10.0

really awful
Crashes / Fires:
9 / 0
Injuries / Deaths:
3 / 0
Average Mileage:
48,473 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2016 Chevrolet Malibu:

Unsubscribe any time. We don't sell/share your email.

problem #89

Oct 102025

Malibu

  • miles
Car suddenly stopped dead cold while driving on a highly driven road. No power. Several attempts were made to get off the main road and drive to a close neighborhood. Finally started and at every stop sign the car grinded during stopping and threw me backwards in driver's seat. Needed a tow..

- Kenosha, WI, USA

problem #88

Oct 032025

Malibu

  • miles
My 2016 Chevy Malibu Limited is experiencing Electronic Brake Control Module (EBCM) failure symptoms that match Recall 39440, even though my VIN is not listed in the recall. Details of the problem: -The brakes would randomly feel like they were sticking and the car being held back -Brake lights would remain on -Car would float all over the road -ABS and StabiliTrak warning lights illuminated in the dash once. -ABS and ESC functions stop working, leaving only based braking available. -These failures occur intermittently but increased to everytime. -All 4 brakes are dragging, pulsing (no lights illuminated), reaching 240 degrees -Confirmed by mechanic EBCM This is a safety hazard. The vehicle becomes more difficult to control in adverse conditions without ABS/ESC. I transport my special-needs child in this vehicle, and I am deeply concerned for our safety. Why I believe recall expansion is needed: GM has acknowledged this exact defect in Recall 39440 (affecting other 2016 Malibus built during specific production dates). My vehicle is showing the same failure, and I request NHTSA investigate whether the recall population should be expanded to include additional VINs.

- Dubois, IL, USA

problem #87

Jul 232025

Malibu

  • miles
When I was driving my car with my child in it my break tightened up and I couldn-??t apply them to stop I had to let my foot off the gas and let my car slow its self down safely. When I got my car home my husband looked at it and found out that my vaccum pump had went out and part of it broke off in the engine. This is very unsafe and this needs to be investigated because people can-??t know when the vacuum pump is going to go bad this issue lays on gm and Chevy to make sure the parts they are using will hold up and be safe

- Grove City, OH, USA

problem #86

Jun 032022

Malibu

  • miles
Brake booster pump failed ( gm part # 12704586 ) Causing limited braking and severe damage to internal engine components, camshafts, timing chain have been damaged This is a ongoing problem in which i have had this pump replaced at my expense several times. The problem stems brake booster pump is lubricated using the engine's oil. Booster pump has a small screen to filter oil, this filter can easily become clogged resulting in booster to run dry and grenade into top of engine. These pieces then interfer with camshafts and timing gears other components

- Waterford, MI, USA

problem #85

May 222024

Malibu

  • miles
The car has a seat belt electrical problem it makes sound once in a while indicating for the driver to put their seat belt on. Also there is issues with the brake sensor. The #1 issue is the Transmission Accumulator Pressure Pipe, when it breaks all your transmission oil pours out from the bottom of the vehicle. The part is about $20 but if not installed right you will think that your transmission is dead but it's not.

- Fresno , CA, USA

problem #84

Sep 142024

Malibu

  • miles
Update to claim #11614644. Car was inspected by Auto Lenders in Lakewood, NJ. Vacuum pump failed and cam shaft has to be replaced, was told the engine **SHOULD* be salvageable. They won't know until they start taking it apart. Was told it will take 12 hrs for each part at $180 an hr. Damage is estimated at $4500. Car is currently under an extended warranty, we are waiting to hear if the warranty will cover the damage. My son still owes $9000 on the car, we bought it 2 yrs ago. Beyond angry that Chevy/GM has not recalled this car!!!

- Galloway, NJ, USA

problem #83

Sep 142024

Malibu

  • miles
Vacuum pump failure. Brakes failed while driving the car, brakes became manual power but was able to pull over safely. There was no previous warning or error codes. Car is currently at a Mr. Tire facility. The manager ran diagnostic code - "reduce engine power" error and found the cause as the vacuum pump. Due to the time of the failure, late Saturday 9/14/24, the part cannot be ordered until Monday from the local Chevy dealership. The facility will not know if there is additional engine damage until the part is remove and inspected. There is known issues with vacuum pumps failing and a class action lawsuit currently in ligation.

- Galloway, NJ, USA

problem #82

Sep 132024

Malibu

  • miles
I am having to replace the VACUUM PUMP for the second time. Each time the pump breaks it spreads contaminants inside the camshaft compartment causing further issues. This is a common problem according to the many complaints I've seen on auto sites. This should be a recall.

- Belmont, MS, USA

problem #81

May 012024

Malibu

  • miles
The electrical chip in my EBCM has a malfunction and the brakes will grab and grind at random times. Also at the time electronic stability control will mess up increasing the risk of a crash. Other malibu vehicles with the same year have had a recall on these parts. Mine however was not included but has the same malfunctioning part.

- Pinson , AL, USA

problem #80

Aug 012024

Malibu

  • miles
Brake vacuum booster failed resulting in the brakes failing.

- Brunswick, OH, USA

problem #79

Jul 172024

Malibu

  • miles
Brake Booster vacuum pump failed and pieces broke off in the engine.. it failed in the middle of driving with my [XXX] daughter.. the brakes padel was hard and was hard to stop.. could have caused a real bad accident even caused death if happened while driving.. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Missouri City, TX, USA

problem #78

Jul 172024

Malibu

  • miles
Brake booster vacuum pump failed and pieces of the pump broke off and in the engine..

- Missouri City, TX, USA

problem #77

Feb 292024

Malibu

  • miles
Vehicle engine light reported codes P050F, FE8:engine, and FE9. It was determined the Brake Booster Vacuum Pump was leaking oil and was faulty. It has been replaced and brakes better. Engine light went off. The other diagnostic by my mechanic showed the Oil Control Intake and Exhaust Variable Valve Timing (VVT) Solenoid needed to be replaced too.

- Miami, FL, USA

problem #76

Feb 042024

Malibu

  • miles
I am very upset right because I purchased this Chevy Malibu 2016 from Vroom. It was fine at first and then things start to go downhill. For starters my tire light came on first only a week after having the car, then the shift into was appearing on the dashboard as well as the engine light. Then my husband spent almost 2000 on the brakes because the car was making this horrible sound and I almost couldn't stop the car because the pedal was stuck and would not push down. Thank God no one was hurt. Then my car just shut off twice one day at a busy intersection, it went completely dead with my children in the car. This is a ongoing issue. Now I had a diagnostic test ran on my vehicle and it was said I needed a new motor only after having the car for only a year. This car is very dangerous and I wish they would take it off the market, because it will also reduce your speed while driving out of nowhere. Chevrolet should be responsible for all problems before they are aware of these issues!

- Jonesboro, GA, USA

problem #75

Aug 172023

Malibu

  • miles
I was driving on the highway started to exit the exit ramp at the top of the exit ramp. There-??s a stop sign. Want to stop for it previously to this my brakes were fine then I went to press on them to come to the final stop at the stop sign and they were super hard. and

- Greenville, MI, USA

problem #74

Aug 052023

Malibu

  • miles
I took my car to to Firestone to have the brakes checked because I had a stiff brake pedal and could only use my emergency brake to stop. They did a basic and advanced diagnostic and said that the brake booster that I have has been recalled and also other equipments on my car has been recalled and I must bring it to a dealership. I searched my VIN and nothing popped up even though months ago I was emailed a recall notice on the fuel pump system and Air bags and it has never been repaired in my car even from the past owners.There have been 10 recalls from Malibu's manufactured in 2016 and my car shows every sign and indication that it is one of those few selected. My VIN should be updated or investigated for parts in my vehicle that have been recalled. The Car stops when idle for two minutes or longer and shuts off the engine and air if you use the USB outlet there is a serious electrical problem which is also a safety hazard according to NHTSA guidelines.

- Irving, TX, USA

problem #73

Aug 012023

Malibu

  • miles
My 2016 chevy Malibu had brake vacuum pump failure. No warnings. Brake pedal got hard and could not stop. I was returning home with my 13 yr. old daughter from Tennessee and had to get it fixed so we could get home. Mechanic said this is a common problem and that there is a class action lawsuit on this problem with these cars about having a recall. This put me out of pocket $1986 dollars which is unacceptable and could have ruined my entire engine.

- Burbank, IL, USA

problem #72

Jul 282023

Malibu

  • miles
When pressing on break it goes straight to floor sometimes or locks up and throws service needed code and reduce power steering

- Concord, MI, USA

problem #71

Jul 162023

Malibu

  • miles
I just bought this car 2 weeks ago. Had to replace the windshield wiper pump. There are at least 10 TSBs on the vehicle I'm on disability I can't afford to fix all that. The rear hub bearing was barely making noise when I bought it. Now tire feels like it's going to fall off. I believe there's a TSB on when you put the car in park and shut it off then it's not going in to gear even though it said it's into gear so I have to get that fixed as well. Can't Chevy fix thermostats just like I have to fix my mistakes in life.

- Portage , IN, USA

problem #70

May 082023

Malibu

  • miles
#1 3rd brake light leaking into back seat and trunk manufacture bolts backed out and/or missing, can also cause water to get into the brake light which tends to cause 3rd brake light failure, increasing risk of a crash. #2 gear shift lever inner lock blocking the ability for user to shut the vehicle off, this can also cause the gear shift lever to indicate vehicle is in park, but the transmission may actually be in another gear. This can lead to damage to the transmission or increase the risk of a crash. A recall has been made for Chevy Malibu 2016-2020 but my VIN was not included. While my vehicle is experiencing these issues. Issue was confirmed by an independent service center. Shift to park message pop up on dash when attempting to shut vehicle off unsure of exact start date but started a few months ago. I have since been doing my research on issues and their solutions.

- Surry, VA, USA

Read the next 20 complaints »