Vehicle had been in for routine maintenance 6 weeks prior. Around 46k miles, the check engine light came on requiring me to bring it back to the Toyota dealer. I wasn't able to bring it to the dealer for about 6 days after it came on due to appointment availabilitly. Once I brought it in, they told me the coolant bypass valve had a circuit short and needed to be replaced. This part was replaced and is unable to be inspected. This is a safety issue especially during the summer as this short could cause the engine to overheat.

- Upland, CA, USA

2019 Vehicle with less than 45K miles Got a message to take the car to the dealership. Dealership tells me that the coolant bypass valve needs to be replaced. Dealership representative tells me this is a common issue with cars like mine and the part is back ordered for an indeterminate amount of time. After doing some research, I see this is a major issue with quite a few Toyota models, not just Rav4.

- Ponder, TX, USA

Warning Engine Maintenance light popped up on 2019 RAV4 Adventure, with notification to see dealership. Took vehicle in and was informed that the coolant bypass valve has internal circuit failure. Vehicle has has 23,000 miles, this should not be happening to a relatively new car. Appears to be a widespread defect per the Internet: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Austin, TX, USA

The problem for Toyota is well known on the engine bypass valves. Several Toyotas owners are experiencing this issue on replacement, even service team members are suprised this part isn-??t recalled yet.

- Houston, TX, USA

Engine maintenance required visit your dealer alert on screen. Seems to happen when the A/C is in use. Took it to a Toyota dealership for a diagnostic test and they said it was the Engine coolant bypass valve. The diagnostic test was $180. They mentioned the part was on backorder and I have been waiting for the part for a month now. The alert will not go away at all if the A/C is in use. The dealership mentioned this has been happening frequently with RAV 4s. It will cost approximately $771 to repair and $189 for a coolant flush.

- Dallas , TX, USA

Getting the following issue: 2019 RAV4 : P268115 Engine Coolant Bypass valve circuit short to battery or open This is happening to a lot of other cars - it seems like Toyota has a faulty coolant valve

- Bristol, CT, USA

Engine maintenance required light came on. Vehicle was diagnosed with needing a new coolant bypass valve. Researching online and in Toyota groups, this is a widespread issue. Even the dealer said they have had many of these repairs yet Toyota has not issued a recall. This is a repair with a cost of $500-$1000 and a safety concern but Toyota has not addressed it.

- Aubrey, TX, USA

On May 13, 2023, -??Engine Maintenance Required-Visit Your Dealer-?? warning appeared on my console. I immediately brought the vehicle to the Toyota dealer. I was told the Coolant Bypass Valve went bad. This was at roughly 45,000 miles. I had previously purchased a -??No deductible extended warranty-?? from this same Toyota dealer. Now they tell me this -??Valve-?? is not covered under warranty. I was charged $887.99 for repair of this -??Valve-??. As this could cause the engine to overheat, causing additional damage, it most certainly is a safety issue.

- Sacramento , CA, USA

Engine repair light keeps coming on RAV4 HYBRID SMELL OF GASOLINE is present at times NOISES LIKE GRINDING OR SCRAPING from WHAT SOUNDS LIKE UNDER the CAR WHEN BRAKING AND akso WHEN accelerating

- Encinitas, CA, USA

Engine Bypass Coolant Valve. Issue could cause coolant leak and cause car to overheat. Issue confirmed by Toyota dealership. Also many individuals confirming the same issue. Component inspected by dealership. No issues until component failed and now a constant engine repair message.

- Athens, GA, USA

2019 Toyota Rav4 Premium Engine Maintenance light visit dealer popped up on the vehicle. Researching online apparently the coolant bypass valve malfunctioning is a recurring issue with the 2019 Toyota Rav4, not sure why a recall has not been done yet for this vehicle. Went to the dealer to have the vehicle looked at, before having it diagnosed the service person stated it is probably the coolant bypass valve and that the part is on back order, vehicle was put on the machine to have it diagnosed and confirmed that the Coolant Bypass Valve will need to be replaced. The only warning light that it gave me was Engine Maintenance light came on. The service advisor said the vehicle is perfectly fine to drive till they get the part in, which still concerns me because of the engine. I am having to pay out of pocket to get it repaired but after talking to the service people and researching online from other people, there really should be a recall for the Coolant Bypass Valve.

- Charlotte, NC, USA

We have a 2019 Toyota Rav4, win VIN JTMK1RFV8KD******, about a week ago this message appeared: "ENGINE MAINTENANCE REQUIRED. VISIT YOUR DEALER." The Mileage was still 74,104. After a week, I took it to a mechanic shop; I had the oil changed and discovered that the message cannot be removed. I had the vehicle system scanned and one of the items that came up is "Engine and engine cooling". My mechanic went on line to find out if there's a RECALL issue on my vehicle with its VIN. There are 8 Recall issues on the KELLY BLUE BOOK website but not on the Toyota website. We called the dealership and they confirmed that my VIN is not included in the list. Toyota is charging $180 or more just to Diagnose. WHY do we have to pay for the Manufacturer's defects?

- Los Angeles, CA, USA

The Coolant Bypass Valve went bad, and apparently it-??s been happening frequently to a lot of peoples Toyotas. Also unsafe because I have to wait for the part, which is on back order, because so many of them are faulty. This need to me recalled!

- Davenport, FL, USA

Vehicle stalled while driving 60mph, vehicle overheated upon restarting

- Rio Grande City , TX, USA

Driving home from work on 3/25/23 at 9:15 pm my dash lights starting going on and off flicking. -??Power steering malfunction. Steering power low visit your dealer-?? -??abs-?? also multiple dash lights came on at the same time. Brake light steering light. Got home and took video while parked to safely show the issue

- Menifee, CA, USA

The engine on my Rav4 suddenly stopped without any notification while I was driving it on the freeway. I could have been severely injured from the risk of being rear ended by vehicles behind me. I have experienced this twice now, and both times, I have been on a busy highway in the middle of rush hour traffic. While driving, the engine would start sputtering and the vehicle will jolt and shake, eventually causing a warning message to appear that says power steering low, engine shutting off, place vehicle in Park. Then, when I turn the engine off, and try to restart it, it would flash a message that read Not ready to drive. After towing the vehicle to a service department, the vehicle would start up like normal, and the techs could not get vehicle to duplicate the issue. No codes would come up when they place it on a scanner, either. I researched the issue online, and it appears I am not the only one who has experienced this issue with the Rav4. Please reference https://www.rav4world.com/threads/engine-stopped-steering-power-low.323916/ This incident happened twice, once on 3/6 and again on 3/8. I thought the issue was fixed after having my vehicle towed on 3/6 to Freeman Toyota Service where they determined the issue was due to a recall on the fuel pump. However, the incident occurred again on 3/8, and I had to have the vehicle towed as the engine shut off while I was driving on the freeway blocking one lane of traffic on the interchange that connects one freeway to another. I was very fearful of other vehicles crashing into me as some of them were squeezing by between my vehicle and the retaining wall to get around me. It took the wrecker over an hour to get to me due to high traffic time. I have uploaded 2 tow bills I had to pay, and the service invoice for the recall work done. My vehicle is currently at another Toyota Service department where they are telling me they are unable to duplicate the issue.

- Houston, TX, USA

I received an alert on my vehicle that engine maintenance was required. I conducted a code reader scan of the vehicle. There was no codes that were activated or shown. I took my vehicle to a Toyota dealership. I was advise that my vehicle which only has 42k miles had a bybass coolant value issue. I further saw YouTube videos and read forums on my vehicle and the issue. A lot of individuals are reporting similar issues with their vehicle. An interesting remark, which I noticed was that a lot of the Rav4s from 2019 and newer had the same issue. These cars are not even above the 100k miles, which makes me wonder and worry how safe will my vehicle be. The part is on backorder around 1 month to 3 months. My vehicle begin to display the message around 40k miles. I believe a recall should occur.

- Hillsboro, OR, USA

The contact owns a 2019 Toyota Rav4. The contact stated that the roof rack clips were fractured and water was leaking into the vehicle, causing the vehicle to shut off intermittently, electrical failures, and air bags malfunction. The vehicle was taken to the local dealer where it was diagnosed that the headliners were leaking. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The approximate failure mileage was 66,000.

- Pembroke Pines, FL, USA

I have a 2019 all-wheel-drive limited and for the last two months it has been slipping into mud and sand mode. It happens when I shift from driving to park or drive to park, and if I-??m standing idle it will slip into mud and sand mode and switch off a few minutes later. Dealership says it-??s the sensors but I had my sensors checked and there is no issue there.

- Johns Island , SC, USA

My vehicle 2019 Toyota Rav 4 Limited has transmission and engine issues as well as a roof rack leak. I have reported this to Toyota via 1-800-331-4331, which was not helpful. Israel stated that there is nothing that Toyota Cooperate can do about this issue. Both the transmission and engine had been previously repaired at Toyota of Laredo to no avail. Currently my vehicle is awaiting repair at Cavander Toyota in San Antonio. No loaner was provided despite me being a home health therapist who needs her vehicle to work.

- Laredo, TX, USA