6.9

fairly significant
Typical Repair Cost:
No data
Average Mileage:
104,450 miles
Total Complaints:
9 complaints

Most common solutions:

  1. not sure (9 reports)
Get notified about new defects, investigations, recalls & lawsuits for the 2005 Dodge Grand Caravan:

Unsubscribe any time. We don't sell/share your email.

problem #9

Apr 062018

Grand Caravan SXT 3.6L

  • Automatic transmission
  • 145,000 miles

Have another 2005 Dodge Caravan with the same issue, only it had a recall for fuel shut off float in the multifunction control value. It sticks which may result in the vehicle stalling after refueling. Which in essence they had replace the fuel tank. Now is is happening with the 2005 I am currently driving. Don't understand why one gets a recall and the other does not.

- yadogdurbinfamily, Bristol, US

problem #8

May 072014

Grand Caravan 3.3L

  • Automatic transmission
  • 101,125 miles

I really feel dodge should fix the issue at hand. really pain in the rear

- C W., Owosso, MI, USA

problem #7

Apr 152015

Grand Caravan LX V6

  • Automatic transmission
  • 109,000 miles

Really doesn't make me feel to safe. I wish Dodge would fix it.

- maryboberry, washington, DC, USA

problem #6

Dec 012013

Grand Caravan LXI 2.8L

  • Automatic transmission
  • 56,000 miles

Engine stalling out after fill up with gas: this is a problem that Dodge is aware of and will not address it. It's kind of like tough luck, that's what you get for buying a Dodge.

- dennyden, Englewood, FL, USA

problem #5

Mar 012014

Grand Caravan SXT 3.9sxt

  • Automatic transmission
  • 85,000 miles

EVERY fill-up, the car stalls 3-4 times as we try to leave the station. Almost had wrecks a few times as we tried to get back into traffic, van would buck and actually die. It always started back up OK, and after 3-4 times it was OK until the next fill-up. Sure makes you dread fill-ups for a weird reason!!!.

- Fawn D., Amarillo, TX, USA

problem #4

Jun 042014

Grand Caravan SXT 3.8L

  • Automatic transmission
  • 168,000 miles

It stalls as soon as I leave the gas pump area after refueling.

- Juan R., Trenton, NJ, USA

problem #3

Aug 212014

Grand Caravan LX

  • Automatic transmission
  • 100,050 miles

Engine shuts down within a couple minutes of filling up fuel tank. Most times happens at stop sign approaching roadway leaving gas station or on the highway once driving. This has happened at least 10 times with this vehicle always after filling.

- Tim K., Bellefonte, PA, USA

problem #2

May 042011

Grand Caravan SXT 3.8L

  • Automatic transmission
  • 95,514 miles

After filling up with gas the engine will run really rough and sometimes the engine will stall. This is a big issue to me for safety reasons. As I pull out into traffic from the gas station or from a intersection it will jerk and sometimes stalls. So I am sitting in traffic trying to start the engine again. One of these times I will get hit by another vehicle. This is a VERY big safety issue for me.

- bgage, Luck, WI, USA

problem #1

Dec 032009

Grand Caravan

  • Automatic transmission
  • 80,000 miles

Talked to dealer and they said to fix this small problem they would have to replace the entire gas tank. Approx cost is $800. Apparently the fuel filter is what is causing the car to stall and it is inside the gas tank. Brillant, because you never have to replace the fuel filter. Who thought of this?

- Chris A., Lebanon, OH, USA