for 5 years from the date of first use or 60,000 miles (whichever occurs first). Read More »
-
TSB #T-TT-0372-15
TT: In certain cases, vehicles undergoing the ZE7 AZ Oil Consumption repair procedure will require a short block replacement. Read More »
-
TSB #T-TT-0361-15 Rev
TT: Based on current part order allocation, some piston types have been incorrectly identified while undergoing the ZE7 2AZ Oil Consumption repair procedure. Read More »
-
TSB #T-SB-0030-15
TSB: Some 2006 - 2013 model year vehicles equipped with the 2AZ engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #ZE7_Phase 2_WPB(
WPB: Toyota has received some reports where the vehicles may exhibit excessive engine oil consumption. Read More »
-
TSB #T-TT-0361-15
TT: Based on current part order allocation, some piston types have been incorrectly identified while undergoing the ZE7 2AZ Oil Consumption repair procedure. Read More »
-
TSB #WPB (POL 14-12)_
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excessive engine oil ... Read More »
-
TSB #T-TT-0353-15
TechTip: Condition - There has been some concern with 3 Piece Piston Ring installations for 2AZ-FE and 2AZ-FXE engines. This TechTip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #T-TT-0353-15
TechTip: Condition - There has been some concern with 3 Piece Piston Ring installations for 2AZ-FE and 2AZ-FXE engines. This TechTip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #ZE7_Service Cons
Warranty Enhancement: BACKGROUND As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive ... Read More »
-
TSB #ZE7_Warranty Enh
EC: Currently the Reair Kit for RAV4 Vehicles PN: 04004-11828 is missing exhaust gasket 90917-06078 at this time to supplement this kit contents. The warranty system has been modified to accept this additional required part. Read More »
-
TSB #ZE7_Service Cons
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_Service Cons
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_WPB_WEP_Publ
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excessive engine oil ... Read More »
-
TSB #ZE7_WPB_WEP_Publ
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excessive engine oil ... Read More »
-
TSB #T-SB-0030-15
TSB: NOTE-Service Bulletin No. T-SB-0158-14, "2AZ Engine Oil Consumption Inspection Procedure," MUST be performed first BEFORE continuing with the procedure in this bulletin. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0030-15. Read More »
-
TSB #T-SB-0030-15
TSB: NOTE-Service Bulletin No. T-SB-0158-14, "2AZ Engine Oil Consumption Inspection Procedure," MUST be performed first BEFORE continuing with the procedure in this bulletin. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0030-15. Read More »
-
TSB #ZE7_WEP_Region L
RL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_WEP_Dealer L
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota has announced a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on ... Read More »
-
TSB #ZE7_POL14-12_WEP
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_POL14-12_WEP
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_WEP_Warranty
WPB: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. This Warranty Enhancement Program will be launched in two phases due to current part production capacity limitations. Read More »
-
TSB #ZE7_VIN Expansio
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota is preparing a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on Certain ... Read More »
-
TSB #ZE7_VIN Expansio
DL: As part of our continual efforts to ensure the best in customer satisfaction, Toyota is preparing a Warranty Enhancement Program to extend warranty coverage to address customer complaints of Excessive Engine Oil Consumption on Certain ... Read More »
-
TSB #T-SB-0158-14 Rev
TSB: Some 2006 - 2013 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0158-14 Rev
TSB: Some 2006 - 2013 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0158-14 Rev
TSB: Some 2006-2011 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles have equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles have equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #ZE7_WEP_Updated_
EC: The Tamper Tape recommended for the 2AZ-FE Engine Oil Consumption Inspection Procedure found in T-SB-0158 (Toyota) and S-SB-0031-14 (Scion) is now available at the MDC. Read More »
-
TSB #ZE7_WEP_Updated_
EC: The Tamper Tape recommended for the 2AZ-FE Engine Oil Consumption Inspection Procedure found in T-SB-0158 (Toyota) and S-SB-0031-14 (Scion) is now available at the MDC. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #T-SB-0094-11 Rev
TSB: Some 2006 - 2011 model year vehicles equipped with the 2AZ-FE engine may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Use the following Repair Procedure to address this condition. Read More »
-
TSB #ZE7_Electronic C
Electronic Communication: Toyota recently released T-SB-0158-14 and S-SB-0031-14 to provide an inspection procedure and signoff sheet for excessive engine oil consumption testing on 2AZ engine models. Read More »
-
TSB #ZE7_Dealer Lette
Dealer Letter: As part of our continual efforts to ensure the best in customer satisfaction, Lexus is preparing a Warranty Enhancement Program to extend warranty coverage to address customer compaints of Excessive Engine Oil Consumption ... Read More »
-
TSB #T-SB-0158-14
TSB: Some 2006-2011 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #T-SB-0158-14
TSB: Some 2006-2011 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #90K_LSC_Extensio
Region Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. Read More »
-
TSB #90K_LSC_Extensio
Dealer Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. Read More »
-
TSB #TSB-0056-11
TOYOTA: 2006-2008 RAV4. ABNORMAL NOISE FROM THE IDLER PULLEY ASSEMBLY. *RM Read More »
-
TSB #TSB-0047-10
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #TSB-0111-10
TOYOTA: 2AZ-FE & 2AZ-FXE THROTTLE BODY. ENGINE CONTROL. PROVIDE UPDATED THROTTLE BODY PART NUMBER INFORMATION FOR CERTAIN VEHICLES. THE DRAIN PIPE HAS BEEN ELIMINATED ON THROTTLE BODY SERVICE PARTS. Read More »
-
TSB #TC-10-010
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN MODEL VEHICLES EQUIPPED WITH A 2GR-FE (VE) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #LSC-90-K
TOYOTA: ON CERTAIN MODEL VEHICLES,EQUIPPED WITH A 2GR-FE (VE) ENGINE, AN INITIATED PHASE 3 WILL REPLACE THE VVT-I OIL HOSE DUE TO THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #TSB-0064-10
TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. Read More »
-
TSB #TSB-0184-09
TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
-
TSB #TSB-0094-09
TOYOTA: SOME VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A TICKING/CLICKING TYPE NOISE FROM THE CYLINDER HEAD COVER AREA WHICH MAY BE ACCOMPANIED BY A MIL ON AND ONE OR MORE VVT-I RELATED DIAGNOSTIC TROUBLE CODES (DTCS). Read More »
-
TSB #T-PANT-2024-004-
This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. Read More »
-
TSB #T-TT-0468-17 Rev
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #T-TT-0628-20
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #T-SB-0033-14
Some vehicles in particular geographic areas may exhibit a condition where the HVAC Evaporator Drain Hose has become obstructed with an insect nest. Read More »
-
TSB #G0Y_Dealer Daily
Dealer Daily: An additional inspection-only opcode for aftermarket mufflers has been added. Read More »
-
TSB #ZE7_Warranty Enh
EC: Currently the Reair Kit for RAV4 Vehicles PN: 04004-11828 is missing exhaust gasket 90917-06078 at this time to supplement this kit contents. The warranty system has been modified to accept this additional required part. Read More »
-
TSB #DOR-M3J3F-07
These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. Read More »
-
TSB #DOR-M9J4S-07
These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. Read More »
-
TSB #G0Y_Dealer Packa
Dealer Package: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate ... Read More »
-
TSB #G0Y_TI_RAV4_02.2
Technical Instructions: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate ... Read More »
-
TSB #TSB-0046-10
TOYOTA: MIL ON; FUEL IN EVAP SYSTEM. SOME VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS DUE TO FUEL IN THE EVAP SYSTEMS: MIL ON WITH THE FOLLOWING DTCS STORED: P043E, P043F, P2401, P2401, AND P2419; INTERMITTENT ROUGH ... Read More »
-
TSB #TSB-0046-10
TOYOTA: MIL ON; FUEL IN EVAP SYSTEM. SOME VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS DUE TO FUEL IN THE EVAP SYSTEMS: MIL ON WITH THE FOLLOWING DTCS STORED: P043E, P043F, P2401, P2401, AND P2419; INTERMITTENT ROUGH ... Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #T-SB-0080-13 REV
TSB: SOME 2006 - 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #T-SB-0080-13 Rev
TSB: Some 2006 - 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Read More »
-
TSB #ZF4_DEALER 12/3
"DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #ZF4_DEALERD 12/3
"DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #POL15-04
WPB: IN CERTAIN 2006 TO 2012 MODEL YEAR RAV4 4WD VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #ZF4-Dealer Daily
DD: In our continuing efforts to help ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Rear Differential Coupling Growl Noise on 2006-2012 model year RAV4 ... Read More »
-
TSB #ZF4-WPB POL15-04
WPB: In certain 2006 to 2012 model year Rav4 4WD vehicles, Toyota has received some reports where the vehicle may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Read More »
-
TSB #T-TT-0086-11
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
-
TSB #T-SB-0134-14
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
-
TSB #LSC BST Phase 3
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. Read More »
-
TSB #T-SB-0071-11 Rev
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Read More »
-
TSB #T-SB-0391-08 Rev
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Read More »
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
-
TSB #T-SB-0014-11 Rev
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
-
TSB #T-SB-0260-08 Rev
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Read More »
-
TSB #T-SB-0134-14
TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Read More »
-
TSB #T-SB-0200-08 Rev
TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions. Read More »
-
TSB #TSB-0047-10
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. Read More »
-
TSB #TSB-0184-09
TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). Read More »
-
TSB #T-SB-0006-11 Rev
TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Read More »
-
TSB #T-SB-0014-11 Rev
TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Read More »
-
TSB #T-SB-0080-13 REV
TSB: SOME 2006 - 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #ZF4_DEALER 12/3
"DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #ZF4_DEALERD 12/3
"DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 ... Read More »
-
TSB #POL15-04
WPB: IN CERTAIN 2006 TO 2012 MODEL YEAR RAV4 4WD VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. Read More »
-
TSB #ZF4-Dealer Lette
DL: In our continuing efforts to help ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Rear Differential Coupling Growl Noise on 2006-2012 model year RAV4 ... Read More »
-
TSB #TSB-0080-13
TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Read More »
-
TSB #T-SB-0080-13
Some 2006 ? 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Read More »
-
TSB #T-SB-0057-18
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0134-16-Rev
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. Read More »
-
TSB #T-SB-0229-12_Rev
TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #TSB018217
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. Read More »
-
TSB #T-SB-0134-16
TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Read More »
-
TSB #BST-Region Lette
Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Region Lette
Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-TI-Smart Sto
Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #ZE7_Important Do
DD: In limited cases vehicles being serviced for ZE7 will require a replacement short block. Dealers will need to install the dowel pins between the short block and lower crankcase when performing this repair. Read More »
-
TSB #T-TT-0360-15
TT: Customers may experience connectivity issues when the following conditions are met: The customer's iPhone is operating on iOS9 firmware. The customer's iPhone is connected to the vehicle via Bluetooth. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
-
TSB #T-SB-0012-13 REV
"TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #T-TT-0223-13
The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. Read More »
-
TSB #T-TT-0226-13
The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Read More »
-
TSB #T-TT-0362-15
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
-
TSB #T-TT-0086-11
TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Read More »
-
TSB #T-TT-0118-11 Rev
technicians should confirm the following key points to minimize the potential for future MIL "ON" concerns after HV Battery Replacement. Read More »
-
TSB #TSB-0047-09
TOYOTA: MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER VEHICLE HAS COLD SOAKED IN SUBFREEZING AMBIENT AIR TEMPERATURES. Read More »
-
TSB #T-SB-0012-13 Rev
TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Read More »
-
TSB #T-TT-0381-16
Tech Tip: Some customers may experience difficulty programming HomeLink. Read More »
-
TSB #T-TT-0355-15
TechTip: Condition: Customers may experience connectivity issues when the following conditions are met: The customer?s iPhone is operating on iOS9 firmware The customer?s iPhone is connected to the vehicle via Bluetooth. Read More »
-
TSB #T-TT-0355-15
TechTip: Condition: Customers may experience connectivity issues when the following conditions are met: The customer?s iPhone is operating on iOS9 firmware The customer?s iPhone is connected to the vehicle via Bluetooth. Read More »
-
TSB #TSB-0012-13 Rev2
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
-
TSB #T-SB-0012-13 Rev
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
-
TSB #T-SB-0012-13
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
-
TSB #T-SB-0064-10 Rev
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. Read More »
-
TSB #T-SB-0185-13
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Read More »
-
TSB #TS-BO030-01 Obso
This bulletin is now obsolete. Please see T-SB-0185-13. Read More »
-
TSB #T-TT-0269-13
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #T-SB-0094-21 Rev
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #Toyota Safety Re
Toyota Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-SB-0218-17_Rev
TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Read More »
-
TSB #HR1_Region Lette
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
-
TSB #HR1_Dealer Lette
Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Read More »
-
TSB #T-TT-0213-13
Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. Read More »
-
TSB #T-SB-0122-11 Rev
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
-
TSB #T-TT-0213-13
Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. Read More »
-
TSB #TSB-0122-11
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #Z2G_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #Z3G_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #Support Program
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #T-SB-0094-21
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #ZKG Important Up
DL: CUSTOMER SUPPORT PROGRAM ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #Customer Support
Dealer Daily Message: ***Phase 2 ? Customer Renotification and Repair Phase*** Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of ... Read More »
-
TSB #ZKG_Region Email
Region Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Region Lette
Region Letter: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Dealer Email
Dealer Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Dealer Packa
Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Paint Repair
Repair Process: Customer Support Program ZKG ? Paint Repair Process. Read More »
-
TSB #ZKG_Technical In
Technical Instructions: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Phase 2 ? Customer Renotification and Repair Phase Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super ... Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Technical_In
TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied ... Read More »
-
TSB #ZKG_Dealer Email
Dealer Email: Phase 1 - Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Dealer Packa
Dealer Package: Phase 1 - Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Dealer Packa
Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Region Email
Region Email: Phase 1 - Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Region Lette
Region Letter: Phase 1 ? Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #T-SB-0040-08
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
-
TSB #T-SB-0040-08
TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. Read More »
-
TSB #T-SB-0187-12
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. Read More »
-
TSB #T-SB-0304-17
TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria ... Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #LSC BST Phase 3
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. Read More »
-
TSB #LSC BST Phase 1.
On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. Read More »
-
TSB #LSC BST Phase 2
On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. Read More »
-
TSB #LSC BST Phase 2
On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. Read More »
-
TSB #LSC BST Phase 3
As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. Read More »
-
TSB #LSC BST Phase 1.
On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. Read More »
-
TSB #TSB-0087-12
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #T-SB-0187-12_Rev
TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Read More »
-
TSB #T-SB-0187-12_Rev
TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Read More »
-
TSB #T-SB-0187-12 Rev
Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. Read More »
-
TSB #T-TT-0124-11
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-TT-0124-11
Please refer to the following recommendations for the best practices for vehicle tire rotations. Read More »
-
TSB #T-SB-0187-12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #11607
TIRE PRESSURE WARNING VALVE/SENSOR ACTIVATION. *KB Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #T-SB-0063-20
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Read More »
-
TSB #T-SB-0381-09 Rev
TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Read More »
-
TSB #T-SB-0122-11 Rev
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
-
TSB #TSB-0122-11
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Read More »
-
TSB #T-SB-0187-13
Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Read More »
-
TSB #TTT063620
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Read More »
-
TSB #T-TT-0636-20 Rev
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0636-20
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Read More »
-
TSB #T-TT-0010-10 Rev
Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft ... Read More »
-
TSB #T-SB-0187-13
Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Read More »
-
TSB #T-SB-0001-10 Rev
Some vehicles may exhibit a MIL ?ON? Diagnostic Trouble Code (DTC) P0138 and/or P0158 (Oxygen Sensor Circuit High Voltage Bank 1 or 2). In some instances a P2195 or P2197 (A/F Sensor Signal Stuck Lean) DTC may also be present. Read More »
-
TSB #T-SB-0141-10 Rev
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield ... Read More »
-
TSB #TSB003220
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the ... Read More »
-
TSB #T-SB-0057-18
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #ZKG_Paint_Repair
CSP: Customer Support Program ZKG - Paint Repair Process Operation Flow Chart Read More »
-
TSB #T-SB-0032-20 Rev
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the ... Read More »
-
TSB #ZKG_Dealer_Lette
TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied ... Read More »
-
TSB #ZKG_Proper_Photo
ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Technical_In
TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied ... Read More »
-
TSB #T-SB-0304-17 Obs
TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Read More »
-
TSB #T-SB-0032-20
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. Read More »
-
TSB #T-SB-0142-13_Obs
OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20. Read More »
-
TSB #T-SB-0010-20
TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-SB-0008-20
TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Read More »
-
TSB #ZKG_Dealer Packa
Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. Read More »
-
TSB #ZKG_Technical In
Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition ... Read More »
-
TSB #KR3_Region Email
Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Read More »
-
TSB #KR3_Region Lette
Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Read More »
-
TSB #KR3_Dealer Email
Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Read More »
-
TSB #KR3_Dealer Packa
Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Read More »
-
TSB #G0Y_JR8_Region E
Region Email: Toyota will be sending Safety Recall and Special Service Campaign follow-up notices to owners whose vehicles have not yet had the following Safety Recall or Special Service Campaign repairs completed. Read More »
-
TSB #G0Y_JR8_Dealer E
Dealer Email: Safety Recall and Special Service Campaign completion is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #G0Y_JR8_Region L
Region Letter: Toyota will be conducting Safety Recall and Special Service Campaign follow-up notifications to owners whose vehicles have not yet had the following Safety Recall or Special Service Campaign repairs completed. Read More »
-
TSB #G0Y_JR8_Dealer P
Dealer Packet: Safety Recall and Special Service Campaign completion is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #PG004-97-Obsolet
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Read More »
-
TSB #PG006-01-Obsolet
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Read More »
-
TSB #T-SB-0304-17_Rev
TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #T-SB-0057-18
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. Read More »
-
TSB #T-SB-0304-17_Rev
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. Read More »
-
TSB #G0Y Dealer Daily
Dealer Daily: Special Service Campaign G0Y dealer letter and technical instructions now available on TIS. Read More »
-
TSB #BST-Region Lette
Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Region Lette
Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-TI-Smart Sto
Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #Safety Recall an
Update on Technician Certification Requirements. Read More »
-
TSB #POL14-12
WARRANTY POLICY BULLETIN (POL14-12): TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0381-16
TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Read More »
-
TSB #ZE7_PHASE2 11/18
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_PHASE2 11/17
"WPB: THE ENGINE IS COVERED UNDER THE TOYOTA NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS FROM THE DATE OF FIRST USE OR 60,000 MILES (WHICHEVER OCCURS FIRST). Read More »
-
TSB #ZE7_IMP 11/12
DD: IN LIMITED CASES VEHICLES BEING SERVICED FOR ZE7 WILL REQUIRE A REPLACEMENT SHORT BLOCK. DEALERS WILL NEED TO INSTALL THE DOWEL PINS BETWEEN THE SHORT BLOCK AND LOWER CRANKCASE WHEN PERFORMING THIS REPAIR. Read More »
-
TSB #POL 14-12
WPB: TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #T-TT-0353-15 Rev
TT: There has been some concern with 3 Piece Ring installations for 2AZ-FE and 2AZ-FXE engines. This Tech Tip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #T-TT-0360-15
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
-
TSB #T-TT-353-15 Rev1
TT: There has been some concern with 3 Piece Ring installations for 2AZ-FE and 2AZ-FXE engines. This Tech Tip contains the accepted installation method required for Toyota vehicles. Read More »
-
TSB #T-TT-0361-15
TT: Based on current part order allocation, some piston types have been incorrectly identified while undergoing the ZE7 2AZ Oil Consumption repair procedure. Read More »
-
TSB #ZE7_WEP_Customer
DD: Toyota has updated the Customer Handling Reference Guide to include the expansion vehicles; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #ZE7_Dealer Daily
DD: Toyota has updated the Customer Handling Reference Guide to include the expansion vehicles; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #ZE7_Dealer Daily
DD: Toyota has updated the Customer Handling Reference Guide; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #ZE7_Electronic C
Electronic Communication: Toyota recently released T-SB-0158-14 and S-SB-0031-14 to provide an inspection procedure and signoff sheet for excessive engine oil consumption testing on 2AZ engine models. Read More »
-
TSB #ZE7_Electronic C
Electronic Communication: Toyota recently released T-SB-0158-14 and S-SB-0031-14 to provide an inspection procedure and signoff sheet for excessive engine oil consumption testing on 2AZ engine models. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #ER11_Re-Notifica
Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Read More »
-
TSB #TC-14-032
TOYOTA: ON SOME VEHICLES, INFORMATION BEING SENT OUT REGARDING INSTALLATION OF SMART STOP TECHNOLOGY. MODEL YEARS 2003-2010 COROLLA, COROLLA MATRIX, LAND CRUISER, HIGHLANDER RAV4, 4RUNNER, TUNDRA. Read More »
-
TSB #T-TT-0132-11
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. Read More »
-
TSB #T-SB-0122-11 Rev
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers ... Read More »
-
TSB #T-SB-0141-13
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. Read More »
-
TSB #T-SB-0054-13
California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Read More »
-
TSB #T-SB-0093-09 Rev
A revised procedure has been developed to ensure proper removal and installation of the sun visor. Please use the following procedure for removal and installation of the sun visor. Read More »
-
TSB #BST-Region Lette
Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Region Lette
Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-Dealer Packa
Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #BST-TI-Smart Sto
Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Read More »
-
TSB #T-SB-0043-14 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0043-14 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0101-11 Rev
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Read More »
-
TSB #T-SB-0043-14 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-SB-0043-14
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Read More »
-
TSB #T-TT-0360-15
TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER'S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER'S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. Read More »
-
TSB #T-TT-0360-15
TT: Customers may experience connectivity issues when the following conditions are met: The customer's iPhone is operating on iOS9 firmware. The customer's iPhone is connected to the vehicle via Bluetooth. Read More »
-
TSB #T-TT-0268-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-TT-0226-13
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #PG004-97-Obsolet
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Read More »
-
TSB #PG006-01-Obsolet
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Read More »
-
TSB #T-PG006-00 Obsol
This bulletin is now obsolete. Please see T-SB-0054-13. Read More »
-
TSB #T-SB-0043-14
OBSOLETE NOTICE January 22, 2024: This bulletin is now obsolete. Please see T-SB-0057-18. Read More »
-
TSB #TSB009421Rev1
TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. Read More »
-
TSB #Toyota PRO19-02
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. Read More »
-
TSB #T-SB-0040-08 Obs
OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16. Read More »
-
TSB #TSR-1212-17
Technician Certification Requirements. Read More »
-
TSB #T-SB-0134-16_Rev
TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Read More »
-
TSB #T-SB-0218-17_Rev
TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Read More »
-
TSB #ZE7
WARRANTY POLICY BULLETIN (POL14-12): ADDED THE SHORT BLOCK RELEASE AUTHORIZATION FLOW CHART. TOYOTA HAS RECEIVED SOME REPORTS WHERE VEHICLES MAY EXHIBIT EXCESSIVE ENGINE OIL CONSUMPTION. Read More »
-
TSB #Safety Recall an
Update on Technician Certification Requirements. Read More »
-
TSB #ZE7_WEP_Customer
DD: Toyota has updated the Customer Handling Reference Guide to include the expansion vehicles; please refer to TIS for the most current version. All previous versions of this document should be discarded. Read More »
-
TSB #T-SB-0158-14
TSB: Some 2006-2011 model year vehicles equipped with 2AZ-FE or 2AZ-FXE engines may exhibit engine oil consumption. The piston assembly has been changed to minimize oil consumption. Read More »
-
TSB #BST_Renotificati
Region Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Read More »
-
TSB #BST_Renotificati
Dealer Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Read More »
-
TSB #LSC BST Phase 1.
On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. Read More »
-
TSB #T-TT-0255-13
While performing T-SB-0318-08, this document should be used to help supplement which parts to order prior to performing the repair. Read More »
-
TSB #TSR-13V383
TOYOTA/LEXUS: INFORMATION REGARDING DEALER RE-NOTIFICATION, ON CERTAIN VEHICLES, OF REMEDY INSTRUCTIONS (DVD) VIA SEPARATE COVER. MODELS 2006-2011 RAV4, 2010 HS250TH. *PE Read More »
-
TSB #TC13-019
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #Renotification (
Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #Renotification (
Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Read More »
-
TSB #T-SB-0033-13
Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. Read More »
-
TSB #SST Requirements
SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Read More »
-
TSB #T-SB-0064-10 Rev
This bulletin is now obsolete. Please see T-SB-0012-13. Read More »
-
TSB #T-SB-0192-12
Some 2006 ? 2012 model year vehicles equipped with the 2AZ engine may exhibit an intermittent MIL ?ON? condition with Diagnostic Trouble Code (DTC) P0335 (Crankshaft Position Sensor ?A? Circuit) stored. Read More »
-
TSB #T-PG007-01
Replacement vin plates. Read More »
-
TSB #T-PG002-91
Product general information. Read More »
-
TSB #ZKG_Dealer_Lette
TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied ... Read More »
-
TSB #ZKG_Proper_Photo
ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Read More »
-
TSB #ZKG_Dealer_Lette
DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. Read More »
-
TSB #ZKG_Technical In
Technical Instructions: December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. Read More »
-
TSB #ZKG_Dealer Packa
Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. Read More »
-
TSB #ZKG_Technical In
Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition ... Read More »
-
TSB #T-SB-0080-19
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
-
TSB #T-SB-0080-19 Rev
TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. Read More »
-
TSB #T-SB-0080-19
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. Read More »
-
TSB #T-TT-0468-17-Rev
TT: HVAC drain tube is found to be blocked/clogged. Read More »
-
TSB #T-SB-0033-14_Rev
TSB: Some vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. Read More »
-
TSB #T-SB-0033-14_Rev
TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 - 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Read More »
-
TSB #T-SB-0142-13 Rev
TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Read More »
-
TSB #T-SB-0083-13 Rev
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
-
TSB #T-SB-0083-13 Rev
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Read More »
-
TSB #T-SB-0142-13 Rev
TSB: Some 2004 - 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-SB-0142-13 Rev
TSB: Some 2004 - 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-TT-0051-10
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #T-SB-0142-13
Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Read More »
-
TSB #T-SB-0141-10 Rev
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield ... Read More »
-
TSB #T-SB-003-01 - OB
TSB: OBSOLETE NOTICE: July 7, 2014: This bulletin is now obsolete. Read More »
-
TSB #13707
FLOOR MAT INSTALLATION DURING (PDS) PRE-DELIVERY SERVICE. *NJ Read More »
-
TSB #00207
TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. *KB Read More »