The contact owns a 2000 Toyota Tundra. The contact stated that the vehicle was previously repaired under NHTSA campaign id number 09V444000 (structure) a few years ago and while entering a service station at 2 mph, a loud noise was heard. Upon inspection, it was found that the spare tire had separated from the vehicle. The vehicle was not taken to a mechanic. The manufacturer was not contacted. The failure and current mileages were approximately 157,000.

- Hazel, MA, USA

Previous complaint not correct. Took vehicle to Toyota newburgh NY for safety recall replace frame was told at time had to do power steering as leaking and rust and entire cost I had to pay though compain states they are responsible or they wouldn't pass inspection, I showed them. No other choice but to do & hope to recoupe later, yeah right. Truck went in complete frame was done remarkable fast, obvious why, as I drove home the truck had not been put back on frame correct that was clear to the eye but driving it the challenge to remain on road safe.the dealer nys certified insp. Site also passed this vehicle. The truck has so many more safety issues after completion its a joke thanks NHTSA. Not to mention the malfunction of many components that worked prior, called dealer and complained, they also informed me as replace being done that the exhaust hanging by thread due to rust brackets etc the cost to repair $6000 if I bring it back they will surely violate me again, I cant afford $/aggrav. NHTSA has done nothing for me but they continue to compain on the utmost importance we as consumers are these trucks need be taken off the road. Toyota Corp. N dealer laughed when I stated calling NHTSA go ahead they wont do anything, filled w Toyota customer hotline anyway knowing they are in bed with NHTSA. My ? who & where are these fines billlions of $ going, surely not to the owners of vehicles. Mr. Strickland I dare U to do your taxpaying job & get me N others results take these and any other vehicles off the road before my or hey maybe your family is involved in fatality. Are roads are not safe, this Agency is failing everyone that travels over the road. Any attorney willing take private case I got documents N some [xxx] NHTSA stinks big in this who do U represent who ru accountable to I want answers Mr. Strickland contact info nowhere why. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Cold Spring, NY, USA

The contact owns a 2000 Toyota Tundra. The contact stated that the vehicle was included and repaired under NHTSA campaign id number: 09V444000 (structure: Frame and members:underbody shields). The contact stated that after the vehicle was repaired, the frame and tires felt at if they were not aligned properly. Additionally, the vehicle was taken back to the dealer. The technician advised that the power steering rack and pinion was corroded and would need to be replaced. The vehicle was not repaired. The approximate failure mileage was 146,000.

- Cold Spring, NY, USA

The contact owns a 2000 Toyota Tundra. The contact stated that the manufacturer replaced the frame under the recall associated with NHTSA campaign id number: 09V444000 (structure: Frame and memebers: Underbody shields), but did not replace the lines for the power steering that direct into the front axle. The contact stated that the couplings that pass fluid into the axle were rusted. The contact also stated that the manufacturer did not replace the rusted fuel lines either. The contact stated that the power steering had failed and the fuel lines that went from the fuel pump to the motor were about to fail. The manufacturer did replace the brake lines. The vehicle was in the possession of the manufacturer for five months during the repair process. The failure mileage was 152,000 and the current mileage was 155,000.

- Racine, OH, USA

Took truck to Toyota dealer and was told unsafe to drive due to rust. Was told they would replace the frame but it would cost me $8000 to replace all broken parts and labor. Called Toyota and they said there was nothing they could do.

- Prince Frederick, MD, USA

The contact owns a 2000 Toyota Tundra. The contact stated that after receiving notification of NHTSA campaign I.D. number 09V444000 (structure: Frame and members:underbody shields), the vehicle was taken to the dealer. The dealer inspected the vehicle and advised the contact that the frame did not need the corrosion protection compound as stated in the recall. The contact stated that the frame had excessive corrosion and was not safe to drive. The contact called the manufacturer but did not receive any assistance. The failure mileage was 43,000.

- Marietta , GA, USA

TL- the contact submitted an email and requested that the official IVOQ be written verbatim to the email: I am the owner of a 2000 Toyota Tundra with severe frame rot. I can not get Toyota to replace my frame because the vehicle was a rebuilt vehicle. The only thing they could do was replace the rear cross member. The problem I have with this is that my truck is excellent condition with the exception of the frame. I bought it with 50,000 miles on it and it now has 189,000 miles on it. A local man had his replaced and the truck will pass an inspection. It is frustrating I sent a letter to Toyota a year ago and to no response. So I guess my question is are they pulling the wool over my eyes and to doing the replacement or am I just screwed. Assignees and notifications* updated 05/02/12 updated 05/04/12

- Troy , ME, USA

The contact owns a 2000 Toyota Tundra. The contact stated that the vehicle was included in the recall associated with NHTSA campaign id number: 09V444000 (structure: Frame and members:underbody shields). The vehicle was taken to an authorized dealer for repair. The contact expressed concern with having a rusted frame repaired with replacement parts and felt that the manufacturer should purchase the vehicle back from him. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 66,000.

- Hampden, MA, USA

The contact owns a 2000 Toyota Tundra. The contact stated that the frame was rusted. The dealer diagnosed the vehicle and found no failures. The manufacturer was contacted, but denied any assistance with repairs to the vehicle. The vehicle was not repaired. The failure mileage was 65,000 and the current mileage was 84,000.

- Ft. Blackmore, VA, USA

Toyota Tundra 2000 frame severely rusted. According to mechanic, maybe a risk to me and others. I have owned Toyota since 1984, and have never been so disappointed and appalled. Is NHTSA doing anything or is this a waste of my time" what do I do"

- Orange, CT, USA

This vehicle was purchased at greensburg Toyota, greensburg, pa. This vehicle has had brake lines replaced, fuel lines replaced, the frame corroded and rusted out, fuel lines rusted out, the tie rods rusted out, the tailgate rusted out, the electrical outlets for the backup and tail lights were shorting out, the entire body on this vehicle is rusting. This vehicle is a complete menace to the Toyota company. This vehicle had the front axles rusted out and the wheel fell off while driving it.

- Perryopolis, PA, USA

1. noticed severe under body rust and frame rust on 2000 Toyota Tundra when washing truck. 2. rust getting worse, making the vehicle less safe to drive and use as intended. 3. nothing has been done to correct this issue yet, but did receive a letter from Toyota stating the issue with under body rust and took it to the dealership, but they didn't do anything about it.

- Bloomington, IN, USA

(1). I purchased a new 2000 Toyota Tundra extended cab limited at price Toyota in Delaware. In February 2009 I observed rust through of bracket from bed to frame visible through rear wheel well. Requested that my wife report this to Liberty Toyota in NJ during routine 5000 mile oil change. She was told that this was "not a problem". (2). In September 2009 truck was again taken to Liberty Toyota for 5000 mile oil change, purchase of 5 new tires and alignment. Liberty Toyota service told my wife that the truck was rusted to the point where they could no longer align the vehicle and no service was performed. Liberty took photos of the underside of the truck and transmitted them to Toyota. Approximately two weeks later Liberty told my wife that Toyota's position was that because of the age and mileage (9 years and 110,000 miles ) that they would do nothing to resolve this issue. (3). In late September 2009 I purchased a 2006 Toyota Tundra crew cab 4 door Tundra limited as a replacement vehicle for my wife a Toyota runnemead, NJ. On that same occasion the 2000 Tundra was put on lift and inspected with a powerful light. Observed various rust through of brackets and at least one fist sized hole through the frame. This was witnessed by the Toyota runnemeade sales person, general manager, sales manager, and service manager. All agreed that this was worst case of rust they had seen, and were of the opinion that the truck was not safe to operate. (4). In October 2009 I contacted Toyota customer service and received a case number. A few days later I again contacted Toyota customer service and was told that "Toyota is studying the problem". this sounded like a stall tactic and gave me little hope for any voluntary positive action from Toyota. As of today 11 November 2009 I have had no further contact from Toyota. (5). I have purchased or helped purchase 5 Toyota trucks for my family. Total expenditure approximately $150,000.

- Tabernacle, NJ, USA

Toyota Tundra year 2000, 4WD,6cyl. Frame total rust, holes in frame, spare tire bracket rusted, tire hanging down few inches from ground, almost caused accident on road. Had to remove tire. Warned by driver in rear of my vehicle, by flashing lights and blowing horn. Time day 11am.

- Pleasant Valley, NY, USA

1. my 2000 Toyota Tundra srt has serious undercarriage rust, and large pieces of metal are beginning to fall from the frame. The main beams of the frame are beginning too deteriorate, also the brake lines are corroded and brake fluid is beginning to seep through the lines. 2. rusted pieces of metal randomly fall from vehicle, and could cause damage or seriously injure other drivers on the road. The brake lines could rupture from the severe deterioration and lead to an accident. 3. currently I am not driving the vehicle until I get new brake lines, but there is nothing that can be done to the frame of the vehicle except recalling the truck. Toyota needs to recall the Toyota Tundra before any major accidents occur and some one is fatally injured.

- Abingdon, MD, USA

Heavy rust and deterioration of the under carriage frame of Tundra truck 2000.

- Somerville, MA, USA

Driving down road and spare tire fell off underneath the truck and rolled down the middle of the road. Took truck to Toyota dealership because a neighbor (who is a service manager) looked at it and said it was unsafe and the whole bottom was rusted out.. Toyota claimed the vehicle was safe that it was just a rusted bolt. Two weeks later the muffler was loud so we took it to a midas dealership. The mechanic called me in and stated that the issue was not the muffler the bolts and clamps had rotted out and he needed to drill holes to attach new bolts. He told me that the bolts holding the joints on the bed of the truck was unsafe and he felt that I should not drive the vehicle and definitely not on the highway. So now I have had 2 people claim the vehicle is unsafe and the Toyota dealers claims it is safe. The whole underneath is a big pile of rust. Luckily no one was injured when the tire fell of while I was doing 50 miles an hour. I was allowing my teenage son to drive this vehicle, but now it spends most of its time sitting in the driveway because we are afraid of a safety concern.

- Dudley, MA, USA

I own a 2000 Toyota Tundra and a few years ago it began to shed its paint. It spots up like it is corroded with a chemical then begins to peel off. By this point the whole truck has either peeled off or is spotted. The running boards are also corroded and rusting with holes all over them. I contacted Toyota and a rep looked at the truck and preceded to accuse me of exposing my truck to a chemical and saying he had never seen this happen before. They refused to make it right. I know of another lady with the same year truck and color of mine who has experienced the same problem. I did not buy my truck new, but it was only 5 or 6 yrs. Old when this problem began to occur. I am thinking that I cannot be the only one out here who is experiencing this. Thank you for all the help you can offer.

- Harrison, AR, USA

2000 Toyota Tundra pickup truck. Had the truck inspected in April of 2009 and found that the steel frame underneath the truck is rotting out the mechanic that we use said the frame may last another year.

- Brookline, NH, USA

I have a 2000 Toyota Tundra SR5 and the metal used is not of good quality. I have repaired the leaf springs on both sides three times due to the leafs breaking and I have never loaded the bed. Also, the frame is extremely rotted with large chunks falling off. Additionally the windshield leaks due to the metal rusting around the frame. I am very disappointed with this and have now heard several complaints from others about similar problems. I am the original owner of this truck and have always had it serviced by a certified Toyota mechanic and fully expected it to last much longer as my previous Toyota product had.

- Sutton, MA, USA