Frame cracked at right rear box rail...

- Watervliet, NY, USA

Frame rust when purchased out of state (Minnesota) from dealer and inspected on 10/2/2012 (in Virginia, upon Transport arrival). They said they believed it was mostly surface rust. Inspected again in may of 2014 and found within 20 months and 24000 miles later, the frame had perforated, and deemed unsafe to drive. It was marketed as a vehicle in great shape, and wasn't cheap. Much money is still owed on this condemned vehicle. These vehicles have a history of this, yet there is nothing being done concerning these unsafe vehicles.

- Richmond, VA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the frame and chassis were corroded. The contact was also concerned that the spare tire would become detached from the vehicle. The vehicle was not repaired. The dealer advised the contact that there were no open recalls on the vehicle. The manufacturer was notified of the failure. The approximate failure mileage was 212,000.

- Matawan, NJ, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that while driving at various speeds, the vehicle would sway from side to side. The contact discovered that the entire sub frame of was rusted and corroded. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 147,000.

- Peru, NY, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the vehicle was severely rusted and the frame area near the tires exhibited corrosion. The vehicle was taken to an authorized dealer who stated that the frame needed to be replaced. The contact referenced NHTSA campaign number: 12V542000 (tires) and stated that the local dealer and the manufacturer indicated that the recall was no longer active. The vehicle was to be inspected and repaired. The manufacturer was notified of the failure. The approximate failure mileage was 85,000. Updated 01/12/16, updated 02/23/16 updated 8/22/2017

- Stanchfield, MN, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the entire frame was completely rusted and as a result, the rear axle and spring hanger became detached from the vehicle. The vehicle was not being driven due to a potential safety hazard. The manufacturer was notified of the problem. The approximate failure mileage was 162,000.

- Rison, AR, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that rusting and corrosion was discovered on the frame. The contact indicated that the rear driver's side leaf spring shackle had sunk into the under frame due to the rust and corrosion. The vehicle was not diagnosed or repaired. The manufacturer was notified of the defect but no solution was offered. The failure mileage was 150,000.

- Washintonville, NY, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the frame had started to deteriorate. The vehicle was taken to a dealer where the technician applied an undercoating to the frame. The contact stated that the coating eventually wore off. The vehicle was not repaired. The manufacturer was not made aware of the problem. The VIN was not available. The approximate failure mileage was 130,000.

- Charleston, WV, USA

Informed by dealer that frame is rusted through and truck is unsafe to drive. Also informed that there had been a service bulletin for this problem. But my truck is no longer eligible for repair under the voluntary service recall (of which I was never notified), as it had expired. I think Toyota should be responsible. They recognized their defective product; however my truck is ineligible for repair because they get to limit their responsibility because their remedy is not technically a "recall". I, and I'm sure many others, are by necessity, driving unsafe vehicles.

- Philadelphia, PA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the vehicle was taken to the dealer for unrelated repairs when he was advised that the sub-frame was severely corroded. As a result, the technician advised the contact that the vehicle was unsafe to drive. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure and current mileage was 110,000.

- Valencia , PA, USA

The contact owns a 2002 Toyota Tacoma. The contact took the vehicle to the dealer for service under NHTSA campaign number: 12V542000 (tires). The contact was advised that the vehicle could not be service under the recall because of excessive corrosion. The contact stated that he was never advised of corrosion when the vehicle was inspected in 2010 for a manufacturer's warranty. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 95,000.

- Bridgewater, NJ, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the rear frame was deteriorated. The vehicle was taken to the dealer, who stated that they would not repair the problem. The contact stated that the dealer informed him that the vehicle was included in a manufacturer's recall and several notices had been sent however, the contact failed to have the vehicle serviced per the recall. The vehicle was not repaired. The manufacturer was made aware of the problem. The approximate failure mileage was 220,000.

- North Dighton, MA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the vehicle was taken for state inspection when he was advised that the front area of the frame was severely corroded. The manufacturer was contacted and advised that the frame was not safely coated therefore, they denied assistance with any repairs. The vehicle was not repaired. The failure and current mileage was 161,250.

- Allison Park , PA, USA

After having my 2002 Toyota Tacoma off the road and garaged for the past 3 years, I was getting the truck ready to be driven on the road again. I am the original owner. I took the truck off the road because my job was eliminated in October 2010. After changing the oil last weekend in my garage I noticed an abnormal amount of rust on the frame. In fact, so much rust that the rubber body mount block on top of the rear leaf spring snapped off in my hand. The leaf springs, brake lines, and front suspension and frame are all in question regarding vehicle safety. I immediately did research online to check out what I thought was abnormal amounts of rust on the frame and to see if anyone else had experienced this too. I was shocked at what I found. A huge safety issue with Toyota Tacoma rusted frames. I come to find out online that Toyota has a history of rusted frames, breaking frames, unsafe frames, and a recall currently for a rear spare tire mount issue due to rust. I also found out Toyota was replacing frames on my model. I called my dealership to set up an appointment to have this truck inspected for Pennsylvania state requirements and to have the rust checked. They told me my vehicle was not valid for the rust inspection and the frame replacement because the program expired, I was told to call Toyota. I was never notified by Toyota or my dealer there was an issue, not by mail, phone calls or certified mail. I had the truck parked in my garage for three years so it wasn't even on the road during this time. Several phone calls later to Toyota and they refuse to replace my frame under the customer care program citing I did not have the undercoating applied by December of 2012. Toyota customer service said I could weld reinforcement plates to my frame myself or find a junkyard frame. Really Toyota?

- Quakertown, PA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the frame of the vehicle exhibited severe rust. The vehicle was taken to a dealer for diagnosis and the contact was referred to the manufacturer. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage was 140,000.

- Honaker, VA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the rear bumper had rusted and the contact was unable to tow anything with the vehicle. The contact spoke with the manufacturer about the failure. The vehicle had not been repaired. The failure mileage was 65,000 and the current mileage was 110,000.

- Trooper , PA, USA

The contact owns a 2002 Toyota Tacoma. The contact stated that the frame and the rear leaf springs contained massive amounts of rust and was unsafe to drive due to the failure. The vehicle had not been repaired. The failure and current mileage was 151,000.

- New Vineyard Rd, ME, USA

This vehicle was already involved in a "campaign" by Toyota to replace severely rusted frames. Now the spare tire lift plate is also rusted through on many of them which Toyota is "implementing a remedy for". my complaint is that I have a severely rusted housing of the rear differential, next to and just below the rusted spare tire carrier lift plate, Toyota refuses to pay for the rusted through housing of the rear differential. This is a negligent safety issue on their part, because those owners who are not aware of the leakage of this part may find themselves without power, or worse perhaps, a lockup of that part when they are going 65 mph on highway possibly with children in their vehicle. The rust on these vehicles is legendary among Toyota owners as evidenced by their complaints on the internet. Toyota did replace the frame on my 2002 Tacoma, but in my opinion, it is their responsibility to replace the rusted out housing. It is not as if that is the only rust on this vehicle, and no other vehicles that I am aware of have this problem.

- Chestnut Ridge, NY, USA

My Tacoma was recalled 2 years ago for frame rust. They told me it was ok + undercoated it to prevent future rusting. All that undercoating is falling off. That can only be due to improper application or faulty product. The dealer that applied the product (ferris Toyota) says the product is faulty + they've seen it many times. They've also confirmed the same with other dealerships. Toyota, otoh, says there's nothing wrong. If the frame doesn't need undercoating, then why'd they do it" are they suggesting it works when 50% has fallen off? this is the same vehicle which is now being recalled for spare tires falling off on the highway + my emergency brakes have been seized with corrosion since I've owned the truck. I've contacted Toyota many times + they refuse to put their correspondence in writing, but the representative, tiffany bishop, says she types a transcript of our conversations, just won't give me copies. She also calls from a phone with a blocked number. What kind of bull is this" these vehicles are obvious hazards on the road + Toyota is playing games instead of making serious efforts to make the vehicles safe. Please bring this to the attention of someone at Toyota other than [xxx], I am finished corresponding with her! information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Dover, OH, USA

The contact owns a 2002 Toyota Tacoma. The contact stated the entire frame was covered with rust. The vehicle was taken to an authorized dealer where a rust under coating was applied to the frame. Two years later, the frame exhibited severe rust and corrosion. The vehicle was not repaired. The manufacturer was notified of the problem. The approximate failure mileage was 53,871. Updated 01/18/13 updated 01/24/13

- Allison Park, PA, USA