On two occasions as of this date, the engine just shut off while driving my 2016 Toyota RAV 4 XLW AWD. My daughter was able to get to the side of the road when it happened while she was driving thankfully (in a 25 or 30MPH zone). Additionally, at times the vehicle won't start when sitting parked and operating the push to start. It takes several tries, the vehicle just makes a clicking noise. After a short time, it starts up like nothing happened. I took the vehicle into a Toyota dealer and explained the issue. They said they found nothing wrong. There is seriously something wrong with this vehicle and no one seems to be able to figure it out...until someone dies. I've read several similar issues on this site that included incidents with fire and smoke. There needs to be a recall. Now! Or, a class action suit. Now!

- Milwaukee, WI, USA

I took my car to Toyota for multiple issues with my electrical. My headlights go out every 5-10 minutes when trying to drive at dark. The headlights turn off or do not work if I try to use my blinker or windshield wipers. Three times now my car has stalled when I tried to turn on my headlights while driving. And one time it stalled when I went to make a left turn. Toyota ran a diagnostic and said everything was fine. I took it to autozone, they said the battery was fine. A third opinion and a new battery later and I-??m still having the same problems. No one can tell me what-??s wrong.

- Buffalo, NY, USA

The car rapidly caught on fire while parked and off. Smoke first appeared from the hood and subsequently flames came out of the hood causing the entire car to catch in fire. There were no warning lights/messages. The car was inspected by our insurance, USAA

- Durham, NC, USA

While my wife was driving the car it suddenly shutoff. She was in the middle of a turn and was able to get to the side of the road. I few moments later she saw what she assumed was steam coming from under the hood and she immediately got out of the car. Within a minute of getting out of the car she saw flames dripping down from the engine. She called the fire department who put the flames out, but the car is most likely totaled. The fire department told her it looked like the battery exploded. I want to make sure you are aware of this as I see you have had other complaints.

- Vero Beach, FL, USA

I was driving from Ft Myers to Tallahassee on I-have 75 in Florida on March 8, 2022. All of a sudden, I heard the Lane Departure Assist go off in my car (which I had previously turned off because the alert is annoying) and my phone stopped working (it was plugged into a USB port in the car playing a podcast). A few minutes later, I stopped at a rest area and noticed my trip odometers had reset and a bunch of other settings I had previously set in my car had also reset back to factory settings, such as the cruise control settings, blind spot monitor, and parking assist. There might be more...I just haven't noticed those yet. When I got back home, I saw an envelope from Toyota titled, "12-Volt Battery Size and Installation Inspection Consumer Advisory." I did get my battery replaced in Winter 2020 by a non-Toyota dealer so now I'm wondering if that has anything to do with this Consumer Advisory.

- Kalamazoo, MI, USA

- I believe the ECM has failed, and I believe this after replacing battery, starter, spark plugs, and spark plug wires. While accelerating, and while maintaining a consistent speed over 50 mph, the tachometer (and engine, accordingly) yanks itself back and forth between 3500 and 5500 rpm. The vehicle physically jumps back and forth between massive acceleration and decceleration, without any change in throttle/pedal placement. This occurs while in Cruise Control, Eco Mode, Normal Mode, and Sport Mode. There is not yet a discernable pattern or trigger identified in why this occurs. - My safety and the safety of others has been put at risk by the vehicle's jerking, halting, and unplanned acceleration in heavy traffic situations. It scares me and others in traffic, to the point that people have asked if I was okay after being able to visibly notice the car's behavior on the highway, and my reaction. - The problem has been reproduced twice by an independent service center. Toyota Dealership read the computer for the vehicle to pull codes, told me nothing was wrong, and sent me away. - The vehicle has been inspected by my local Toyota dealership (lackluster inspection, in my opinion). Nothing resulted from this inspection. - There were (and still are) NO warnings lamps, messages, reminders, codes, or notifications of any kind to show that something is abnormal in my engine. This is the most vexing part of this issue. As far as the computer in the Rav4 is concerned, everything is nearly perfect. and it IS NOT.

- Marietta, GA, USA

Our 2016 Rav4 produced a loud clunk then lost power (after being drive 5-10 minutes) and came to a complete stop. The engine would not turn over nor the car power come back on. White smoke began within 30 seconds of losing power and within one minute flames began shooting out under the driver's side upper hood.

- Pflugerville, TX, USA

The contact owns a 2016 Toyota Rav4. The contact stated that while her husband was stopped at a traffic light, he started smelling an abnormal burning odor before flames started coming up from under the dashboard and out of the driver's and passenger's side vents. The driver pulled over and started pouring water from a cooler onto the fire to try to extinguish the flames however, the flames reignited. Another motorist pulled over to assist and disconnected the battery. A business owner also stopped by, and extinguished the flames with a fire extinguisher. The fire department arrived however, the fire was already extinguished. A police report was filed. The driver stated that a fire report was not filed. The contact stated that the dashboard was destroyed. The driver sustained burns on both hands however, medical attention was not sought. The driver contacted fiesta Kia (7400 lomas blvd ne, albuquerque, nm 87110, (505)999-2700) where the vehicle had been purchased only 22 days earlier. The dealer arrived at the scene and the vehicle was towed to the dealer where it remained still unrepaired. The insurance provider was contacted and informed the driver that a fire investigator would be sent out to inspect the vehicle, which was still pending. The vehicle was not repaired. The insurance provider had not yet decided whether or not the vehicle was a total loss. The manufacturer was not contacted or informed of the failure. The failure mileage was 52,000.

- Rancho, NM, USA

The contact owns a 2016 Toyota Rav4. The contact stated that the key fob failed to start the vehcile. Additionally, the rear brake lights were filled with water and were inoperable. The contact called nyc motorcars of the bronx (3748 boston rd, the bronx, NY 10469, (347) 966-4272) however, the vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 39,000.

- The Bronx, NY, USA

The navigation displays, radio and all equipment that uses it quits and shuts down and will go off and on 3-8 times and then it seems to be ok. I was driving the vehicle down the highway when it happens. This has happen many times.

- Norton, VT, USA

While driving on a local road I started to lose electrical power. At first I lost power steering and shortly after the heat stopped working and all the lights on the dashboard lit up. When I brought the car to be diagnosed the fuse box had been burned and wires melted and there was smoke indicating there had been a fire around the fuse/electrical area

- Lakewood, NJ, USA

I have had and continue to have battery trouble with my Toyota Rav4. I first bought a new 2014 and at my regular maintenance at the dealership, the battery was replaced several times. I was uncomfortable enough to trade it in and get a new 2016. I still have this one, but it continues to have battery trouble. I have been left stranded at work when my car would not start. That is when I found massive amounts of corrosion, and to this day, the terminals corrode over even with new battery. The passenger door does not always lock with the key button bc of this issue. I would estimate I've replaced the battery 3-5 times between the two cars, with no real solution. Batteries have always been replaced/installed by the local Toyota dealership. (I'm sure invoices could be pulled if necessary) my cars have not stalled while running, they won't start or just start to have electrical issues w lights, and it gets checked by the dealership. They usually recommend replacement while the battery is covered. A separate but equally unsettling issue is with the windshield. It recently cracked due to a passenger flicking a bug on it. You would think a rock landed on it.

- Jefferson, LA, USA

The contact owned a 2016 Toyota Rav4. While her husband was making a right turn at 30 mph, the vehicle abruptly shut off without warning; however, her husband was able to restart the vehicle upon depression of the accelerator pedal. As they continued to drive, the failure occurred two more times and after the third failure, a blackish smoke began to emit from underneath the front passenger side of the hood. The contact's husband was able to exit the vehicle and extinguish the fire with a water bottle. The authorities were called to the scene, and the fire department removed the battery from the vehicle. A fire and police report were filed; no injuries were reported. Due to the failure, the vehicle was towed to sheehy Toyota of stafford(95 garrisonville rd, stafford, va 22554) where they initially gave the contact an estimate to replace the vehicle parts in order to check if the vehicle was still operable. Due to the high cost of the repair, her insurance company deemed the vehicle total loss and was destroyed. The manufacturer had yet to be notified of the failure. The vehicle had been destroyed. The failure mileage was 44,156. The consumer provided the report from the fire department.

- Stafford, VA, USA

Rear hatch motor failed. Hatch will not open. Toyota admits fault/defect, but refuses to cover costs associated with fixing it.

- Gonzales, LA, USA

The wiring harness was chew completely up. This affected my power brakes, engine, steering system, etc. These lights came on while driving the car! rats chewed my wiring.

- Ville Platte, LA, USA

My car phone does not work with my iphone 11 pro max. I have a 2016 Toyota Rav4 hybrid. The bluetooth on my new phone well not pair with my etune software. Tbe phone can't even discover it. When it finally fails my screen on my cat phone says no microphone detected. Rotors says it's an apple software problem. Jus a safety issue. I drive and work out of my car six days a week.

- Perry, OH, USA

Started my 2016 Rav4 limited on 7/27/2019. After starting it none of the safety features are working. This appears to be a known issue among other Toyota owners. The vehicle was fine when I shut it off the night before. Now anti lock braking, lane departure alert, pre-collision system, and adaptive cruise control are all failing.

- Hutchinson, KS, USA

The contact owns a 2016 Toyota Rav4. While attempting to make a turn from a stop, the vehicle lost power. There was no warning indicator illuminated. The vehicle restarted within two seconds, but the failure recurred. The vehicle was taken to gettel Toyota of lakewood (941-567-1080, located at 5959 E. state rd 64, bradenton, fl 34208) where it was determined that the vehicle was performing as designed. The failure recurred. The manufacturer was made aware of the failures and did not assist. The failure was not remedied. The failure mileage was approximately 1,000.

- Bradenton, FL, USA

2016 Toyota Rav4 xle. Consumer states that after purchase vehicle would not start. The consumer was informed, by the dealer, the failure was due to the vehicle being struck by lightening. The insurance company did not agree.

- Dacula, GA, USA

It was a cold day in Massachusetts. I warmed up the car in the morning for 10 minutes before starting to drive to work. I got onto the Massachusetts pike and after a couple exits of cruising at 60 hit stop and go traffic. At one of the entrances and when I slowed down to a stop in the traffic my car flashed the battery critical charging error for a split second before saying everything needed to be restarted by putting the car into park. After that, the car completely shut down. I was not able to put on hazards until about 15 seconds later of trying to get the power back on did the car start up. Within that time a driver behind me decided to hit me in the rear. On restart the car didn't show the fault but upon looking up the battery critical charging failure it states to not drive the car and to immediately take it to a shop. The shop cannot find the code due to it being wiped making solving the issue even more difficult.

- Brookline, MA, USA