10.0
really awful- Crashes / Fires:
- 1 / 1
- Injuries / Deaths:
- 4 / 0
- Average Mileage:
- 1,824 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
« Read the previous 20 complaints
A week prior to this incident, the 2020 RAV4 was taken to Toyota for its maintenance check where everything was checked, replaced and changed. However, the last two days an incessant message keeps popping up on the dash stating -??engine maintenance required-?? Visit your dealer-?? taking up the entirety of the middle screen inhibiting my ability from seeing my speed, mileage, distance to empty, time, lane assist and other car information that I normally rely on. I have pressed the -??arrow back-?? or -??back-?? button numerous times but three seconds later the message pops again inhibiting me from being able to use necessary car controls to stay safe. The engine on the 2020 RAV4 needs to be recalled as my car only has 55,000 miles on it. I have talked to numerous professionals within the motor industry in which they state these engines have lower stability and life expectancy than PREVIOUS engines used in older RAV4 models. Not only the engine, but the messaging system within the RAV4 needs to be fixed immediately as the communication of maintenance WHILE driving is a hazard. If I cannot look at texts to even just simply read it, why is there is message bright and in the middle of my dashboard popping every 3 seconds with a bright red triangle stating that I need -??engine maintenance required, visit a dealer-??. This is a safety issue and one in which almost nearly cost me my life.
- Alpharetta, GA, USA
This is a known issue. Coolant Bypass Valve Issue Error on value says "Engine Maintenance Required, Visit Your Dealer." We have been waiting on the recall at 27,000 miles (brand new purchased). We are at 50,000 miles now and still no resolution and the error stays.
- Greenville, SC, USA
* Coolant Bypass Valve * This problem costs $800 to fix at the Toyota Dealership. car is a 2020 Rav4 with only 32k miles on it. * After reading thousands of complaints on websites from other 2020 Rav4 owners with the exact same problem, I think there should be a recall as this can be a dangerous issue if the engine overheats. I am shocked that nothing has been done about this yet. only warning was a routine maintence light that comes on every 5,000 miles.
- Fairhope, AL, USA
The following is an issue involving my 2020 RAV4 Toyota battery manufacturing defects that ended the life of my RAV4 battery. The mentioned event occurred on [XXX], and a report was created and recorded by a Toyota representative on [XXX], via (800) 331-4331 phone call, with the reference report number [XXX]. The nature of the issue was that my 2020 RAV4 battery parts came loose from the inside, and the metals were rubbing with each other, causing the smoke and the battery to overheat, ending its life due to the mentioned manufacturing defects. Based on the dangerous, alarming issue of overheating and dense heavy smoke from the battery, I left it at the dealer for service to prevent any toxic fumes, fire, or explosion. I told the dealer adviser that those manufacturing defects are a serious safety concern that should be reported in the public-??s best interest to avoid any possible tragedies. I noticed when I picked up my car from the dealer that the battery manufacture defect was not recorded in the paperwork I had received; the manager and the advisor didn-??t show any sense of urgency to the matter, so I filed a report to Toyota Motor North America Headquarters, Plano Texas. Report number: [XXX] The dashboard panel never displayed any safety hazard warnings or any symbols indicating the conditions of the smoke and battery overheating were jeopardizing my life and my family aboard while I drove with them. I paid $ $552.55 for the battery and a diagnostic service; management did not want to acknowledge that a manufacturing defect ended the battery life. Customers should not be responsible for replacement costs when the event is caused by manufacturing imperfection -??even though the warranty is over.-?? The dealer advisor and management know that these manufacturing battery defects happen. Still, nobody ever informed me to be mindful of the dangerous state of faulty battery defects when I purchased my 2020 RAV4. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Moreno Valley, CA, USA
Car operating as normal in the morning, few hours later went to start up car again and had message saying -??hybrid system malfunction-??. Drove it around for a few minutes then other lights started flashing, lane departure, traction control, crash detection. They all went away and except the hybrid malfunction warning.
- Sterling, IL, USA
Engine bypass valve sensor is faulty. Many users have reported this past 40k miles on RAV4 2019-2021
- Debary, FL, USA
2020 RAV4 hybrid. Vehicle doesn't start; requires a jump, which is inconvenient or unsafe, depending on where it happens. Intermittent occurrence, ~ 3 times/year. Toyota checked 12V battery, pronounced OK, of course the car was driven to the shop for the check, so was operating at the time. I've checked the battery when the car wouldn't start and found it to be a little low (11.5V) but by no means fully discharged. Not associated with leaving components on (we are careful to turn everything off) or weather; the vehicle is garaged in the winter. I turned off the "Bluetooth" system which we never used and haven't had this issue over the past year. Suspect that the "Bluetooth" system was operating even when the vehicle was off?
- Madison, WI, USA
Got an engine maintenance required alert, took to Toyota and they advised the coolant bypass valve needs to be replaced at just 38,000 miles. Googled this and found out many 2020 RAV4 with the same issue at just under 40,000 miles. Also a common issue is the voltage being low and we already had to get the battery replaced once and still get alerts of it being low after replacement. Have to pay today $765 for the coolant bypass to be replaced, will have the receipt later in the day.
- Hollywood, FL, USA
2020 Toyota RAV4 XLE purchased July of 2020. Just hit 35K miles and an "engine maintenance required" message appeared. The error message would not go away while driving and blocked the entire display screen. There is an issue with the Engine Coolant Bypass Valve that costs $700-$1000 to repair. The part and repairs are not covered by the 60,000 power terrain warranty.
- Redding , CA, USA
I have a 2020 RAV4 Toyota with 60,000 miles.. I have replaced the car battery 3 times now Toyota has no clue why. The 2nd battery only lasted 8 months and it was a name brand battery (Die Hard).. The engine problem started with a warning light that i could not turn off.. I took my car to Toyota and they told me right off (without checking) it was because of a Coolant Bypass Value, the Toyota service lady said it was her 5th Rav4 this week with the same problem. I checked on line and was surprised how many Rav4 customers were complaining about the same issue so i reported it to you.. Toyota is charging me $900 to replace.
- Wesley Chapel, FL, USA
Coolant bypass valve failure my car has less than 50k Dealerships informed me that they fix around 10 a month for that part there is a defect regarding this pump
- Charlotte, NC, USA
Despite the upkeep of maintenance the light warning light won-??t go off. I follow rav4 groups this is a common problem.
- Charlotte, NC, USA
On or about 8/21/23, we were driving from Vermont back to our home in New Jersey when the sound system started malfunctioning. First, we lost all sound (safety warnings, as well as radio). The sound returned and then cut out again repeatedly. Then, the speakers emitted loud (full volume) static and popping sounds despite the audio system being "off." At the time, we were driving at approximately 65 mph on a highway with our two young children. The noise was so loud that it was difficult to focus on driving. The static and popping sounds continued until we pulled over and shut the car off. These failures have continued and increased in frequency since that time. Our safety was put at risk in two ways: 1) all of the safety warnings were and are muted and ineffective and 2) a full-volume static/popping sound while driving at highway speeds could have caused an accident. Subsequently, we did the following: -Googled the issue and found a relevant Technical Service Bulletin published by Toyota in September 2020 that applies to our make/model and VIN. It is labeled T-SB-0086-20 and can be found here: [XXX]. This suggests the issue applies to multiple Toyotas. The Bulletin indicates the VIN number where the issued stopped -- suggesting Toyota took steps to fix it. There has been no recall related to this issue and we were never notified of this issue. The issue is apparently related to a defective amplifier. -Brought our vehicle to our local Toyota service center (Paul Miller Toyota of West Caldwell NJ). An employee there was able to reproduce and confirm the issue and recommended replacing the amplifier. -Called Toyota to report the problem and register a complaint given the safety issues, failure to notify us of the problem even though it was known to Toyota, and the cost of repair ($2640). There were no warnings, messages, or other symptoms of the problem prior to the failure on or about 8/21/23. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Glen Ridge, NJ, USA
Power steering light is on and possibly due to water penetration from recent heavy rainfall.
- Las Vegas , NV, USA
High Voltage Warning and Low Power to Steering reading on the dashboard. Service engine warning!
- Fishers, IN, USA
There is a recall for the roof rails leaking water which can damage the air bags and electrical components. They will not fix the roof with new gaskets unless you actually see the water coming in. My concern is that it is leaking and I'm just not seeing it because the 110 degree weather. I do not want to be in an accident with my wife and kids in the car and have the air bags not work. They should fix the gaskets before it leaks and leads to further potential damage or even life threatening results(air bags being wet and not deploying). They will not fix my roof until it actually starts leaking even tho there is a recall in place. This is ridiculous.
- Phoenix, AZ, USA
I was driving and out of nowhere this warning came on engine maintenance required, and this now a normal maintenance required that means an oil change. The problem with this warning is the coolant bypass valve, and I-??m not the only one with this issue, my car has only 32100 miles only, this a ridiculous for a new car. Plus it seem that this issue only comes on with tha A/C
- Atlanta, GA, USA
2020 Toyota Rav4, just around 25K miles, took to dealership to get regular maintenance service, (oil change, tire rotation). After a couple days, "engine maintenance required" message pops up. Plugged in code reader and brings up code "P268115" for "Engine Coolant Bypass Valve Circuit Short to Battery or Open". This issue is popping up for many recent year Toyota models (Rav4, Camry, Corolla) and is not being repaired by Toyota for free. They are charging $600 - $1000 to repair faulty part that is not the owner's fault and issue needs to be recalled.
- Lemon Grove, CA, USA
Car has 26K miles on it (3 year 2 months old). A light appears saying Emergency Engine Maintenance is required. After research as this error is not in manual, found out it was a failed coolant bypass valve and this was a common failure/faulty equipment but we are being asked to pay full price to repair. A simple internet search shows 100's of consumers with same issue in same model and low miles.
- Westford, MA, USA
- Farmington , UT, USA